Model year record

2022 Thor Motor Coach Palazzo recalls & problems

The 2022 Thor Motor Coach Palazzo has 1 safety recall and 4 owner complaints on file with NHTSA. The most-reported problem area is tires (2 complaints).

Recalls1safety recalls

Complaints4filed by owners

Crashes · fires0 · 0reported in complaints

Injuries · deaths0 · 0reported in complaints

Safety recalls

EquipmentFeb 23, 2023

Recreational vehicle/trailer

Recall 23V1130001,969 vehicles

Problem: Thor Motor Coach (TMC) is recalling certain 2015-2023 Palazzo recreational vehicles. The front lower cap brackets that support the front fiberglass panel may become loose and detach from the vehicle while in motion.
Risk: A detached bracket can become a road hazard, increasing the risk of a crash.
Fix: Dealers will inspect and replace the front lower brackets, as necessary, free of charge. Owner notification letters were mailed March 15, 2023. Owners may contact TMC customer service at 1-877-855-2867. TMC's number for this recall is RC000291.

Recall repairs are free at any authorised dealer. A recall listed here may already have been fixed on a particular car: enter its 17-character VIN at nhtsa.gov/recalls to see open recalls.

What owners report

Problem area	Complaints	Typical mileage*
TiresPressure monitoring and regulating systems; Valve	2	—
StructureBody	2	—
Wheels	1	—

*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.

Recent owner complaints

Structure
The contact owns a 2022 Thor Motor Coach Pallazo RV built on a 2022 Freightliner XC-S Chassis. The contact stated that while driving approximately 55-60 MPH, the front cap was shuddering, and the contact noticed that the windshield was abnormally moving from side to side. Additionally, a prior crack on the windshield was expanding due to the failure. The contact stated that upon arriving at the residence, the contact became aware that the windshield had cracked significantly. The RV was taken to an Auto Glass Shop, and the windshield was replaced. The contact was informed that upon installing the windshield, the windshield was 1-2 inches too low due to defective brackets. The RV was taken…
Jul 10, 2025 · 13,160 miles
Tires › Valve
Re: NHTSA #21V-921 Referring to this recall, when Freightliner performed this recall, they removed the stem extension without replacing it with a properly functioning stem extension. I consider this repair to be unacceptable as it does not provide access to the air stem on the inner rear tires without having to jack up the Motorhome and crawling underneath the vehicle. Properly functioning stem extension are readily available as millions of Semi Trucks operate with them daily. I have tried to contact Freightlinerâs Warranty Dept. without benefit of a reply. It is my evaluation that this recall has not been properly performed.02
Feb 23, 2023
Structure › Body
The Thor Palazzo has 2 braces in the front "nose" area of the coach-these braces are metal brackets that attach the front fiberglass nose to the area that contains the generator and fans for the air conditioner and other front-end components. These braces attach at both ends: the front part of the brace attaches w/ screws to a piece of wood that is then screwed into the fiberglass on the very front of the motorhome. The back side of the brace is attached w/ screws to a metal piece. This bracket acts as a support to the front windshield of the coach. This piece of metal on the passenger side of the motorhome came completely off & was drug under the front of the motorhome. Luckily, we were at…
Oct 14, 2022
Wheels
On several occasions, I have received a "High Tire Pressure" warning indicating that one of my tires is either too hot or the pressure is excessive. On other occasions, I have gotten a High Tire Temperature Warning. Daimler Truck North America issued a campaign on this (number SF644A-C) and I took my motorhome in to get repaired. They reprogramed the TPMS computer. However, I am still having problems. I have contacted the dealer, they tell me they do not know of any other repairs or campaigns for this issue and there is nothing that can be done at the moment. This issue is extremely nerve-racking when the alert comes up on my dash while I am on the highway. I am in constant fear that one of…
May 30, 2022

Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.