*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.
Electrical system
While driving, the vehicle displayed three simultaneous warnings â âDrive system malfunction, safely stop vehicle,â âElectrical system malfunction, restart not possible, contact service,â and âAll-wheel drive malfunction, limited stabilityâ â and lost propulsion completely. This occurred on at least two separate occasions while driving. After each event, the vehicle would not restart for approximately 15 minutes, after which it began working again temporarily. The vehicle was taken to an authorized Audi dealer, which found no coolant in the front drive motor and diagnosed a fault in the SX6 high-voltage battery switching module, which controls connection of the high-voltage…
Sep 4, 2026Electrical system
The vehicle is experiencing an intermittent but active 'Electrical system: malfunction!' safety alert on the dashboard and myAudi app, caused by an internal high-voltage battery cell circuit fault (Diagnostic Trouble Code P0DB400 / U04A300) and a failure in the battery thermal runaway detection system. When the fault occurs, the vehicle suffers a complete loss of regenerative braking, severely affecting stopping predictability and vehicle handling. An authorized Audi dealership (Audi West Chester) confirmed the internal module failure under TAC Case NF-1675032 and directed a full battery module replacement. Diagnostic scans have confirmed two highly critical manufacturer trouble codes:…
Jul 29, 2026Unknown or other
From time to time the driver's door does not latch completely so the door is only partially closing. Dealer was able to duplicate the problem but will not replace (estimated cost for new door latch is just under $800.) at their expense. It appears that others have had the same problem. When driving the car air rushes into the vehicle as the door is not fully shut. I worry that this problem could be very serious should I be in an accident with a partially closed door rather than a fully closed door. The problem first appeared early in the winter and seems to be getting worse.
Jan 5, 2026Service brakes
Brakes were replaced by Audi with genuine Audi parts and within 2 months, the brake rotors became warped, requiring a resurfacing. After driving another 2 months, they once again became warped, making the entire car lurch and shake during braking.
Apr 1, 2026Service brakes
My drive motors keep failing (so far 3 times) and my emergency braking abruptly stops my vehicle when no true danger is present and Iâm in complete control of my vehicle. Currently my vehicle has a constant shuddering while braking which doesnât feel safe because itâs not braking properly. Audi regional and the dealership refuses to take ownership of the issue. Dealer has confirmed issue and replaced drive motors three times. Each time my braking system has gotten worse. The part was replaced each time under warranty but Audi has not confirmed that a fix has been found and corrected. This means it can occur again and abruptly which can absolutely be a safety hazard as it was each time…
Mar 1, 2024Electrical system
The contact owns a 2022 Audi E-Tron. The contact stated that while driving at various speeds, the vehicle independently switched to SAFE Mode and failed to properly accelerate while depressing the accelerator pedal. Additionally, the mileage range was reduced, and the battery recharging time increased. The failure started after the vehicle was repaired under the NHTSA Campaign Number: 23V867000 (ELECTRICAL SYSTEM). The vehicle was taken to the local dealer, but no failure was found with the vehicle. The vehicle was later taken to an independent mechanic who reported that the amperage of the battery had been reduced from 400 amps to 130 amps. The manufacturer was notified of the failure, but…
Jul 23, 2025 · 16,000 milesElectrical systemFire
CATASTROPHIC ELECTRICAL FAILURE - SMOKE IN CABIN While driving with passengers, dashboard displayed "ELECTRICAL FAILURE - PULL OVER WHEN SAFE" followed by loud explosive POP and cabin filled with SMOKE. ROOT CAUSE: Prior undisclosed collision damage. Dealer (Morrie's Golden Valley Cadillac) removed front bumper in June 2025 (Repair Order #78683), then sold vehicle as "no accidents" in August 2025. Subsequent inspection revealed cut wiring and improper repairs (Invoice #94609). CURRENT STATUS: Vehicle inoperable 3+ months. Audi corporate technicians have repaired major problem however vehicle still has charging issues that happened right before the catastrophic failure unable to repair.…
Nov 25, 2025Electrical system
The vehicles software system regularly crashes and/or does not load leaving all camera functionality and safety alerts inoperable. I have had the vehicle in to address these concerns 5 times with no resolve from the manufacturer. Even with video evidence they claim the vehicle is functioning as intended. This is in direct violation of FMVSS 111 as the rearview camera is regularly not available. Sometimes the system reboots within seconds and sometimes it takes 10 minutes or more.
Aug 13, 2025
Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.