The 2009 Audi Q7 has 3 safety recalls and 21 owner complaints on file with NHTSA. The most-reported problem area is fuel/propulsion system (7 complaints).
Recalls3safety recalls
Complaints21filed by owners
Crashes · fires0 · 1reported in complaints
Injuries · deaths2 · 0reported in complaints
2009 Audi Q7 in an NHTSA crash test
Safety recalls
Equipment › Other › Labels
NHTSA recall 23V086000 · Feb 15, 2023 · 12,100 vehicles
Problem: Volkswagen Group of America, Inc. (Audi) is recalling certain 2009-2015 Q7 vehicles. The Gross Axle Weight Rating (GAWR) listed on the certification label is incorrect, which can allow the vehicle to be overloaded. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 110, "Tire Selection and Rims," and Part 567, "Certification."
Risk: An overloaded vehicle can increase the risk of a crash.
Fix: Dealers will install an overlay label containing the correct rear GAWR on top of the existing safety certification label, free of charge. Owner notification letters were mailed April 24, 2023. Owners may contact Audi's customer service at 1-800-253-2834. Audi's number for this recall is 50G5.
Components: Equipment › Other › Labels; Tires
Fuel system, gasoline › Delivery › Fuel pump
NHTSA recall 18V818000 · Nov 19, 2018 · 5,987 vehicles
Problem: Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2007-2012 Audi Q7 and 2009-2012 Audi Q5 vehicles, previously repaired under NHTSA recall 16V-660. These vehicles were previously repaired with an interim repair of installing butyl tape to the fuel pump flange, until replacement remedy parts became available.
Risk: The butyl tape may not prevent fuel from leaking. A fuel leak in the presence of an ignition source can increase the risk of a fire.
Fix: Volkswagen will notify owners, and dealers will replace the fuel pump flange and install butyl tape, free of charge. The recall began December 28, 2018. Owners may contact Audi customer service at 1-800-253-2834. Volkswagen's number for this recall is 20BJ.
Problem: Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2009-2012 Audi Q5, and 2007-2012 Audi Q7 vehicles equipped with gasoline engines. The fuel pump flange on the affected vehicles may crack, allowing fuel to leak.
Risk: A fuel leak in the presence of an ignition source increases the risk of a fire.
Fix: Audi will notify owners, and dealers will inspect the flange, replacing any flanges that are cracked. If the flange is not cracked, dealers will clean the pump flange and install a butyl rubber band to protect the pump. These repairs will be made free of charge. The recall began November 9, 2016. Owners may contact Audi customer service at 1-800-253-2834. Volkswagen's number for this recall is 20W9.
Recall repairs are free at any authorised dealer. A recall listed here may already have been fixed on a particular car: enter its 17-character VIN at nhtsa.gov/recalls to see open recalls.
Crash test ratings
NHTSA side barrier crash test
2009 Audi Q7 4-DR. w/SAB
Overall
Not Rated
Frontal crash
Not Rated
Side crash
Not Rated
Rollover
★★★★★
Rollover risk
18.5%
Forward collision warning: Optional · Lane departure warning: No
NHTSA 5-Star Safety Ratings (New Car Assessment Program). Ratings are comparable only between vehicles of similar size and weight, and ratings from 2011 on use tougher tests than earlier years. Photos: NHTSA.
Fuel economy
Q7 Diesel
20mpg combined
City / highway
17 / 24 mpg
Fuel
Diesel
3 L · 6 cyl · Automatic (S6) · All-Wheel Drive · about $4,800/year to fuel
Q7
16mpg combined
City / highway
14 / 20 mpg
Fuel
Premium Gasoline
3.6 L · 6 cyl · Automatic (S6) · 4-Wheel or All-Wheel Drive · about $5,150/year to fuel
Q7
15mpg combined
City / highway
13 / 18 mpg
Fuel
Premium Gasoline
4.2 L · 8 cyl · Automatic (S6) · 4-Wheel or All-Wheel Drive · about $5,500/year to fuel
EPA estimates from fueleconomy.gov for each engine and transmission sold. Annual cost is the EPA's estimate for 15,000 miles a year at its current fuel and electricity price assumptions. Your results will vary.
*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.
Recent owner complaints
Jul 16, 2021Fuel/propulsion system I purchased this vehicle used on 7/14/21 from Audi of Des Moines. Not even 3 days after purchasing, the rear view mirror fell down, the back of the front driver and passenger seats came off, the car had been hail damaged at the dealership but they didn't inspect the entire car so I have to replace the windshield and front license plate plastic grill attachment. However, my biggest concern is the smell of Gasoline after I drive the vehicle, every time. There is a strong odor of gasoline near both rear doors/wheels that can be smelled after stepping out of the vehicle and the engine has been lagging. I have filled the gas tank 3 times and each time used premium gasoline. I can't get any…
Jun 27, 2021 · fire · 2 injuriesEngine I was driving my 2009 Audi Q7 last June 27,2021 at 5 pm in interstate 5N my speed is 70mph when i heard a beep sound , Air bag and Hood light on flashes in the dash board and i decided to pull over on the shoulder lane when my wife noticed that smoke coming out in front of the engine, i stopped the engine but i can`t pull the key and my set belt locked to where i can`t release it , my wife help me to get out from the set belt and she managed gave forced to her door just to open it , I was able to reached the lever to open the hood where smoke & fire coming out from the engine , I`m trying to control the fire but fire spread out rapidly inside the car and less than a minute fire covered the…
Sep 17, 2020 · 100,200 milesVisibility/wiper WHILE DRIVING IN MODERATE RAIN WITH THE WINDSHIELD WIPERS ON, THE PASSENGER SIDE WINDSHIELD WIPER FLEW OFF. I ORDERED A NEW PASSENGER SIDE WINDSHIELD WIPER AND IT WORKED FOR A MONTH. THEN THE PASSENGER SIDE WIPER FROZE DURING USE, CAUSING THE DRIVER SIDE WIPER TO HIT IT.
Apr 7, 2020 · 140,000 milesFuel/propulsion system FUEL LEAKING TOP OF LEFT SIDE FUEL TANK AT FUEL PUMP CONNECTIONS
Jan 7, 2020Electrical system CAR BOSE AMPLIFIER RECEIVES WATER FROM PANORAMA ROOF DAMAGING THE ENTIRE PINS SYSTEM, GPS AND BLUETOOTH SYSTEM.
Mar 17, 2019 · 124,000 milesEngine I HAVE A 2009 AUDI Q7 DIESEL BOUGHT FROM DEALERSHIP MARCH 2019 AFTER IT HAD BEEN SOLD TO THE PUBLIC ONCE AUDI DID EMISSIONS RECALLS , AFTER I BOUGHT THIS VEHICLE HAD ISSUES WITH IT 10 DAYS AFTER I BOUGHT IT I TOOK IT BACK DEALERSHIP WANTS TO HAVE NOTHING TO DO WITH HELPING ME EVEN THOUGH IT STILL HAS AN EXTENDED WARRANTY FOR 4 YEARS MORE FROM THE MANUFACTURER, I HAVE A FLASHING GLOWPLUG AND LIMP MODE VEHICLE THAT WHEN DRIVING IT AND GLOW PLUG GOES ON WHILE I AM ON THE ROAD VEHICLE SLOWS DOWN FROM GOING 65MPH TO APPROXIMATELY UNDER 15MPH IN JUST SECONDS ENGINE LOSES POWER AND ITS A SAFETY HAZARD WHILE ON THE FREEWAY . AUDI DEALER CLAIMS I HAVE FUEL CONTAMINATION BUT WHEN ASKED TO PROVE TO ME…
Sep 1, 2019Structure › Body SUNROOF DRAIN LINE CONNECTOR, WATER LEAK ON TOP OF THE RADIO BOSE AMPLIER
Jul 20, 2019 · 103,000 milesFuel/propulsion system NOTICED A STRONG GASOLINE SMELL IN THE ENCLOSED GARAGE WHERE THE VEHICLE IS KEPT. RESEARCHED THE ISSUE ONLINE AND DISCOVERED SEVERAL INSTANCES WHERE THE PRESSURIZED FUEL FILTER ASSEMBLY ON TOP OF THE FUEL TANK (LEFT SIDE, BENEATH SECOND ROW REAR SEAT) DEVELOPS CRACKS IN THE PLASTIC AND EMITS A FINE SPRAY OF FUEL. I REMOVED THE SECOND ROW SEAT AND DISCOVERED A POOL OF LIQUID GASOLINE ON TOP OF THE PRESSURIZED FUEL FILTER. AUDI HAS AN EXISTING RECALL UNDER NHTSA CAMPAIGN NUMBER: 16V660000, WHICH MERELY "INSTALLS A BUTYL RUBBER BAND TO PROTECT THE PUMP" AND WHICH I HAVE ALREADY HAD PERFORMED AT THE DEALERSHIP. THIS IS A DIFFERENT ISSUE IN THAT THE FUEL FILTER ITSELF DEVELOPS CRACKS AND…
Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.
NHTSA defect investigations
EA11003 · opened Feb 7, 2011 · closed Mar 27, 2015High-Pressure Fuel Pump Failure The Office of Defects Investgation (ODI) opened EA11-003 on February 7, 2011, based on 160 complaints to ODI and Volkswagen involving high pressure fuel pump (HPFP) failures in model year (MY) 2009 through 2010 Volkswagen Jetta and Golf and Audi A3 TDI vehicles and questions regarding fuel sample results provided by Volkswagen as part of its response to PE10-034.During EA11-003, ODI analyzed design information, field experience and test data for MY 2009 through 2012 Volkswagen Jetta, Golf and Touareg and Audi A3 and Q7 vehicles equipped with TDI engines. Volkswagen has not identified any design or manufacturing defects in the subject TDI Clean Diesel pumps and has stated that the subject pumps were designed, tested and approved for use in the United States market, with substantial design margins for fuels that are out of specification.Volkswagen believes that misfueling with gasoline is…
