Model year record

1996 Nissan 200SX recalls & problems

The 1996 Nissan 200SX has 2 safety recalls and 37 owner complaints on file with NHTSA. The most-reported problem area is air bags (12 complaints).

Recalls2safety recalls

Complaints37filed by owners

Crashes · fires3 · 1reported in complaints

Injuries · deaths4 · 0reported in complaints

Safety recalls

Exterior lightingMay 24, 2006

Exterior lighting

Recall 06E04900027,176 vehiclesopened after NHTSA action (OVSC)

Problem: CERTAIN CK MOTORSPORTS COMBINATION HEADLIGHTS, CLEAR CORNER, BUMPER, AND SIDE MARKER LIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON THE PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Risk: WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Fix: CK MOTORSPORT WILL NOTIFY OWNERS AND REPLACE THE NONCOMPLIANT LAMPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 1, 2006. OWNERS MAY CONTACT CK MOTORSPORT AT 1-909-610-7211.

VisibilityMay 5, 1998

Windshield wiper/washer › Linkages

Recall 98V093000512,387 vehicles

Problem: VEHICLE DESCRIPTION: PASSENGER VEHICLES. WATER CAN ENTER AND DISPLACE THE GREASE IN THE WIPER ARM LINKAGE BALL JOINT WHERE THE WIPER LINKAGE ATTACHES TO THE WIPER MOTOR LINKAGE.
Risk: THIS CAN RESULT IN GRADUAL WEAR OVER A PERIOD OF TIME INSIDE THE JOINT THAT COULD LEAD TO THE SEPARATION OF THE WIPER LINKAGE ASSEMBLY FROM THE WIPER MOTOR LINKAGE AT THE BALL JOINT. A LOSS OF WINDSHIELD WIPER FUNCTION CAN RESULT IN THIS SEPARATION OCCURS.
Fix: TO PREVENT GREASE FROM BEING WASHED OUT OF THE JOINT, THE DEALERS WILL MODIFY BY ADDING A WATER DIVERSION SEAL THAT WILL PREVENT WATER FROM ENTERING THE WINDSHIELD WIPER LINKAGE BALL JOINT AREA.

Recall repairs are free at any authorised dealer. A recall listed here may already have been fixed on a particular car: enter its 17-character VIN at nhtsa.gov/recalls to see open recalls.

What owners report

Problem area	Complaints	Crashes	Fires	Injuries	Typical mileage*
Air bagsFrontal	12	3	0	4	—
VisibilityWindshield wiper/washer › Linkages; Windshield wiper/washer	9	0	0	0	120,500 mi
Power trainAutomatic transmission; Clutch assembly	4	0	0	0	—
TiresTread/belt; Sidewall	4	0	0	0	—
Unknown or other	2	0	0	0	—
Parking brakeConventional	2	0	0	0	—
Engine and engine coolingExhaust system › Emission control; Engine › Gasoline	2	0	0	0	—
Electrical systemIgnition; Wiring › Front underhood	2	0	1	0	—
SuspensionRear	2	0	0	0	—
Seat beltsFront › Retractor	1	0	0	0	—
Exterior lighting	1	0	0	0	—
Vehicle speed control	1	0	0	0	—

*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.

Recent owner complaints

Power train › Automatic transmission
TL*THE CONTACT OWNS A 1996 NISSAN 200SX. THE VEHICLE WOULD NOT SHIFT GEARS OR EXCEED 20 MPH. THE DEALER STATED THAT THE TRANSMISSION NEEDED TO BE REPLACED. THE VEHICLE IS CURRENTLY BEING REPAIRED BY THE DEALER. THE CURRENT AND FAILURE MILEAGES WERE 92,000.
Jan 9, 2008 · 92,000 miles
Visibility › Windshield wiper/washer › Linkages
WIPER ARM LINKAGE POPS OFF AS DESCRIBED IN THE RECALL SECTION, BOTH WIPERS BECOME NON-FUNCTIONAL. LOCAL NISSAN DEALER WILL NOT HONOR THE RECALL, STATING THAT MY CAR DOES NOT HAVE THE DEFECTIVE PART - NO RECORD OF THIS RECALL BEING PERFORMED LINKED TO THIS VIN. *TR
Nov 10, 2007 · 141,500 miles
Suspension
ENTERING A RIGHT TURN ON A CLOVER LEAF THE CAR MADE A SUDDEN SIDEWAYS MOVEMENT. I WAS TRAVELING ABOUT 20 MPH AND WAS FORCED TO THE SHOULDER. INITIAL ROADSIDE INSPECTION FOUND LEFT REAR TIRE TOUCHING LEFT REAR FENDER WELL. CAR WAS TAKEN BY FLATBED CARRIER FROM ROADSIDE. UPON FURTHER EXAMINATION FOUND THAT THE BRACKET THAT CONNECTS THE REAR LEFT TRAILING-LINK ARM TO THE REAR AXLE HAD SEPARATED FROM THE CHASSIS. NISSAN DEALERSHIP INSPECTED CAR AND BRACKET AND FOUND THAT THE BRACKET WAS NOT WELDED TO THE CHASSIS WITH THE CORRECT AMOUNT OF SPOT WELDS. IN FACT, SIX TO SEVEN SPOT WELDS WERE MISSED COMPARED TO THE RIGHT SIDE. NISSAN HAS REFUSED TO REPAIR THIS QUITE OBVIOUS MANUFACTURERS DEFECT…
Apr 12, 2007 · 181,000 miles
Visibility › Windshield wiper/washer › Linkages
DT*: THE CONTACT STATED THE WIPER ARM LINKAGE DISENGAGED WITHOUT WARNING, WHILE THE WINDSHIELD WASHER/WIPERS WERE ACTIVATED. THE VEHICLE WAS NOT INSPECTED BY A DEALER. THERE WAS A NHTSA RECALL, # 98V093000, REGARDING THE WINDSHIELD WASHER/WIPER ARM LINKAGE. THE VEHICLE WAS NOT INCLUDED IN THE RECALL DUE TO THE VIN. THE MANUFACTURER WAS CONTACTED.
Aug 3, 2006 · 128,000 miles
Visibility › Windshield wiper/washer › Linkages
I OWN A 1996 NISSAN 200SX WITH . I PURCHASED THE CAR IN LATE SUMMER OF 2005. ON JULY 5 2006 MY SON WAS DRIVING THE CAR IN A RAIN STORM AND THE WIPERS STOPPED FUNCTIONING. THE NEXT DAY HE ASKED ME TO LOOK AT THE CAR AND I DISCOVERED THE WINDSHIELD WIPER LINKAGE HAD FAILED AT THE BALL JOINT WHERE THE CONNECTING ROD FROM THE MOTOR JOINS THE PIVOT ROD FOR THE WIPER BLADES. I DID A LITTLE RESEARCH AND DISCOVERED THIS PROBLEM WAS PREVIOUSLY REPORTED IN NHTSA RECALL 98V093000. I CONTACTED MY LOCAL NISSAN DEALER AND I WAS TOLD MY VIN HAD NO OUTSTANDING RECALLS. I CALLED NISSAN CORP. AND WAS TOLD THE SAME THING. HOWEVER, NISSAN IS GOING TO PULL THE ARCHIVES ON MY VEHICLE TO SEE IF IT HAS BEEN…
Jul 5, 2006 · 141,000 miles
Tires › Tread/belt
MY WITNESS WHO DROVE WITH ME CHECKED THE TIRE PRESSURE BEFORE WE LEFT BECAUSE WE WERE DRIVING OVER 150 MILES. WE WERE DRIVING FROM ALMOST APACHE JUNCTION,AZ TO SIERRA VISTA AZ. TO PICK MY 7 YEAR OLD SON FROM HIS MOTHERS. WE GOT OUTSIDE OF CASA GRANDE GOING THE SPEED LIMIT, WE HEARD A LOUD NOISE AND FELT SOMETHING HIT THE SIDE OF THE CAR. COME TO FIND OUT THE TREAD COMPLETELY PEELED OFF AND WHEN IT PEELED OFF IT DID $2000 OF DAMAGED TO MY PASSENGER SIDE OF THE CAR. EVEN THOUGH THE TREAD PEELED OFF THERE WAS STILL AIR IN THE TIRE, SO WE DROVE TO A TIRE PLACE AND GOT A SPARE TIRE IN ELOY, AZ. I FILED A COMPLAINT WITH COOPER TIRES AND THEY DENIED ME SAYING THAT THE TREAD CAME OFF DO TO UNDER…
Oct 2, 2005 · 17,300 miles
Visibility › Windshield wiper/washer
DT: THE CONTACT STATED DRIVER'S SIDE WINDSHIELD WIPER DOES NOT WORK. THE PASSENGER SIDE WINDSHIELD WIPER WILL WORK INTERMITTENTLY. THERE WAS NO FOREWARNING PRIOR TO THE WIPERS NOT WORKING. THERE WAS RECALL 98V093000. HE CONTACTED THE DEALER, THEY STATED IT WAS TOO OLD OF A RECALL IN THEIR DATABASE. *AK
Oct 24, 2005 · 113,000 miles
Power train › Clutch assembly › Pedal/hand lever(motorcycle)
MANUAL TRANSMISSION CLUTCH CABLE FAILED, UNABLE TO CHANGE GEARS WHILE DRIVING. THIS CONDITION WAS INTERMITTENT AND HAPPENED THREE TIMES BEFORE DEALER WAS ABLE TO DIAGNOSE AND REPAIR. AS A RESULT OF FAILURE, CAR WAS UNABLE TO DOWNSHIFT WHICH LED TO VEHICULAR LACK OF CONTROL. LOCAL NISSAN DEALER FINALLY WAS ABLE TO DIAGNOSE THE PROBLEM AND REPLACE THE ENTIRE CLUTCH CABLE ASSEMBLY. UNKOWN OF OLD PART IS AVAILABLE FOR INSPECTION.
Apr 30, 2005 · 97,400 miles

Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.