Model year record

2005 Scion Tc recalls & problems

The 2005 Scion Tc has 4 safety recalls and 155 owner complaints on file with NHTSA. The most-reported problem area is visibility (47 complaints).

Recalls4safety recalls

Complaints155filed by owners

Crashes · fires25 · 3reported in complaints

Injuries · deaths35 · 2reported in complaints

Safety recalls

EquipmentFeb 3, 2010

Other › Labels

Recall 10V035000271,417 vehicles

Problem: GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Risk: THIS DOES NOT MEET THE STANDARD REQUIREMENTS.
Fix: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.

Air bagsOct 26, 2006

Side/window

Recall 06V40800029,542 vehicles

Problem: ON CERTAIN VEHICLES, THE SIDE IMPACT SEAT-BOLSTER AND CURTAIN SIDE AIRBAGS MAY INADVERTENTLY DEPLOY. THIS CONDITION CAN OCCUR IF THE DOOR FOR THAT SIDE OF THE VEHICLE IS CLOSED WITH A HIGH RATE OF FORCE WHILE THE VEHICLE'S IGNITION IS IN THE "ON" POSITION OR WITHIN 90 SECONDS OF TURNING THE IGNITION KEY FROM THE "ON" POSITION TO THE "OFF" POSITION.
Risk: IF THE SIDE IMPACT SEAT-BOLSTER AND CURTAIN SIDE AIRBAGS INADVERTENTLY DEPLOY, THEY COULD CAUSE PERSONAL INJURY IF AN OCCUPANT IS SEATED ON THE SAME SIDE OF THE VEHICLE AS THE DOOR THAT IS CLOSED WITH A HIGH RATE OF FORCE. UNTIL THE REPAIR HAS BEEN PERFORMED, IT IS RECOMMENDED THAT A MINIMAL FORCE/SPEED BE USED TO CLOSE THE DRIVER AND PASSENGER DOORS OR CLOSING THE DOORS AFTER 90 SECONDS HAVE ELAPSED FROM TURNING THE IGNITION KEY FROM THE "ON" TO THE "OFF" POSITION.
Fix: DEALERS WILL REPLACE THE TWO SIDE IMPACT AIRBAG SENSORS AND INSTALL A URETHANE PAD IN THE FRONT DOORS, IF NECESSARY, FREE OF CHARGE. THE RECALL BEGAN ON NOVEMBER 6, 2006. OWNERS MAY CONTACT TOYOTA AT 1-866-548-1851.

Air bagsApr 3, 2006

Air bags

Recall 06V096000133 vehicles

Problem: ON CERTAIN VEHICLES, DUE TO IMPROPER ASSEMBLY OF THE AIR BAG INFLATOR, WHICH IS USED IN THE SIDE AIR BAG, THE CURTAIN SHIELD AIR BAG, AND THE KNEE AIR BAG ASSEMBLY, SOME INFLATORS WERE PRODUCED WITH AN INSUFFICIENT AMOUNT OF THE HEATING AGENTS NECESSARY FOR PROPER AIR BAG DEPLOYMENT. IN THIS CONDITION, THE EXPANSION FORCE OF THE GAS MAY BE INSUFFICIENT TO PROPERLY INFLATE THE AIR BAG WHEN THE SRS SYSTEM IS ACTIVATED DURING A CRASH.
Risk: THIS MAY INCREASE THE RISK OF INJURY TO THE OCCUPANT IN THE INVOLVED SEATING POSITION IN THE EVENT OF A CRASH.
Fix: DEALERS WILL REPLACE THE SPECIFIC SRS AIR BAG. THE RECALL BEGAN ON APRIL 6, 2006. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371, SCION AT 1-866-548-1851, OR LEXUS AT 1-800-255-3987.

VisibilityOct 18, 2005

Sun/moon roof assembly

Recall 05V48300071,392 vehiclesopened after NHTSA action (ODI)

Problem: ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH A GLASS WIND DEFLECTOR, THE DEFLECTOR, IF IMPACTED BY A PROJECTILE, SUCH AS ROAD DEBRIS, WHILE DRIVING WITH THE WIND DEFLECTOR IN THE UPWARD-TILTED POSITION AT HIGHWAYS SPEEDS, MAY SHATTER AND SEPARATE FROM THE FRAME.
Risk: PIECES OF THE WIND DEFLECTOR GLASS MAY SEPARATE FROM THE FRAME AND FALL UPON THE VEHICLE OCCUPANTS CAUSING DRIVER DISTRACTION AND/OR INJURY.
Fix: DEALERS WILL INSTALL A PROTECTIVE LAMINATE TO THE WIND DEFLECTOR TO PREVENT PIECES OF GLASS FROM SEPARATING FROM THE WIND DEFLECTOR FRAME. THE RECALL BEGAN OCTOBER 27, 2005. OWNERS MAY CONTACT TOYOTA AT 1-866-707-2466.

Recall repairs are free at any authorised dealer. A recall listed here may already have been fixed on a particular car: enter its 17-character VIN at nhtsa.gov/recalls to see open recalls.

Fuel economy

tC

23mpg combined

City / highway	20 / 27 mpg
Fuel	Regular Gasoline

2.4 L · 4 cyl · Automatic 4-spd · Front-Wheel Drive · about $2,900/year to fuel

tC

22mpg combined

City / highway	19 / 27 mpg
Fuel	Regular Gasoline

2.4 L · 4 cyl · Manual 5-spd · Front-Wheel Drive · about $3,050/year to fuel

EPA estimates from fueleconomy.gov for each engine and transmission sold. Annual cost is the EPA's estimate for 15,000 miles a year at its current fuel and electricity price assumptions. Your results will vary.

What owners report

Problem area	Complaints	Crashes	Fires	Injuries	Typical mileage*
VisibilitySun/moon roof assembly; Windshield	47	1	0	2	32,500 mi
StructureBody; Frame and members	32	1	1	4	54,500 mi
Air bagsFrontal; Side/window	20	14	0	17	75,297 mi
TiresPressure monitoring and regulating systems; Tread/belt	12	1	0	0	31,000 mi
Unknown or other	11	0	0	0	60,000 mi
Engine	9	0	1	0	120,750 mi
Vehicle speed controlAccelerator pedal	8	3	0	6	102,000 mi
Power trainAutomatic transmission	8	1	0	0	52,900 mi
Service brakes, hydraulicAntilock/traction control/electronic limited slip; Foundation components › Disc › Caliper	7	4	0	1	15,200 mi
EquipmentElectrical › Radio/tape deck/cd etc.	6	1	0	1	16,450 mi
Engine and engine coolingEngine; Cooling system	5	0	0	0	31,000 mi
Seat beltsFront	5	3	0	6	31,000 mi

*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.

Recent owner complaints

Engine
Never had a problem with car before went on freeway to get up to speed n the speedometer was dropping so I pull to side of freeway shut car off turn car back on here clunk clunk shut car off no check engine light was on or has been on no oil light was on nothing get car towed back to safe place well check fluid n oils bone dry cars engine blows just started reading n I guess 2005 goes. Threw oil way fast why isn't that noteted anywhere so messed up just did oil change week before this so shocked now I have to try to fix my blown engine single mom not able to make ends meet now this idk what to do
Sep 7, 2025
Engine
Engine burning oil
Jun 12, 2019
Air bagsCrash
1. I believe my airbags deployed pre-maturely with a soft impact to another vehicle. There was no damage to the other vehicle and no police report needed to be filed. There is a minor damage to my front bumper. 2. The airbags inflated on me, but no medical attention was required. 3. I have not confirmed or reproduced this problem with a professional. 4. My car has not been inspected nor reported to my insurance agency as my coverage only covers liability. 5. No symptoms prior to airbags deploying pre-maturely *Because of the pre-mature deployment of my airbags I am unable to afford the airbags to be reset, as doing so would cost more than the kbb estimated value of my car.
Nov 6, 2021
Air bagsCrash
TL* THE CONTACT OWNED A 2005 SCION TC. WHILE THE CONTACT WAS ACCELERATING FROM A TRAFFIC LIGHT, HER VEHICLE WAS T-BONED BY ANOTHER VEHICLE THAT RAN A RED LIGHT. THE ENTIRE DRIVER'S SIDE OF THE VEHICLE WAS SMASHED IN AND THE VEHICLE WAS TOTALED. THERE WERE NO INJURIES. THE SIDE CURTAIN AIR BAGS AND DRIVER'S SIDE AIR BAG DID NOT DEPLOY. A POLICE REPORT WAS FILED AND THE VEHICLE WAS TOWED TO A BODY SHOP. THE MANUFACTURER WAS CONTACTED AND REMINDED BY THE CONTACT THAT THERE WAS AN UNKNOWN RECALL FOR THE SIDE AIR BAGS FOR WHICH THE VEHICLE WAS REPAIRED FOR IN 2006. THE MANUFACTURER RESPONDED WITH A LETTER, STATING THAT THEY ASSIGNED AN ENGINEER TO DIAGNOSE THE VEHICLE. BASED ON THEIR INSPECTION,…
Oct 3, 2019 · 91,400 miles
Unknown or other
GLASS ROOF SHATTERED UNPROVOKED
Sep 4, 2019 · 160,000 miles
Air bagsCrash2 injuries
TAKATA RECALL?? AIRBAGS FAILED, DURING ACCIDENT. AFTER BEING CUTOFF AND GOING DOWN ROUTE X. LOST CONTROL HIDING CONCRETE. CAR FLIPPED, WAS DRAGGED A FEW FEET'S - NO AIRBAGS. PASSENGER STILL HAS ANXIETY WHEN GETTING INTO VEHICLES-THE ONE THING YOU'D THINK WOULD RESPOND DIDN'T. HOW DO WE EVER GET THE SENSE OF SECURITY BACK. *DT *TR
May 18, 2018 · 2 miles
Engine
I PURCHASED A RED 2005 SCION TC FOR MY DAUGHTER IN FEBRUARY, 2019 FROM TOYOTA AUTO NATION IN DAVIE, FL. THEY HAD IT PRICED IN GOOD CONDITION, SO I EXPECTED TO GET SOME USE OUT OF IT. I PAID ALMOST $6,000. MONTH LATER IT OVERHEATED ON THE HIGHWAY (595) AND MY DAUGHTER HAD TO PULL OVER LATE AT NIGHT ON THE HIGHWAY AND I HAD TO HAVE IT TOWED TO MY HOME. VERY SCARY AND UNSAFE SITUATION FOR A TEEN. HAD IT TOWED BACK TO THEIR SERVICE STATION AND IT TURNED OUT TO BE A PROBLEM, THAT COST ME $600. I FIND IT HARD TO BELIEVE THAT THIS COMPANY WOULD NOT HAVE SEEN ANY DAMAGE UNDER THE HOOD. SHAME ON THEM FOR SELLING ME A CAR THAT BROKE DOWN IN ONE MONTH. I HAVE CALLED THEM AND THEY WILL NOT HELP WITH…
Jul 11, 2019
Power train
TL* THE CONTACT OWNS A 2005 SCION TC. WHILE THE DRIVER WAS AT A STOP LIGHT, THE CLUTCH PEDAL FAILED AND TRAVELED TO THE FLOORBOARD. PRIOR TO THE FAILURE, THE CLUTCH PEDAL WAS STICKING. THE DRIVER HAD TO PULL THE CLUTCH PEDAL UP WITH HER LEFT FOOT. THE VEHICLE WAS PUSHED OVER TO THE SIDE OF THE ROAD AND LATER TOWED TO THE CONTACT'S RESIDENCE. THE CONTACT STATED THAT AN INDEPENDENT MECHANIC CAME TO HIS RESIDENCE AND DIAGNOSED THAT THE CLUTCH NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER AND DEALER WERE NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 166,367.
May 24, 2019 · 166,367 miles

Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.

NHTSA defect investigations

GLASS MOONROOF SHATTERSClosed
ODI'S INVESTIGATION DISCLOSES THAT THE SUBJECT VEHICLES SUSTAIN MOONROOF SHATTERING AND/OR DAMAGE AT RATES COMPARABLE TO THOSE FOR MOST OTHER SIMILARLY EQUIPPED VEHICLES.THIS REVIEW ALSO DISCLOSES THAT SUCH INCIDENTS OCCUR IN MOST VEHICLES WITH MOONROOFS AND THAT WHILE TEMPERED GLASS PANELS COMMONLY USED IN MOONROOF FABRICATION ARE SHATTER-RESISTANT, SOME CATASTROPHIC FAILURES DO IN FACT OCCUR.IMPACT WITH SMALL STONES OR ROAD DEBRIS MAY RESULT IN IMMEDIATE OR DELAYED SHATTER INCIDENTS, DEPENDING ON THE EXTENT AND NATURE OF DAMAGE SUSTAINED BY THE GLASS MOONROOF PANEL.THE MANUFACTURER CONCLUDES THAT INCIDENTS OF MOONROOF SHATTER ARE RANDOM OCCURRENCES THAT RESULT PRIMARILY FROM IMPACT WITH SMALL STONES OR OTHER OBJECTS WHILE THE VEHICLE IS IN MOTION. A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AND THIS PE HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A…
PE06024 · opened Jul 7, 2006 · closed Dec 6, 2006
SUN/MOON ROOF WIND DEFLECTOR BREAKAGEClosedLed to recall 05V483000
THE MANUFACTURER NOTIFIED NHTSA BY LETTER DATED OCTOBER 17, 2005, THAT A SAFETY RECALL HAS BEEN INITIATED.NHTSA HAS ASSIGNED NO.05V-483 TO THE RECALL.THE CORRECTIVE ACTION WILL CONSIST OF INSTALLING A PLASTIC FILM TO THE INSIDE SURFACE OF THE WIND DEFLECTOR GLASS.THE CORRECTIVE ACTION WILL BE PERFORMED ON APPROXIMATELY 71,400 MY 2005 AND 2006 SCION TC VEHICLES MANUFACTURED DURING THE PERIOD OF MARCH 12, 2004 THROUGH JULY 21, 2005. BASED ON THIS ACTION, THE SUBJECT EA HAS BEEN CLOSED.
EA05013 · opened Aug 26, 2005 · closed Oct 26, 2005
SUN/MOON ROOF WIND DEFLECTOR BREAKAGEClosed
THE MANUFACTURER STATES THAT THERE ARE NO INDICATIONS OF DEFICIENCIES IN THE DESIGN, MANUFACTURE, OR ASSEMBLY OF THE WIND DEFLECTOR THAT MAY ACCOUNT FOR THE INCIDENTS REPORTED.THE MANUFACTURER ALSO BELIEVES THAT IMPACT OF AIRBORNE ROAD DEBRIS WITH THE WIND DEFLECTOR IS THE PROBABLE CAUSE FOR THE INCIDENTS REPORTED.ODI'S ANALYSES OF THE WARRANTY DATA INDICATE THAT INCIDENTS OF WIND DEFLECTOR BREAKAGE WHILE DRIVING WILL CONTINUE TO OCCUR OVER TIME, AS THE POPULATION AND ON-ROAD EXPOSURE OF THE SUBJECT VEHICLES INCREASE.THE EVIDENCE INDICATES THAT REGARDLESS OF THE CAUSE FOR SUCH BREAKAGE, THE BROKEN GLASS PARTICLES AND FRAGMENTS MAY FALL DIRECTLY ONTO THE FRONT SEAT OCCUPANTS OF THESE VEHICLES.THESE OCCURRENCES MAY POSE A RISK OF DRIVER DISTRACTION AND PERSONAL INJURY.THIS PE HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA05-013) TO FURTHER ASSESS THIS MATTER.
PE05021 · opened Apr 28, 2005 · closed Aug 26, 2005