Model year record

2004 Buick Rainier recalls & problems

The 2004 Buick Rainier has 2 safety recalls and 158 owner complaints on file with NHTSA. The most-reported problem area is electrical system (84 complaints).

Recalls2safety recalls

Complaints158filed by owners

Crashes · fires9 · 4reported in complaints

Injuries · deaths10 · 0reported in complaints

Safety recalls

Exterior lightingMay 5, 2005

Turn signal

Recall 05V198000286,478 vehiclesopened after NHTSA action (ODI)

Problem: ON CERTAIN TRUCKS AND SPORT UTILITY VEHICLES, THE DRIVER WISHING TO SIGNAL A TURN BY MOVING THE DIRECTIONAL SIGNAL LEVER, (UP OR DOWN) MAY CAUSE THE FRONT MARKER/TURN LIGHTS AND REAR TURN LIGHTS TO FLASH IN A MANNER SIMILAR TO HAZARD WARNING, RATHER THAN FLASHING ON THE DESIRED SIDE ONLY.
Risk: THE DRIVER MAY NOT BE ABLE TO CLEARLY SIGNAL THEIR INTENTIONS TO TURN, CHANGE TRAVEL LANES, OR POTENTIALLY WARN OTHERS OF AN IMPAIRED VEHICLE OPERATING CONDITION INCREASING THE RISK OF A CRASH.
Fix: DEALERS WILL REPLACE THE SUSPECT FLASHER MODULES WITH A NEW FLASHER MODULE DESIGNED WITH SEALED RELAYS AND MORE DURABLE CONTACT MATERIAL INSIDE OF THE RELAYS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 4, 2005. ISUZU BEGAN MAILING OWNER LETTERS ON AUGUST 4, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, ISUZU AT 1-800-255-6727, BUICK AT 1-866-608-8080, AND OLDSMOBILE AT 1-800-630-6537.

Exterior lightingNov 1, 2004

Brake lights

Recall 04V527000871,473 vehiclesopened after NHTSA action (ODI)

Problem: ON CERTAIN SPORT UTILITY VEHICLES, VIBRATION AND HEAT MAY CAUSE THE TAIL LAMP/STOP LAMP BULB TO LOOSEN IN ITS SOCKET. IF THIS OCCURS, THE BULB MAY FLICKER AND EVENTUALLY BECOME INOPERATIVE.
Risk: AN INOPERATIVE BRAKE LAMP WILL NOT CONVEY THE DRIVER'S INTENTION OF STOPPING TO DRIVERS IN FOLLOWING VEHICLES, AND AN INOPERATIVE REAR TURN SIGNAL LAMP WILL NOT CONVEY THE DRIVER'S INTENTION TO TURN TO DRIVERS IN FOLLOWING VEHICLES. BOTH OF THESE FAILURES CAN INCREASE THE RISK OF A CRASH.
Fix: DEALERS WILL INSPECT THE TAIL LAMP/STOP LAMP ASSEMBLIES, AND IF NECESSARY, REPLACE THEM. THE RECALL BEGAN ON NOVEMBER 22, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438, OLDSMOBILE AT 1-800-630-6537, BUICK AT 1-866-608-8080, OR GMC AT 1-866-996-9463.

Recall repairs are free at any authorised dealer. A recall listed here may already have been fixed on a particular car: enter its 17-character VIN at nhtsa.gov/recalls to see open recalls.

Crash test ratings

2004 Buick Rainier 4-DR.

OverallNot Rated

Frontal crash	Not Rated
Side crash	Not Rated
Rollover	★★★★★
Rollover risk	19.1%

2004 Buick Rainier 4-DR. w/SAB

OverallNot Rated

Frontal crash	Not Rated
Side crash	Not Rated
Rollover	★★★★★
Rollover risk	19.1%

NHTSA 5-Star Safety Ratings (New Car Assessment Program). Ratings are comparable only between vehicles of similar size and weight, and ratings from 2011 on use tougher tests than earlier years. Photos: NHTSA.

Fuel economy

Rainier 2WD

16mpg combined

City / highway	14 / 19 mpg
Fuel	Regular Gasoline

4.2 L · 6 cyl · Automatic 4-spd · Rear-Wheel Drive · about $4,200/year to fuel

Rainier 2WD

16mpg combined

City / highway	14 / 18 mpg
Fuel	Regular Gasoline

5.3 L · 8 cyl · Automatic 4-spd · Rear-Wheel Drive · about $4,200/year to fuel

Rainier AWD

16mpg combined

City / highway	14 / 19 mpg
Fuel	Regular Gasoline

4.2 L · 6 cyl · Automatic 4-spd · 4-Wheel or All-Wheel Drive · about $4,200/year to fuel

Rainier AWD

15mpg combined

City / highway	13 / 17 mpg
Fuel	Regular Gasoline

5.3 L · 8 cyl · Automatic 4-spd · 4-Wheel or All-Wheel Drive · about $4,450/year to fuel

EPA estimates from fueleconomy.gov for each engine and transmission sold. Annual cost is the EPA's estimate for 15,000 miles a year at its current fuel and electricity price assumptions. Your results will vary.

What owners report

Problem area	Complaints	Crashes	Fires	Injuries	Typical mileage*
Electrical systemInstrument cluster/panel; Wiring › Interior/under dash	84	2	4	3	59,142 mi
Exterior lightingHeadlights; Brake lights	21	1	0	0	102,500 mi
Power trainAutomatic transmission; Transfer case (4-wheel drive)	15	0	0	0	39,000 mi
Vehicle speed control	12	2	0	1	42,000 mi
Air bagsFrontal; Frontal › Driver side › Inflator module	12	9	0	16	57,000 mi
Fuel system, gasolineStorage › Tank assembly › Filler pipe and cap	9	0	0	0	97,400 mi
Fuel/propulsion system	7	0	0	0	101,182 mi
Engine and engine coolingEngine; Exhaust system › Emission control	6	0	0	0	40,701 mi
SuspensionFront	6	0	0	0	82,300 mi
StructureFrame and members › Underbody shields	5	0	0	0	1,000 mi
VisibilityDefroster/defogger/hvac system; Defroster/defogger/hvac system › Fan/motor	4	0	1	0	43,066 mi
SteeringRack and pinion; Hydraulic power assist › Power steering fluid	4	0	0	0	—

*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.

Recent owner complaints

Exterior lighting
TL* THE CONTACT OWNS A 2004 BUICK RAINIER. THE CONTACT STATED THAT THE HEADLIGHTS TURNED OFF INTERMITTENTLY WITHOUT WARNING. THE CONTACT STATED THAT THE HEADLIGHTS REMAINED OFF FOR APPROXIMATELY SIX MINUTES. WHEN THE LIGHTS TURNED BACK ON, THE LIGHTING WAS DIM. THE VEHICLE WAS TAKEN TO J.D. BYRIDER (5101 NEW BERN AVE, RALEIGH, NC 27610) WHERE THEY REPLACED THE REPLACED THE HEADLIGHT DRIVER MODULE ON TWO DIFFERENT OCCASIONS, BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOT CONTACTED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 150,471.
Sep 18, 2018 · 150,471 miles
Vehicle speed controlCrash1 injury
TL* THE CONTACT OWNED A 2004 BUICK RAINIER. WHILE DRIVING APPROXIMATELY 30 MPH IN THE RAIN, THE VEHICLE HYDROPLANED. THE CONTACT LOST CONTROL OF THE VEHICLE AND CRASHED INTO A WALL. AS A RESULT, THE CONTACT WAS RENDERED UNCONSCIOUS AND TRANSPORTED TO THE HOSPITAL VIA AMBULANCE. THE CONTACT'S HEAD STRUCK THE DRIVER'S SIDE WINDOW AND THE CONTACT REMAINED IN A COMA FOR SEVERAL MONTHS. THE AIR BAGS DID NOT DEPLOY. A POLICE REPORT WAS FILED. THE CONTACT SUSTAINED INJURIES TO THE RIGHT SIDE OF THE HEAD, WHICH CAUSED WALKING COMPLICATIONS AND A LOSS OF FEELING IN THE RIGHT SIDE OF THE BODY. IN ADDITION, THE CONTACT SUFFERED A LOSS OF SIGHT IN THE RIGHT EYE DUE TO A CRUSHED SKULL. THE VEHICLE WAS…
Apr 29, 2016
Fuel/propulsion system
I NOTICED IN NOVEMBER OF 2016 MY BUICK RAINNER WAS SMELLING LIKE GASOLINE AFTER I GOT OUT AND LEFT IT RUNNING WHILE I WAS DROPPING STUFF AT HOME FROM WORK. WHEN I GOT BACK IN MY VEHICLE I DIDN'T SMELL ANYTHING, BUT COULD SMELL OUTSIDE THE VEHICLE. I WENT ABOUT ANOTHER 10 MILES LATER TO MY DESTINATION AND PARK. 20 MINS LATER WENT BACK OUT AND CRANK MY VEHICLE AND COULD SMELL A STRONG GAS ODOR COMING THRU VENTS ON THE INSIDE OF MY SUV. I GOT OUT AND LOOKED UNDER MY HOOD AND DIDN'T SEE ANYTHING WRONG UNDER THE HOOD. WHEN I WALKED TOWARD THE BACK OF THE VEHICLE THE GAS SMELL WAS EVEN STRONGER. I CHECKED THE FUEL / GAS TOP TO SEE I LEFT IT OFF BUT IT WASN'T. THEN I LOOKED UNDER MY VEHICLE AND…
Nov 19, 2016 · 174,000 miles
Exterior lighting
HEADLIGHTS FAIL INTERMITTENTLY WHILE DRIVING. WHILE DRIVING LAST NIGHT THE LOW BEAM HEADLIGHTS WENT OUT. THE HIGH BEAMS STILL WORKED. THIS IS ABOUT THE SIXTH TIME THIS HAS HAPPENED. I CHANGED OUT THE HEADLIGHT RELAY JUST BEFORE THIS OCCURRED AS I HAD SEEN A RECALL ON 2006 AND 2007 RAINIERS SHOWING THIS AS THE PROBLEM. AFTER A SHORT TIME THE HIGH BEAMS ALSO WENT OUT. I PARKED AND TURNED THE ENGINE OFF FOR A WHILE AND WHEN I RESTARTED THE HIGH BEAMS WERE WORKING AGAIN BUT NOT THE LOW BEAMS. I WAS DOING A COMBINATION OF STREET AND HIGHWAY DRIVING AND IT APPEARS TO BE UNRELATED TO ANY ROAD CONDITIONS AS THIS HAS HAPPENED ON BOTH HIGHWAYS AND CITY STREETS.
Apr 25, 2018 · 116,400 miles
Fuel/propulsion system
TL* THE CONTACT OWNS A 2004 BUICK RAINIER. AFTER PARKING THE VEHICLE, A FUEL ODOR WAS NOTICED OUTSIDE THE VEHICLE. ONCE THE CONTACT ENTERED THE VEHICLE, THE ODOR WAS STRONGER. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THEY DIAGNOSED THAT THE FUEL LINES WERE ROTTED AND THE FUEL PUMP NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND INFORMED THE CONTACT ABOUT THE EXTENDED WARRANTY. THE APPROXIMATE FAILURE MILEAGE WAS 109,722.
Jan 26, 2018 · 109,722 miles
Exterior lighting
LOW BEAM HEADLIGHTS FAILURE BOTH AT THE SAME TIME. OCCURRED ON TWO SEPARATE OCCASIONS. FIRST TIME A YEAR OR SO AGO, LOW BEAM RELAY REPLACED BY BEST RECOLLECTION
Dec 21, 2017 · 200,000 miles
Electronic stability control (esc)
TRANSFER CASE SHIFT MODULE CONTROL MODULE
Apr 19, 2006 · 5,000 miles
Visibility/wiper
LOW BEAMS ON LIGHTING GOES OUT FOR NO APPARENT REASON. THIS HAS HAPPENED TWO TIMES IN THE LAST TWO WEEKS. DEALERSHIP SAYS THEY JUST CAN'T FIND ANYTHING WRONG. ALTHOUGH THEY HAD ANOTHER VEHICLE THERE WITH SAME PROBLEM. THIS SEEMS TO BE A RECURRING PROBLEM WITH GM SUV'S. MY 1994 GMC DID THE SAME THING AND I HEARD REPORTS OF OTHER GMC'S DOING THE SAME THING. NOT GOOD ON INTERSTATES AT NIGHT.
Jul 21, 2017 · 114,000 miles

Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.

NHTSA defect investigations

Loss of HeadlightsClosed
The subject vehicles are model year (MY) 2002-2009 Chevrolet Trailblazer, GMC Envoy, 2004-2007 Buick Rainier, 2003-2008 Isuzu Ascender, 2005-2009 Saab 9-7X, 2002-2004 Oldsmobile Bravada, 2003-2006 Chevrolet SSR, 2005-2009 Buick Lacrosse, and 2006-2008 Pontiac Grand Prix. This scope includes the Trailblazer/Envoy variants: 2002-2006 Envoy XL/Trailblazer EXT and 2004-2005 Envoy XUV. The original scope of this investigation was expanded to include all vehicles equipped with the subject Headlight Driver Module (HDM). The focus of the investigation was to determine whether actions performed by General Motors adequately addressed any unreasonable risk to motor vehicle safety in the subject vehicles concerning the headlights and the HDM that controls them.Under normal electrical load and environmental conditions, the HDM can overheat inside the Underhood Electrical Center (UEC). This can cause…
RQ17002 · opened Apr 24, 2017 · closed Mar 29, 2021
FUEL PUMP MODULE LEAKS GASOLINEClosed
DURING THE COURSE OF THIS EA INVESTIGATION, ODI OBSERVED THAT THE MAJORITY OF THE COMPLAINTS (88%) AND WARRANTY CLAIMS (94%) WERE REPORTED FOR VEHICLES THAT ARE REGISTERED FOR USE IN THE SALT BELT REGION OF THE US.THIS AREA INCLUDES 20 STATES IN THE NORTHEAST, MID ATLANTIC AND THE MIDWEST REGIONS AND THE DISTRICT OF COLUMBIA.CONSUMERS IN THE SALT BELT REGION REPORTED TO ODI THAT THEY COULD SMELL FUEL VAPORS IN THEIR VEHICLES WHILE DRIVING.UPON FURTHER EXAMINATION OF THEIR VEHICLES, THEY DISCOVERED THAT FUEL VAPORS WERE COMING OUT OF THE TOP OF THE FUEL TANK. THIS CONDITION IS CAUSED BY CORROSION OF THE RETURN AND SENDER LINES OF THE FUEL PUMP MODULE.WATER AND ROAD SALT COLLECT ON TOP OF THE FUEL PUMP LEADING TO SMALL PINHOLES APPEARING ON THE FUEL LINES.FUEL MAY LEAK AND COLLECT ON TOP OF THE MODULE AND/OR SPILL ONTO THE GROUND.THE DATA EVALUATED UNDER THIS INVESTIGATION REFLECT A…
EA07009 · opened Jul 10, 2007 · closed Aug 28, 2008
BRAKE LAMP FAILUREClosedLed to recall 04V527000
GM STATES THAT SOME BRAKE/TAIL LAMP BULBS CAN PREMATURELY BECOME INOPERATIVE DUE TO MALFUNCTIONING BRAKE/TAIL LAMP SOCKETS.ON MARCH 2, 2004, GM INITIATED A 6-YEAR/72,000 MILE SPECIAL POLICY FOR 989,487 SUBJECT VEHICLES TO INSPECT AND REPLACE THE REAR BRAKE/TAIL LAMP BULB SOCKET ASSEMBLIES.ON APRIL 4, 2004, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION (PE04-032) BASED ON CONSUMER COMPLAINTS ALLEGING BRAKE LIGHTS NOT OPERATING WHEN THE BRAKE PEDAL IS DEPRESSED.ON AUGUST 3, 2004 ODI UPGRADED PE04-032 TO AN ENGINEERING ANALYSIS (EA04-021).BY LETTER DATED OCTOBER 27, 2004 GM NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA # 04V527) COVERING SUBJECT VEHICLES THAT WERE NOT ALREADY REPAIRED UNDER GM'S SPECIAL POLICY.MY 2004 SUBJECT VEHICLES BUILT AFTER AUGUST 8, 2003 CONTAIN IMPROVED BRAKE LAMP ASSEMBLIES AND ARE NOT INCLUDED IN THE RECALL.GM DEALERS WILL…
EA04021 · opened Aug 3, 2004 · closed Nov 4, 2004