*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.
Engine
Hello, my car was parked at home and as I turned the engine on, I noticed the red light 'oil pressure' on the dashboard. I checked the oil level and it was very low. On the same day I purchases 2 quarts of oil to keep it at a safe level. The next day I checked the dip stick again and much oil was loss. I was very concerned and finally was able to make an appointment to my mechanic shop for inspection which led to an appointment for a fix on 3/6/2025. The problem was a defective OEM oil pressure switch. This warranty of the oil pressure switch is covered by KIA under WTY026 Warranty Extension for 15 years/150000 miles for the same 3.3L GDI engine as my 2016 Hyundai Azera. Since Hyundai is…
Mar 3, 2025Unknown or otherFire
On XXX while my daughter was driving this car on [XXX] outside of [XXX], the car caught fire and within minutes was engulfed in flames. My daughter and her boyfriend only had enough time to pull off the road and get out. The entire vehicle burnt to the ground. My daughter and boyfriend were minutes from burning to death in this car with no advanced warning or notification. The fire seems to have started near the gas filler cap. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Jul 2, 2026Engine
Engine overheating without Engine light or any other safety alerts until Engine finally failed
Apr 9, 2026Engine and engine cooling
The contact owns a 2016 Hyundai Azera. The contact stated that the heating system was inoperable. The vehicle was taken to two Goodyear Auto Repair Shops, where it was diagnosed with a head gasket leak. One of the Goodyear facilities replaced the thermostat and the radiator. The contact stated that while driving at 55 MPH, a message that the engine was overheating was displayed. The contact was able to pull over to the side of the road. The vehicle was towed to the dealer, where it was diagnosed that the head gasket was leaking because the head gasket bolts had melted. The dealer sent the vehicle to a machine shop, where the engine was repaired. Additionally, the contact stated that the…
Nov 17, 2023 · 109,000 milesElectrical system
Moonroof- I opened my moonroof and when I tried to close it, the sunshade would not retract - it is hanging - causing me not to be able to see the back window when looking through my rear view mirror. I brought to a body shop and they said it is a design flaw. Now they want $1,800 to fix it!
Sep 17, 2023Air bags
Air Bag light came on while driving. After getting it checked, the technician stated that the air bag module went out and was erased. A new module would need to be ordered and the old one replaced. repair was not done as the cost was expensive and I don't believe that I should pay for something that is a safety equipment issue, This should be under a lifetime warranty. Currently driving the vehicle without working air bags. Has not been reported to the manufacturer. Light first appeared in February of 2022.
Aug 16, 2022Structure › Body
While driving on the interstate, the panoramic sunroof exploded. Pieces of glass flew off my car. The explosive sound was very loud and startling, but I was able to maintain control of my vehicle. Vehicles behind me were potentially impacted by flying pieces of glass. I took my vehicle directly to the dealer, (Nalley Hyundai) who confirmed the glass shattered. There was no evidence of any foreign object impacting the glass. There were no warnings lights, messages or any other symptoms of an impending issue. Reported to Hyundai USA, Case # 19935493.
Jun 25, 2022Unknown or other1 injury
The hydraulic hood lifting "hinges" did not hold the hood up. When I raised the hood to fill the window washer container, the hood fell, unhindered, on my left wrist, as I was taking the cap off of the filling tube. 2 seconds later it could have been my head as I would have been over the washer reservoir opening. The hand was very bruised, and the wrist was cut. (really hurt) Went to the dealer & he said this was the first Azera they had heard of with the problem but had seen several Sonatas with this problem. I believe the hydraulic lifters are the same, so perhaps the problem affects both models.
Apr 29, 2022
Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.