The 1995 Chrysler Cirrus has 11 safety recalls and 369 owner complaints on file with NHTSA. The most-reported problem area is service brakes, hydraulic (150 complaints).
Recalls11safety recalls
Complaints369filed by owners
Crashes · fires45 · 5reported in complaints
Injuries · deaths33 · 0reported in complaints
Safety recalls
Suspension › Front › Control arm › Lower arm
NHTSA recall 10E059000 · Dec 27, 2010 · 22,689 vehicles
Problem: FEDERAL-MOGUL IS RECALLING CERTAIN REPLACEMENT CONTROL ARM ASSEMBLIES, PART NUMBERS K7425, 10945, FA4510X, K7427, 10946, AND FA4611X, SOLD FOR USE ON VARIOUS PASSENGER VEHICLES LISTED ABOVE. THE BALL JOINT ON THE CONTROL ARM ASSEMBLY CAN FAIL CAUSING THE BALL STUD TO WEAR THROUGH THE CONTROL ARM HOUSING RESULTING IN NOISE AND/OR SEPARATION OF THE BALL STUD FROM THE HOUSING.
Risk: IF THERE IS A SEPARATION OF THE BALL STUD FROM THE HOUSING, THE DRIVER CAN LOOSE STEERING CONTROL, POSSIBLY RESULTING IN A VEHICLE CRASH.
Fix: FEDERAL-MOGUL WILL NOTIFY OWNERS OF RECORD AND REPLACE THE AFFECTED CONTROL ARMS FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JANUARY 28, 2011. OWNERS MAY CONTACT FEDERAL-MOGUL AT 1-877-489-6659.
Suspension › Front › Control arm › Lower ball joint
NHTSA recall 09E056000 · Oct 9, 2009 · 5,787 vehicles
Problem: QUALIS AUTOMOTIVE IS RECALLING CERTAIN AFTERMARKET BALL JOINTS SOLD FOR USE ON CERTAIN PASSENGER VEHICLES. THE SOCKET MAY HAVE BEEN EXCESSIVELY HARDENED WHICH COULD CAUSE IT TO CRACK NEAR THE RETAINING RING GROOVE ALLOWING THE BALL STUD TO SEPARATE UNDER IMPACT LOAD. THE SUBJECT BALL JOINTS WERE SOLD AS FOUR PART NUMBERS, D10945, D10946, G10945, AND G10946. THE AFFECTED CONTROL ARMS, D10945 AND D10946, ARE STAMPED WITH THE FOLLOWING DATES ON THE BALL JOINTS: 134308, 135708, 100109, 102709, 104109, 105509, 107609, 108909, 110309, 113209, AND 116609. THE G10945 AND G10946 ARE THE SAME PART AS THE D10945 AND D10946 RESPECTIVELY. THEY ARE LABELED DIFFERENTLY DEPENDING ON THE AFTERMARKET CUSTOMER.
Risk: SEPARATION OF THE BALL STUD FROM THE SOCKET OF THE BALL JOINT HOUSING WOULD ALLOW THE CONTROL ARM TO COLLAPSE AND THE WHEEL TO FOLD IN CAUSING LOSS OF STEERING CONTROL, POSSIBLY RESULTING IN A CRASH.
Fix: QUALIS AUTOMOTIVE WILL REPLACE THE BALL JOINTS FREE OF CHARGE. THE SAFETY RECALL BEGAN ON NOVEMBER 9, 2009. OWNERS MAY CONTACT QUALIS AUTOMOTIVE AT 1-800-493-4128.
Fuel system, gasoline › Delivery › Fuel pump
NHTSA recall 06E091000 · Nov 2, 2006 · 24,358 vehicles
Problem: CERTAIN AIRTEX FUEL PUMP MODULES, P/NOS. E7089M, E7094M, E7113M, AND E7129M, MANUFACTURED BETWEEN JUNE 1 AND SEPTEMBER 24, 2006. THESE FUEL PUMP MODULES WERE SOLD AS AFTERMARKET FOR USE IN CERTAIN DAIMLERCHRYSLER VEHICLES LISTED ABOVE. SILICONE MATERIAL USED IN MANUFACTURE OF THE FLAPPER VALVE WAS OUT-OF-SPECIFICATION, LEADING TO EXCESS SWELL OF THE FLAPPER VALVE RESTRICTING THE FLOW OF FUEL TO THE FUEL PUMP MODULE.
Risk: FUEL RESTRICTION COULD RESULT IN LOSS OF POWER AND/OR ENGINE STALL, POSSIBLY RESULTING IN A VEHICLE CRASH.
Fix: AIRTEX WILL NOTIFY OWNERS AND REPLACE THE DEFECTIVE FUEL PUMP MODULES FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT AIRTEX TOLL-FREE AT 1-866-867-3759.
Fuel system, gasoline › Delivery › Fuel pump
NHTSA recall 06E088000 · Oct 23, 2006 · 39,243 vehicles
Problem: CERTAIN TIGAS FUEL PUMP MODULES MANUFACTURED BETWEEN JUNE 1 AND SEPTEMBER 24, 2006, SOLD UNDER VARIOUS BRAND NAMES AND P/NOS. THESE FUEL PUMP MODULES ARE SOLD AS AFTERMARKET FOR USE IN CERTAIN DAIMLERCHRYSLER VEHICLES LISTED ABOVE. SILICONE MATERIAL USED IN MANUFACTURE OF THE FLAPPER VALVE WAS OUT-OF-SPECIFICATION, LEADING TO EXCESS SWELL OF THE FLAPPER VALVE RESTRICTING THE FLOW OF FUEL TO THE FUEL PUMP MODULE.
Risk: FUEL RESTRICTION COULD RESULT IN LOSS OF POWER AND/OR ENGINE STALL, POSSIBLY RESULTING IN A VEHICLE CRASH.
Fix: TI AUTOMOTIVE WILL NOTIFY OWNERS AND REPLACE THE DEFECTIVE FUEL PUMP MODULES FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 6, 2006. OWNERS MAY CONTACT TI AUTOMOTIVE TOLL-FREE AT 1-877-461-1834.
Power train › Automatic transmission › Lever and linkage › Floor shift
NHTSA recall 04V021000 · Jan 13, 2004 · 2,315,768 vehicles · opened after NHTSA action (ODI)
Problem: ON CERTAIN PASSENGER VEHICLES, THE FLOOR SHIFTER IGNITION-PARK INTERLOCK MAY FAIL AND ALLOW THE SHIFTER TO BE MOVED OUT OF THE PARK POSITION WITH THE KEY REMOVED. AN INOPERATIVE INTERLOCK MAY ALSO ALLOW THE KEY TO BE REMOVED WHEN THE SHIFTER HAS NOT BEEN PLACED IN THE PARK POSITION.
Risk: EITHER CIRCUMSTANCE MAY RESULT IN THE VEHICLE ROLLING AWAY WITHOUT WARNING.
Fix: DEALERS WILL INSTALL A NEW LOAD-LIMITING PUSH ROD INTO THE FLOOR SHIFTER LEVER OF THE AFFECTED VEHICLES. OWNER NOTIFICATION BEGAN ON JUNE 14, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Power train › Automatic transmission › Park/neutral start interlock switch
NHTSA recall 98V183000 · Aug 6, 1998 · 685,000 vehicles · opened after NHTSA action (ODI)
Problem: VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH AUTOMATIC TRANSMISSIONS. THE ADJUSTMENT OF THE CABLE CONNECTING THE CONSOLE SHIFTER MECHANISM TO THE IGNITION KEY CAN CAUSE A TRAPPED KEY CONDITION WHICH CAN RESULT IN A LOW FORCE REQUIRED TO DEPRESS THE SHIFT BUTTON. A COMBINATION OF APPLYING A MIS-ADJUSTED RELEASE BUTTON WITH A LOW FORCE ATTEMPT TO SHIFT OUT OF PARK WITH THE KEY IN THE LOCKED POSITION, CAN BREAK THE CONNECTING PIN IN THE SHIFTER.
Risk: IF THIS HAPPENS, THE "IGNITION-PARK" INTERLOCK SYSTEM WILL BE NONFUNCTIONAL.
Fix: DEALERS WILL INSPECT FOR PROPER OPERATION OF THE SYSTEM. ANY VEHICLES THAT ARE NOT FUNCTIONAL AFTER THE INSPECTION WILL HAVE THE SHIFT MECHANISM AND CABLE REPLACED WITH A "SELF-ADJUSTING" DESIGN.
Seat belts › Front › Anchorage
NHTSA recall 98V063000 · Mar 20, 1998 · 91,544 vehicles · opened after NHTSA action (OVSC)
Problem: VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE REAR SEAT BELT ANCHOR DOES NOT ACHIEVE THE LOADING REQUIRED BY FMVSS NO. 210, "SEAT BELT ASSEMBLY ANCHORAGES."
Risk: FAILURE OF A SEAT BELT ANCHOR CAN RESULT IN THE LOSS OF SEAT BELT PROTECTION, WHICH COULD LEAD TO SERIOUS INJURY OR DEATH IN THE EVENT OF A CRASH.
Fix: DEALERS WILL INSPECT THE REAR SEAT BELT OUTBOARD ANCHOR FLOOR ATTACHMENTS FOR PROPER POSITIONING. IF THE ANCHOR WAS IMPROPERLY ORIENTED, THE ORIENTATION WILL BE CORRECTED.
Suspension › Front › Control arm › Lower ball joint
NHTSA recall 97V201000 · Nov 13, 1997 · 599,000 vehicles · opened after NHTSA action (ODI)
Problem: VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE LOWER CONTROL ARM BALL JOINT CAN SEPARATE DUE TO LOSS OF LUBRICATION.
Risk: SEPARATION OF THE BALL JOINT COULD CAUSE A LOSS OF STEERING CONTROL INCREASING THE RISK OF A VEHICLE CRASH.
Fix: DEALERS WILL INSPECT THE BALL JOINT END HOUSING COVER SEAL FOR LEAKAGE WITH A HIGH PRESSURE AIR TESTER AND THE RUBBER BOOT WILL BE VISUALLY INSPECTED FOR DAMAGE. IF THE COVER SEAL LEAKS OR THE BOOT IS DAMAGED, THE LOWER CONTROL ARM WILL BE REPLACED.
Service brakes, hydraulic › Foundation components › Master cylinder
NHTSA recall 96V075000 · May 3, 1996 · 151,800 vehicles
Problem: THE BRAKE MASTER CYLINDER CAN LEAK BRAKE FLUID DUE TO A DAMAGED DOUBLE LIP REAR PISTON SEAL.
Risk: BRAKE FLUID LEAKAGE CAN RESULT IN DIMINISHED EFFECTIVENESS OF ONE HALF OF THE SPLIT BRAKE SYSTEM. THE INSTRUMENT PANEL WARNING LIGHT(S) WILL SIGNAL SYSTEM IMPAIRMENT PRIOR TO PARTIAL BRAKE SYSTEM LOSS.
Fix: DEALERS WILL REPLACE THE REAR BRAKE MASTER CYLINDR PISTON ASSEMBLY.
Service brakes, hydraulic › Antilock/traction control/electronic limited slip
NHTSA recall 96V074000 · May 2, 1996 · 90,000 vehicles
Problem: CORROSION OF THE ABS HYDRAULIC CONTROL UNIT CAN CAUSE THE SOLENOID VALVES TO STICK IN THE OPEN POSITION.
Risk: IF EITHER FRONT WHEEL VALVE STICKS, THE VEHICLE WOULD SWERVE FROM A STRAIGHT STOP WHEN THE BRAKES ARE APPLIED.
Fix: DEALERS WILL INSTALL A PLATE AND SILICONE GREASE INJECTED INTO THE SOLENOID CAVITY TO ELIMINATE THE POTENTIAL FOR THIS CONDITION.
Engine and engine cooling › Engine › Gasoline
NHTSA recall 96V006000 · Jan 11, 1996 · 40,000 vehicles
Problem: IN CERTAIN VEHICLES, THE ENGINE CYLINDER HEAD OIL GALLEY PLUG DOES NOT SEAL PROPERLY AND ENGINE CYLINDER HEAD OIL IS NOT ADEQUATELY RETAINED.
Risk: INADEQUATE SEALING AND RETENTION OF THE PLUG CAN RESULT IN OIL LEAKAGE WHICH COULD CAUSE A FIRE IN THE ENGINE COMPARTMENT.
Fix: DEALERS WILL INSTALL AN EXPANSION PLUG AND RETAINING BRACKET OVER THE CYLINDER HEAD OIL GALLEY PLUG.
Recall repairs are free at any authorised dealer. A recall listed here may already have been fixed on a particular car: enter its 17-character VIN at nhtsa.gov/recalls to see open recalls.
Crash test ratings
1995 Chrysler Cirrus 4-DR.
Overall
Not Rated
Frontal crash
Not Rated
Side crash
Not Rated
Rollover
Not Rated
NHTSA 5-Star Safety Ratings (New Car Assessment Program). Ratings are comparable only between vehicles of similar size and weight, and ratings from 2011 on use tougher tests than earlier years. Photos: NHTSA.
Fuel economy
Cirrus
21mpg combined
City / highway
18 / 26 mpg
Fuel
Regular Gasoline
2.4 L · 4 cyl · Automatic 4-spd · Front-Wheel Drive · about $3,200/year to fuel
Cirrus
21mpg combined
City / highway
18 / 26 mpg
Fuel
Regular Gasoline
2.5 L · 6 cyl · Automatic 4-spd · Front-Wheel Drive · about $3,200/year to fuel
EPA estimates from fueleconomy.gov for each engine and transmission sold. Annual cost is the EPA's estimate for 15,000 miles a year at its current fuel and electricity price assumptions. Your results will vary.
What owners report
Problem area
Complaints
Crashes
Fires
Injuries
Typical mileage*
Service brakes, hydraulic Antilock/traction control/electronic limited slip; Foundation components › Master cylinder
150
28
2
25
93,694 mi
Power train Automatic transmission; Manual transmission
71
4
0
0
100,000 mi
Engine and engine cooling Engine › Gasoline; Engine
52
0
1
0
84,032 mi
Suspension Front; Front › Control arm › Lower ball joint
48
1
1
1
97,000 mi
Electrical system Ignition; Ignition › Module
47
0
3
1
82,064 mi
Vehicle speed control Cruise control; Linkages
39
8
0
9
57,000 mi
Equipment Appliance › Air conditioner; Electrical › Radio/tape deck/cd etc.
38
0
1
0
—
Visibility Windshield; Power window devices and controls
32
0
0
0
—
Steering Hydraulic power assist system; Hydraulic power assist › Hose, piping, and connections
*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.
Recent owner complaints
Feb 1, 2012 · 130,000 milesPower train TL* THE CONTACT OWNS A 1995 CHRYSLER CIRRUS. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 55 MPH, THE VEHICLE SUDDENLY SHIFTED INTO NEUTRAL. THE VEHICLE THEN SHIFTED OUT OF NEUTRAL, BUT WOULD NOT ACCELERATE OUT OF FIRST GEAR. THE VEHICLE WAS TAKEN TO A MECHANIC FOR A DIAGNOSTIC TEST. THE MECHANIC STATED THAT THE TRANSMISSION WOULD HAVE TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 130,000.
Feb 8, 2012 · 35 milesPower train OUR CAR WILL SHIFT PERFECTLY ONE DAY AND DON'T WANT TO SHIFT THE NEXT SECOND FOR NP REASON, WE HAVE REPLACED THE MODULATOR.. COOLANT TEMP SENSOR.. WE HAVE ALSO EVEN RECABLIORATED THE SHIFTING PATTERN AND STILL HAVE THIS PROBLEM.. IS THIS GOING TO KEEP HAPPENING OR IS THERE SOMETHING I CAN DO TO FIX IT. WE DID A DIAGNOSTIC ON IT AND THE TRANSMISSION WAS GOOD.. I DON'T KNOW WHAT ELSE TO DO.? *TR
Aug 15, 2009 · 40,000 milesPower train › Automatic transmission TRANSMISSION WITHOUT WARNING EITHER SHIFTS DOWN INTO SECOND GEAR AND WILL NOT SHIFT UP OR WORSE THE TRANSMISSION GOES LIMP WHEN DRIVING AT ANY SPEED IN OTHER WORDS YOU END UP COASTING AND COULD POSSIBLY CAUSE A SERIOUS ACCIDENT, THE FIRST TIME THIS HAPPENED TO ME I WAS GOING 65 MPH ON THE FREEWAY. FORTUNATELY, I WAS ON THE RIGHT HAND SIDE OF THE ROAD SO I COULD COAST OFF AND COME TO A STOP. IF I HAD BEEN IN HEAVY TRAFFIC IN EITHER THE CENTER OR LEFT HAND LANE THERE WOULD BE NO WAY FOR ME TO AVOID OTHER CARS AND THIS WOULD HAVE RESULTED IN A SERIOUS ACCIDENT. I TOOK THE CAR TO THE CHRYSLER DEALER AND THEY SAID IT WAS A FAULTY SOLENOID PACK AND THEY REPLACED IT FOR $900+ DOLLARS. THE CAR RAN…
Feb 24, 2009 · 140,000 milesPower train › Automatic transmission I BOUGHT A 1995 CHRYSLER CIRRUS LXI AND FOR THE FIRST LITTLE WHILE IT WAS GREAT, THEN ALL OF A SUDDEN I WAS DRIVING DOWN THE ROAD AT 62 MPH AND THE CAR SHIFTED INTO NEUTRAL I SLOWED DOWN TO ABOUT 30MPH AND IT DROPPED INTO GEAR BUT IT WOULD NOT SHIFT FROM FIRST GEAR. NOW SOMETIMES IT WILL SHIFT FINE AND OTHER TIMES IT WILL NOT SHIFT AT ALL. AND MY A/C QUIT WORKING AND THE RPM GAUGE STOPPED WORKING AT AROUND THE SAME TIME AS THE SHIFTING ISSUES STARTED. *TR
Jun 1, 2008 · 75,500 milesSuspension › Front › Control arm › Lower ball joint TL*THE CONTACT OWNS A 1995 CHRYSLER CIRRUS. SEVERAL MONTHS AGO, WHILE DRIVING 20 MPH, THE DRIVER'S SIDE FRONT SUSPENSION BEGAN MAKING A CREAKING NOISE. THE NOISE DID NOT SOUND LIKE THE SPRINGS, BUT MORE LIKE PLASTIC RUBBING OVER A HEAVY LOAD. THE CONTACT TOOK THE VEHICLE TO A MECHANIC AND WAS INFORMED THAT BOTH THE PASSENGER AND DRIVER'S SIDE FRONT SUSPENSION WERE OUT OF LUBRICANT. IN ADDITION, THE SUSPENSION JOINTS NEEDED TO BE REPLACED. AFTER RESEARCHING THE ISSUE, THE CONTACT DISCOVERED NHTSA CAMPAIGN ID NUMBER 97V201000 (SUSPENSION:FRONT:CONTROL ARM:LOWER BALL JOINT) FOR THE SAME FAILURE HIS VEHICLE WAS EXPERIENCING. THE MANUFACTURER STATED THAT THE RECALL DID APPLY TO HIS VEHICLE; THE…
Oct 15, 2007 · 86,000 milesEngine and engine cooling TL*THE CONTACT OWNS A 1995 CHRYSLER CIRRUS. WHILE APPROACHING A STOP SIGN OR RED LIGHT, THE VEHICLE SHUTS OFF AND WILL NOT RESTART. THE VEHICLE IS ALSO RATTLING VERY LOUDLY. THE DEALER REPAIRED THE STARTER. THE PURCHASE DATE WAS UNKNOWN. THE CURRENT MILEAGE WAS 89,000 AND FAILURE MILEAGE WAS 86,000.
Nov 18, 2005Engine and engine cooling TL*THE CONTACT OWNS A 1995 CHRYSLER CIRRUS. THE CONTACT ATTEMPTED TO START HER VEHICLE, BUT WAS UNSUCCESSFUL. THE ENTIRE INSTRUMENT PANEL ILLUMINATED. THE VEHICLE WAS TAKEN TO A MECHANIC AND HE STATED THAT THE MODULATOR NEEDED TO BE REPLACED. THE WORK WAS PERFORMED, BUT THE FAILURE RECURRED A MONTH LATER. THERE IS A ROD ON THE REAR DRIVER SIDE THAT IS SUPPOSED TO HOLD THE WHEEL IN PLACE, BUT IT HAS RUSTED. THE ROD FELL APART AND THE CONTACT HAD IT REPLACED. WHILE THE VEHICLE WAS PARKED, SHE NOTICED THAT THE BRAKELINE WAS LEAKING BRAKE FLUID ONTO THE GROUND. THE CONTACT TOOK THE VEHICLE TO A MECHANIC AND HAD IT REPAIRED. THE VIN, ENGINE SIZE, NUMBER OF CYLINDERS, POWERTRAIN, AND FAILURE…
Dec 15, 2007 · 122,876 miles · crash · 1 injuryAir bags › Frontal I HAD A FRONT END CRASH AT 25 TO 30 MPH, AND NONE OF THE AIR BAGS DEPLOYED JEOPARDIZING MY LIFE. THIS MAY BE ISOLATED OR MY BE ALL THE CARS LEFT ON THE ROAD. *TR
Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.
NHTSA defect investigations
EA03011 · opened Jul 17, 2003 · closed Jan 30, 2004 · led to recall 04V021000AUTO TRANS IGNITION-PARK INTERLOCK THE MANUFACTURER REPORTS ABOVE ARE BASED ON DAIMLERCHRYSLER?S (DC) ANALYSIS OF MODEL YEAR (MY) 1998 (POPULATION = 356,384) AND 1999 (POPULATION = 486,948) JA, JX AND LH FAMILY SUBJECT VEHICLE DATA (EARLIER MYS EXCLUDED).THE POPULATION NUMBER INCLUDES ALL MYS.THE PRECISE NUMBER OF DUPLICATES BETWEEN ODI AND DC REPORTS CANNOT BE DETERMINED DUE TO MISSING OR INCOMPLETE INFORMATION.THE FATALITY INCIDENT INVOLVED AN ELDERLY PERSON WHO ATTEMPTED TO STOP A ROLL AWAY VEHICLE AND RECEIVED FATAL INJURIES.ODI ALSO GATHERED INFORMATION ON MY 1997-99 PROWLER VEHICLES IN THIS INVESTIGATION. THE PROWLER VEHICLES WERE MANUFACTURED WITH A DIFFERENT DESIGN SHIFTER MECHANISM (THE SHIFT LEVER IS SHORTER).THERE ARE NO COMPLAINTS OF PROWLER INTERLOCK FAILURE IN ODI?S DATABASE, AND DC HAS RECEIVED NO REPORTS EITHER.THE PROWLER IS EXCLUDED FROM THE RECALL SCOPE.THE INVESTIGATION INVOLVED A CONDITION WHERE THE…
DP03002 · opened May 7, 2003 · closed Jul 22, 2003STEERING COLUMN SEPARATION MR. LARRY A. SACKEY SUBMITTED A PETITION TO THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) BY LETTER DATED APRIL 18, 2003, REQUESTING THAT NHTSAFURTHER INVESTIGATE THE DEFECTIVE COLLAPSIBLE STEERING SHAFT SYSTEM ON 1987-1995 VEHICLES MANUFACTURED BY THE DAIMLERCHRYSLER CORPORATION.IN PART BECAUSE OF 49 CFR ? 30120(G), NHTSA HAS DECIDED TO LIMIT THE SCOPE OF THE PETITION VEHICLES TO 1993-1995 MODELS, EXCLUDING THE 1993 JEEP GRAND CHEROKEE AND 1994-1995 DODGE RAM SERIES TRUCKS THAT WERE RECALLED (93V210 & 96V230) FOR STEERING COLUMN FAILURE.IF THE ANALYSIS OF THESE VEHICLES HAD IDENTIFIED A POTENTIAL PROBLEM, THE SCOPE COULD HAVE BEEN EXPANDED IN AN INVESTIGATION.A REVIEW OF ODI'S DATA BASE SHOWS NO RECENT COMPLAINTS AND A LACK OF A COMPLAINT TREND CONCERNING THE SUBJECT ISSUE ON THE SUBJECT VEHICLES AS A WHOLE OR BY INDIVIDUAL MODELS.THEREFORE, THE PETITION IS DENIED.FOR…
EA97016 · opened Sep 29, 1997 · closed Nov 20, 1997 · led to recall 97V201000LOWER CONTROL ARM BALL JOINT FAILURE BY LETTER DATED NOVEMBER 6, 1997, THE MANUFACTURER ADVISED THIS AGENCY OF ITS DECISION TO INITIATE A SAFETY RECALL CAMPAIGN OF THE SUBJECT VEHICLES TO CORRECT THE DEFECT IDENTIFIED IN THIS EA.THE RECALL WILL ALSO COVER 1996 AND 1997 CHRYSLER CIRRUS/DODGE STRATUS VEHICLES, AS WELL AS 1995 THROUGH 1997 CHRYSLER SEBRING CONVERTIBLE AND PLYMOUTH BREEZE VEHICLES EQUIPPED WITH IDENTICAL LOWER CONTROL ARM BALL JOINTS.AN ESTIMATED TOTAL OF 599,00VEHICLES ARE AFFECTED BY THIS RECALL.THE MANUFACTURER'S INVESTIGATION DISCLOSED THAT PROCESS VARIABILITY, TOGETHER WITH THE BALL JOINT HOUSING COVER CRIMPING OPERATION, CAN RESULT IN AN INEFFECTIVE SEAL THAT PERMITS A LOSS OF LUBRICATION AND ACCELERTED WEAR OF THE BALL JOINT ASSEMBLY.THIS CONDITION CAN LEAD TO FAILURE AND SEPARTION OF THE LOWER CONTROL ARM BALL JOINT.THE RECALL IS IDENTIFIED AS NHTSA 97V-201 AND A COPY OF CHRYSLER'S LETTER TO NHTSA IS…
PE97009 · opened Mar 13, 1997 · closed Sep 29, 1997LOWER CONTROL ARM BALL JOINT FAILURE THE MANUFACTURER IDENTIFED VEHICLE OWNER COMPLAINTS OF THE SUBJECT BALL JOINT FAILURES AS TABULATED ABOVE.IN ADDITION, A TOTAL OF 72 WARRANTY REPORTS WERE IDENTIFIED FOR REPLACEMENT OF BROKEN OR CRACKED BALL JOINT ASSEMBLIES IN THE SUBJECT VEHICLES.CHRYSLER ALSO REPORTED THAT 1996 AND 1997 MODELS ARE EQUIPPED WITH IDENTICAL BALL JOINT ASSEMBLIES AS THE SUBJECT 1995 MODEL YEAR VEHICLES.A PARTIAL RESPONSE TO NHTSA'S INFORMATION REQUEST INDICATED THAT THE MANUFACTURER'S ANALYSES AND EVALUATIONS OF THE CONDITION WERE CONTINUING.IN ORDER TO CONTINUE NHTSA'S COMPLETE ASSESSMENT OF THE NATURE AND SCOPE OF THIS MATTER, THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS.