2004 Kawasaki Concours recalls & problems
The 2004 Kawasaki Concours has no safety recalls on file with NHTSA, and 3 owner complaints. The most-reported problem area is engine and engine cooling (2 complaints).
Recalls0safety recalls
Complaints3filed by owners
Crashes · fires1 · 0reported in complaints
Injuries · deaths0 · 0reported in complaints
Safety recalls
No safety recalls have been filed for the 2004 Kawasaki Concours.
Recall repairs are free at any authorised dealer. A recall listed here may already have been fixed on a particular car: enter its 17-character VIN at nhtsa.gov/recalls to see open recalls.
What owners report
| Problem area | Complaints | Typical mileage* |
|---|---|---|
| Engine and engine cooling Engine | 2 | — |
| Structure Frame and members › Underbody shields | 1 | — |
| Service brakes, hydraulic | 1 | — |
*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.
Recent owner complaints
- Oct 23, 2004 · 4,936 milesEngine and engine cooling › Engine
2004 KAWASAKI KLR650 1) VEHICLE WAS PURCHASED NEW AND RIDDEN ACCORDING TO BREAK-IN SCHEDULE. THE VEHICLE WAS RIDDEN MOSTLY ON THE SURFACE STREETS AND HIGHWAYS, AND ABOUT 100 MILES OFF-ROAD. THE BOLT,IDLER LEVER PN 92150-1923 WAS ADJUSTED AT THE INTERVAL RECOMMENDED BY THE MANUAL. 2) AT 4,932 MILES, THE SPRING,IDLER SHAFT, PN 92144-1860 IS MISSING. IT MAY BE IN THE ENGINE, OR MAY NOT HAVE BEEN INSTALLED AT THE FACTORY. THIS MAKES IT IMPOSSIBLE TO ADJUST BALANCER CHAIN TENSION WITHOUT DISASSEMBLING THE ENGINE. A LOOSE BALANCER CHAIN CAN CAUSE CATASTROPHIC ENGINE FAILURE. 3) NO REPAIR HAS BEEN MADE YET. THE SPRING MAY BE IN THE ENGINE. *JB - Aug 10, 2004 · 300 milesEngine and engine cooling › Engine
MOTOR WAS DEFECTIVE. CONSUMER HAD THE MOTORCYCLE FOR 1 WEEK AND EXPERIENCED AN ENGINE PROBLEM. IT MADE A KNOCKING NOISE THAT SOUNDED LIKE A ROD WAS DEFECTIVE WITHIN THE ENGINE. THIS NOISE OCCURRED WHEN THE MOTORCYCLE WAS STARTED AND CONTINUED. CONSUMER TOOK THE MOTORCYCLE TO THE DEALER WHERE THE MOTORCYCLE WAS PURCHASED AND CONTACTED THE MANUFACTURER, WHO WOULD NOT AUTHORIZE THE DEALER TO GO INTO THE CRANK CASE TO INVESTIGATE THE DEFECT. MANUFACTURER'S SOLUTION WAS FOR THE DEALERSHIP TO GIVE THE MOTORCYCLE BACK TO CONSUMER BECAUSE THE MOTORCYCLE NEEDED TO BE BROKEN IN. CONSUMER WAS DISSATISFIED. *AK - Jul 7, 2004 · crashStructure › Frame and members › Underbody shields
WHILE DRIVING 25 MPH AND THE BRAKES WERE APPLIED FOR AN URGENT STOP MOTORCYCLE FLIPPED OVER. ALSO, EXCESSIVE VIBRATION THROUGHOUT THE ENTIRE BODY. THE CONSUMER FOUND OUT THAT THE FRAME WAS STRESSED WHEN THE MOTOR WAS MOUNTED. *AK
Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.