The 2000 Volvo S80 has 5 safety recalls and 318 owner complaints on file with NHTSA. The most-reported problem area is vehicle speed control (94 complaints).
NHTSA recall 10V566000 · Nov 8, 2010 · 416 vehicles
Problem: VOLVO IS RECALLING CERTAIN VEHICLES EQUIPPED WITH GARMIN 760 PORTABLE GLOBAL POSITIONING SYSTEM (GPS) UNITS BECAUSE THE BATTERIES ON THOSE UNITS MAY OVERHEAT.
Risk: AN OVERHEATED BATTERY COULD LEAD TO A FIRE.
Fix: VOLVO ADVISES OWNERS TO PLEASE STOP USING THE GARMIN PORTABLE GPS DEVICE IMMEDIATELY, AND VISIT THE GARMIN WEBSITE TO DETERMINE IF THEIR UNIT IS AFFECTED. THE UNIT'S BATTERY WILL BE REPLACED WITH A NEW BATTERY AND A SPACER WILL BE INSERTED ON TOP OF THE BATTERY NEXT TO THE PCB. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON NOVEMBER 18, 2010. OWNERS MAY CONTACT GARMIN AT 866-957-1981 OR VISIT GARMIN'S WEBSITE AT WWW.GARMIN.COM/NUVIBATTERYPCBRECALL.
Service brakes, hydraulic › Foundation components › Master cylinder
NHTSA recall 07E023000 · Mar 29, 2007 · 13,128 vehicles
Problem: CERTAIN CARDONE MASTER CYLINDERS WITH PART NUMBERS 10-2925, 10-2987, 10-2987MZA, 10-3083, 11-3015, 11-3042, 11-3044, 11-3045, 11-3047, 11-3064, AND 11-3156, AND WITH DATE CODES LOWER THAN DCA7078 SOLD AS REPLACEMENT EQUIPMENT FOR USE ON THE VEHICLES LISTED ABOVE. THE SEAL ON MASTER CYLINDER CAN FAIL AND LEAK BRAKE FLUID.
Risk: LOSS OF BRAKE FLUID CAN RESULT IN POOR BRAKING PERFORMANCE, POSSIBLY RESULTING IN A VEHICLE CRASH.
Fix: CARDONE WILL NOTIFY OWNERS AND OFFER TO REPURCHASE ANY DEFECTIVE MASTER CYLINDERS. THE RECALL BEGAN DURING APRIL 2007. OWNERS CAN CONTACT CARDONE AT 1-800-777-4780.
Vehicle speed control
NHTSA recall 06V441000 · Nov 15, 2006 · 170,099 vehicles · opened after NHTSA action (ODI)
Problem: ON CERTAIN PASSENGER VEHICLES, A COMBINATION OF THROTTLE POSITIONING SENSOR IRREGULARITIES, A DIRTY THROTTLE HOUSING, AND/OR INEFFICIENT SOFTWARE CALIBRATION MAY CAUSE A WARNING LAMP TO LIGHT AND THE SUBSEQUENT ONSET OF LIMP HOME MODES.
Risk: THIS RESULTED IN A HIGH NUMBER OF VEHICLES GOING INTO THE LIMP HOME MODE WITHOUT NEED.
Fix: DEALERS WILL INSTALL THE CURRENT SOFTWARE UPGRADE ONTO THE INVOLVED VEHICLES. THE RECALL BEGAN ON DECEMBER 29, 2006. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.
Problem: ON CERTAIN PASSENGER AND SPORT UTILITY VEHICLES, UNDER CERTAIN OPERATING CONDITIONS, SOME ELECTRIC COOLING FANS MAY OVERHEAT POTENTIALLY CAUSING HEAT DAMAGE AND, IN RARE INSTANCES, A FIRE IN THE ENGINE COMPARTMENT.
Risk: A FIRE IN THE ENGINE COMPARTMENT COULD OCCUR.
Fix: DEALERS WILL REPLACE THE COOLING FAN. THE RECALL BEGAN ON NOVEMBER 29, 2004. CUSTOMERS SHOULD CONTACT VOLVO CARS AT 1-800-458-1552.
Suspension › Front › Control arm › Upper ball joint
NHTSA recall 00V238000 · Aug 24, 2000 · 49,488 vehicles
Problem: VEHICLE DESCRIPTION: PASSENGER VEHICLES. OVER TIME, THE BALL JOINT BETWEEN THE FRONT WHEEL KING PIN AND THE SUSPENSION LINK ARM, CAN EXPERIENCE INCREASED LOOSENESS.
Risk: THIS CONDITION COULD AFFECT THE BALL JOINT'S DURABILITY AND PERFORMANCE.
Fix: DEALERS WILL REPLACE BOTH FRONT BALL JOINTS.
Recall repairs are free at any authorised dealer. A recall listed here may already have been fixed on a particular car: enter its 17-character VIN at nhtsa.gov/recalls to see open recalls.
Crash test ratings
2000 Volvo S80 4-DR. w/SAB
Overall
Not Rated
Frontal crash
Not Rated
Side crash
Not Rated
Rollover
Not Rated
NHTSA 5-Star Safety Ratings (New Car Assessment Program). Ratings are comparable only between vehicles of similar size and weight, and ratings from 2011 on use tougher tests than earlier years. Photos: NHTSA.
Fuel economy
S80
19mpg combined
City / highway
16 / 24 mpg
Fuel
Premium Gasoline
2.9 L · 6 cyl · Automatic 4-spd · Front-Wheel Drive · about $4,350/year to fuel
S80
18mpg combined
City / highway
16 / 23 mpg
Fuel
Premium Gasoline
2.8 L · 6 cyl · Automatic 4-spd · Front-Wheel Drive · about $4,550/year to fuel
EPA estimates from fueleconomy.gov for each engine and transmission sold. Annual cost is the EPA's estimate for 15,000 miles a year at its current fuel and electricity price assumptions. Your results will vary.
What owners report
Problem area
Complaints
Crashes
Fires
Injuries
Typical mileage*
Vehicle speed control Accelerator pedal; Linkages
94
3
0
0
70,117 mi
Engine and engine cooling Engine; Engine › Gasoline
72
0
3
0
67,000 mi
Electrical system Ignition; Wiring › Front underhood
54
0
5
0
81,561 mi
Fuel system, gasoline Delivery; Storage › Tank assembly › Filler pipe and cap
36
0
1
5
81,381 mi
Suspension Front; Front › Control arm › Upper ball joint
34
3
0
0
68,900 mi
Power train Automatic transmission; Automatic transmission › Control module (tcm/pcm/tecm)
24
0
0
0
86,000 mi
Service brakes, hydraulic Antilock/traction control/electronic limited slip › Control unit/module; Antilock/traction control/electronic limited slip
20
1
0
0
93,500 mi
Air bags Frontal; Frontal › Sensor/control module
19
7
0
5
111,000 mi
Steering Rack and pinion › Rack; Steering wheel/handle bar
17
2
0
0
58,475 mi
Visibility Sun/moon roof assembly; Windshield
15
0
0
1
92,000 mi
Exterior lighting Headlights; Turn signal › Flasher unit
9
0
0
0
71,000 mi
Unknown or other
8
0
0
0
75,780 mi
*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.
Recent owner complaints
Sep 5, 2022 · 120,000 milesVehicle speed control The contact owns a 2000 Volvo S80. The contact stated that while at a complete stop, the vehicle intermittently hesitated in responding while depressing the accelerator pedal. The contact stated that the check engine warning light was illuminated during the failure. The contact called the dealer and the manufacturer and was informed that the vehicle was not included in NHTSA Campaign Number: 06V441000 (Vehicle Speed Control) which he linked to the failure. The vehicle was not repaired. The failure mileage was approximately 120,000.
Aug 7, 2020 · 119,375 milesAir bags SWAPPED BATTERY AT O'REILLY'S AUTO PARTS. ALL MANUFACTURER SAFETY PROTOCOLS FOLLOWED. AFTER SWAPPING OUT W/NEW BATTERY: CLIMATE CONTROL MODULE NOT WORKING- SRS AIRBAG 'SERVICE URGENT' ERRORS. VOLVO QUOTING $2500 TO REPLACE CCM, $800 FOR REBUILD-PROCESS. DIM IS ALSO FRIED. NO HEAT OR A/C- AIRBAG ACCIDENTAL DEPLOYMENT RISK. QUICK SEARCH ONLINE SHOWS THIS IS A VOLVO ISSUE SPECIFIC TO S60, S80 & XC70 MODELS (ALL YEARS) FILED COMPLIANT W/VT STATE AG- CAP 2020-07438 ORIGINAL REPAIR ORDER ATTACHED
Sep 5, 2018 · crash · 3 injuriesService brakes I WANT TO MAKE YOU AWARE OF A VERY SERIOUS CAR ACCIDENT THAT MY MOTHER HAD ON 9-5-18. SHE WAS DRIVING HER 2000 VOLVO S80 WHEN HER CAR BEGAN TO ACCELERATE ON ITS OWN. SHE WAS NOT ABLE TO CONTROL THE CAR. MY MOM HAD HER FOOT ON THE BRAKE BUT THAT DID NOT STOP THE VEHICLE. UNFORTUNATELY, AT THAT POINT THE CAR WAS OUT OF CONTROL HITTING AND BANGING UP ALL THE CARS AROUND IT. THEN THE CAR FINALLY SMASHED INTO ANOTHER CAR STOPPING THE OUT OF CONTROL CAR. MY MOM WAS SERIOUSLY HURT AND TAKEN TO THE HOSPITAL. SHE HAD EMERGENCY SURGERY TO REPAIR HER AORTA THAT TORE FROM THE CRASH. SHE ALSO BROKE HER STERNUM. I AM DEVASTATED BY WHAT HAPPENED TO MY MOM. I FEEL THAT IT IS EXTREMELY IMPORTANT THAT YOU…
Dec 21, 2015 · 181,000 milesFuel system, gasoline VEHICLE HAS THE SMELL OF FUEL. THE 2001-2005 MODELS HAVE A RECALL FOR THIS SAME ISSUE BECAUSE OF THE PLASTIC ON THE FUEL PUMP FLANGE CRACKING. MANY OWNERS OF THE 2000 MODELS ARE REPORTING THIS ISSUE. THE FUEL PUMP IS THE SAME USED ON THE 2000 YEAR MODEL AS THE 2001-2005 SO THE 2000 SHOULD BE PART OF THE RECALL ALSO. THE SMELL OF FUEL IS NOT JUST UNPLEASANT BUT DANGEROUS. I HAVE A 11 MONTH OLD SON WHO RIDES IN MY CAR AND IT WOULD BE TRAGIC IF SOMETHING HAPPENED TO MY FAMILY OR SOMEONE ELSE. YOU CAN SEARCH GOOGLE AND SEE MANY OTHER OWNERS REPORTING ISSUES IN THE 2000 MODEL VOLVO S80. PLEASE DO SOMETHING ABOUT THIS. THANK YOU! *TR
Nov 2, 2015Electrical system I WAS DRIVING AND MY CAR LIGHTS AND ALL THE ELECTRONIC STOP WORKING AND TURN OFF
Jun 10, 2015 · 65,000 milesFuel system, gasoline TL* THE CONTACT OWNS A 2000 VOLVO S80. THE CONTACT NOTICED A FUEL ODOR NEAR THE REAR SEAT OF THE VEHICLE AND THE FUEL GAUGE INDICATOR DRASTICALLY DECREASED. THE CONTACT DISCOVERED AN EXCESSIVE AMOUNT OF FUEL LEAKING ON THE GROUND NEAR THE REAR SIDE OF THE VEHICLE UNDER THE FUEL TANK. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE FUEL PUMP FLANGE WAS CRACKED. THE MANUFACTURER STATED THAT THE VIN WAS EXCLUDED FROM NHTSA CAMPAIGN NUMBER: 09V483000 (FUEL SYSTEM, GASOLINE). THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 65,000. UPDATE 01/15/16 MA UPDATED 02/04/16. *JB UPDATED 03/04/16*LJ UPDATED 03/14/16.*JB
Mar 27, 2015Visibility MY DRIVER SEAT BELT JUST LOCKED UP AND I AM UNABLE TO GET IT TO RELEASE. ALL OF THE HOUSING INSIDE CAR APPEARS TO BE CRACKING. I HAVE HAD THE TWO FRONT WINDOWS REPAIRED OVER AND OVER AGAIN. AND NOW I CAN'T EVEN LET MY FRONT WINDOWS DOWN. I HAVE ALSO PAID TO HAVE THE THROTTLE BODY REPAIRED. NOT TO MENTION HOW MANY TIMES I HAVE HAD TO REPLACE THE O2 SENSORS. *TR
Oct 6, 2014Fuel system, gasoline WITHIN THE PAST FEW DAYS, I'VE GOTTEN MANY COMPLAINTS ABOUT THE FOUL SMELL OF GASOLINE LINGERING ON MY VEHICLE. SURE ENOUGH, I TAKE IT TO A MECHANIC AND THE FUEL PUMP IS VISIBLY MOIST ON THE EXTERIOR FROM AN OBVIOUS FUEL LEAKAGE. I RESEARCHED "VOLVO S80 FUEL PUMP" AND FOUND A RECALL IS IN PLACE. THE RECALL STARTS FROM 2001 MODELS AND RANGES UP TO 2005 MODELS AND IS DUE TO THE MATERIAL USED IN THE FUEL PUMP (RECALL CAMPAIGN 09V-483). SINCE MY VEHICLE IS A 2000 MODEL, MY LOCAL VOLVO DEALERSHIP SAID "I DO NOT MEET THE QUALIFICATIONS". MY CONCERN IS IF THE MATERIAL USED IN THE ASSEMBLY OF THE FUEL PUMP CHANGED FROM S80 2000 TO 2001 MODELS. I WOULD LIKE TO BE NOTIFIED WHAT MATERIAL WAS USED FOR…
Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.
NHTSA defect investigations
EA05021 · opened Dec 6, 2005 · closed Dec 12, 2006 · led to recall 06V441000THROTTLE CONTROL MALFUNCTION ON NOVEMBER 14, 2006 VOLVO SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA CONCERNING ETM FAILURES IN MODEL YEAR (MY) 1999 THROUGH 2001 VOLVO MODELS (NOT INCLUDING THE S40 AND V40), MY 2002 S60 AND V70 WITH NATURALLY ASPIRATED ENGINES AND MY 2002 V70S.ACCORDING TO VOLVO, ?A COMBINATION OF THROTTLE POSITIONING SENSOR IRREGULARITIES, A DIRTY THROTTLE HOUSING AND/OR INEFFICIENT SOFTWARE CALIBRATION MAY CAUSE A WARNING LAMP TO LIGHT AND THE SUBSEQUENT ONSET OF LIMP HOME MODES.VOLVO FURTHER STATED THAT,THIS RESULTED IN A HIGH NUMBER OF THESE VEHICLES GOING INTO LIMP HOME MODE WITHOUT NEED.?VOLVO INDICATED THAT THIS WAS THE MOST SEVERE CONSEQUENCE OF AN ETM FAULT IN THE SUBJECT VEHICLES.THE RECALL REMEDY IS A SOFTWARE UPGRADE INTRODUCED BY VOLVO ON MARCH 16, 2006 IN A CUSTOMER SATISFACTION PROGRAM.AT THE TIME OF THE NOTIFICATION 161,202 VEHICLES OF THE POPULATION OF 331,301 HAD ALREADY HAD THE…
PE05041 · opened Jul 26, 2005 · closed Dec 7, 2005THROTTLE CONTROL MALFUNCTION PE05-041 WAS OPENED ON JULY, 26, 2005, BASED ON 136 CONSUMER COMPLAINTS TO ODI ALLEGING THROTTLE CONTROL MALFUNCTIONS IN THE SUBJECT VEHICLES.ODI HAS NOW RECEIVED 591 COMPLAINTS OF ETM FAILURES WHICH ALLEGE SYMPTOMS WITH POTENTIAL SAFETY RELATED CONSEQUENCES.THESE INCLUDE ALLEGATIONS OF ENGINE STALL, VEHICLE SURGING FORWARD WITHOUT ACCELERATOR INPUT, VEHICLE HESITATION UPON ACCELERATION AND SUDDEN AND UNEXPECTED TRANSITION INTO REDUCED PERFORMANCE OPERATION (LIMP MODE).VOLVO SUBMITTED OVER 2,900 COMPLAINTS CONCERNING THE ETM IN THE SUBJECT VEHICLES DURING PE05-041.ODI'S PRELIMINARY ANALYSIS OF A SAMPLE THE VOLVO COMPLAINTS IDENTIFIED APPROXIMATELY 55 PERCENT WITH ONE OR MORE OF THE SYMPTOMS DESCRIBED ABOVE.ODI IS CONTINUING ITS ASSESSMENT OF THE INFORMATION CONTAINED IN THE VOLVO COMPLAINTS. IN NOVEMBER 2005, TO RESOLVE AN INVESTIGATION BY THE CALIFORNIA AIR RESOURCES BOARD, VOLVO…
