*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.
Unknown or other
The RV roof experienced a substantial failure in which the membrane peeled back, exposing the underlying OSB roof decking. A subsequent inspection identified additional concerns regarding the materials and fasteners used in the roof assembly. I believe these findings warrant investigation into whether the RV was constructed in accordance with the manufacturer's specifications, applicable installation requirements, and reasonable standards for a weatherproof recreational vehicle roof. Before a recent trip, I inspected the roof and observed no visible tears, holes, or obvious membrane damage. After traveling to a new location, I discovered the damage on September 23, 2026. A substantial…
Sep 23, 2026Unknown or other
Frame and structural integrity/towable RV. 7/15/2024 â First Warranty Repair (Frame): Blue Compass found broken seal-plate welds on the frame; welds repaired, bolts replaced. 30 ft of roof membrane, which had pulled loose and "ballooned" in transit, was fully replaced. 6/2026 â Recurrence: Roof membrane pulled loose again during travel. Mobile tech (Mike's RV Repair, GA) performed a temporary repair ($668.60, GD-reimbursed), initially noting "frame flex" based on owner's account of 2024 history, later revised to "possible frame flex" absent independent diagnosis. 6/19â21/2026 â Follow-up Repair: GD/dealer deemed mobile-tech photos insufficient. Blue Compass Charleston reopened the…
Jun 11, 2026Equipment › Recreational vehicle/trailer › Lpg systems › Lines and fittings
The contact owns a 2023 Grand Design 5th Wheel. The contact stated that the propane gas pigtail was on the floor and created an electrical spark and popping noise that traveled up to other cords. The contact stated that the pigtail cord was improperly fitted and should not have been on the floor. The vehicle was not diagnosed or repaired. The manufacturer was not notified. The failure mileage was unavailable.
May 3, 2026Structure › Body
This report details a suspected major structural frame failure on my 2023 Grand Design Solitude 391DL. The issues, which are progressive and worsening, indicate a severe loss of structural integrity in the front gooseneck and upper deck area of the fifth wheel. Key observations and symptoms include: Interior Wall Deformation: Interior wall panels in the front bedroom are visibly buckling and warping under stress. Separation of Wall Panels: The rear wall panel inside the main bedroom closet has developed a significant gap and is separating, believed to be a direct result of excessive frame flex. Misalignment of Door Frames: The door frame for the front closet housing the washer and dryer has…
Nov 17, 2025Service brakes
The contact owns a 2023 Grand Design Solitude RV. The contact stated that while hauling the RV and depressing the brake pedal to stop, the RV pushed up against the rear of the pickup truck. The vehicle was taken to the local dealer, who discovered that the RV brake shoes had crumbled and failed. The contact was advised that the brake shoes and braking system needed to be replaced. The vehicle was later taken to the local engineering firm and the braking system was replaced. The manufacturer was notified of the failure, but no assistance was offered. The failure mileage was 9,300.
Aug 19, 2025 · 9,300 milesStructure › Body
Frame Flex & Water Intrusion - We first noticed movement back in August 2024. It seemed like the tongue was going to come through our back truck window where I sit to work with our 3 cats. The inside of the Solitude is a mess too with lights coming down from ceiling, doors are all scratch from rubbing while be transported, trim coming off, wall paper being torn apart, had lag bolts coming up through the floor, leakage in master bedroom, floor warping and more. We took it in to have it fixed in November 2024 to only get her back in late march of 2025. They had to weld and reinforce frame but would not admit to frame flex or provide me with an updated weight placard so it's like they don't…
Oct 1, 2024Unknown or other
The frame has possibly broken in the hitch area. This is a large 5th wheel trailer.
May 1, 2025Service brakes
All brakes were replaced after the first failure. Pulled 3445 miles. RR brake fell apart. Causing loss of braking from that wheel.
Oct 1, 2024
Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.