Model year record
The 2000 Volvo V40 has 1 safety recall and 50 owner complaints on file with NHTSA. The most-reported problem area is service brakes, hydraulic (24 complaints).
Recall repairs are free at any authorised dealer. A recall listed here may already have been fixed on a particular car: enter its 17-character VIN at nhtsa.gov/recalls to see open recalls.
| City / highway | 19 / 26 mpg |
|---|---|
| Fuel | Premium Gasoline |
1.9 L · 4 cyl · Automatic 4-spd · Front-Wheel Drive · about $3,900/year to fuel
EPA estimates from fueleconomy.gov for each engine and transmission sold. Annual cost is the EPA's estimate for 15,000 miles a year at its current fuel and electricity price assumptions. Your results will vary.
| Problem area | Complaints | Typical mileage* |
|---|---|---|
| Service brakes, hydraulicAntilock/traction control/electronic limited slip; Foundation components › Disc › Pads | 24 | 29,000 mi |
| Engine and engine coolingEngine › Gasoline; Engine | 10 | 83,000 mi |
| SuspensionRear › Springs › Coil springs; Rear › Springs | 7 | 63,801 mi |
| Electrical systemIgnition; Horn | 5 | — |
| Exterior lightingHeadlights; Brake lights | 4 | — |
| Vehicle speed control | 4 | 97,750 mi |
| WheelsHub; Lugs/nuts/bolts/studs | 3 | — |
| SteeringRack and pinion | 2 | — |
| StructureBody; Body › Hatchback/liftgate | 2 | — |
| Power trainAutomatic transmission | 2 | — |
| Unknown or other | 1 | — |
| VisibilityWindshield wiper/washer | 1 | — |
*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.
TL* THE CONTACT OWNS A 2000 VOLVO V40. THE CONTACT SHIFTED INTO REVERSE WITH THE BRAKE PEDAL ENGAGED WHEN THE VEHICLE UNINTENTIONALLY ACCELERATED AND DROVE OVER A PLASTIC TRASH RECEPTACLE, CERAMIC POT AND THEN CRASHED INTO THE SIDE OF A NEARBY HOUSE. THERE WAS NO PERSONAL INJURY AND THE EXTERIOR SIDE OF THE HOUSE SUSTAINED MINOR DAMAGE. A POLICE REPORT WAS NOT FILED. THE REAR BUMPER COMPLETELY DETACHED AND THE VEHICLE WAS IN THE PROCESS OF BEING TOWED TO A COLLISION CENTER. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS UNAVAILABLE. UPDATED 10/04/11*LJ UPDATED 3/22/12 *CN
2000 VOLVO V40 - VERY WELL MAINTAINED, 2ND OWNER, APPROXIMATELY 83,000 MILES. I STARTED NOTICING THAT THE CAR WOULD SURGE ON THE HIGHWAY WITH THE A/C ON AND WHEN I HAD STEADY PRESSURE ON THE ACCELERATOR (I.E. ICRUISING AT A STEADY SPEED). THE SURGE IN RPM'S WOULD BE RHYTHMIC, VERY SUBTLE (100-200 RPMS) AND CONTINUE INDEFINITELY UNTIL I TURN THE A/C OFF - AT WHICH TIME THEY WOULD CEASE. THEY WOULD SOMETIMES RESUME WHEN I TURNED THE A/C COMPRESSOR BACK ON. THIS HAPPENED INFREQUENTLY OVER THE PAST MONTH (IT'S JUNE IN CT, MY STATE OF RESIDENCE) AND WOULD NOT HAPPEN EVERY TIME I RAN THE A/C - BUT ONLY OCCURRED WHEN THE A/C COMPRESSOR WAS RUNNING. THEN A REMARKABLE THING HAPPENED TODAY - WHILE…
BRAKES FAILED COMING INTO MY DRIVEWAY. ABLE TO STOP CAR BY USING EMERGENCY BRAKE. COULD HAVE CAUSED A CRASH. BROUGHT TO BE SERVICED. MECHANIC REPORTED THAT IT WAS FAILED LEFT FRONT BRAKE HOSE DUE TO SPRING SUPPORT RUBBING THROUGH. THIS HOSE HAS BEEN REPLACED AND THE OLD PART IS AVAILABLE. MECHANIC ALSO REPORTED THAT RIGHT FRONT BRAKE HOSE NEEDS TO BE REPLACED BECAUSE OF SAME REASON. AN APPOINTMENT FOR THIS HAS BEEN SCHEDULED AND PART WILL BE AVAILABLE. HE FEELS THIS WILL BE A DESIGN ISSUE. *TR
VEHICLE IDLE INCREASE ON BRAKING TO ABOUT 1500 RPMS. WHEN PUT IN PARK, IDLE INCREASED TO 4500 RPMS. I TRIED TAPING THE GAS TO SEE IF RPMS WOULD GO DOWN. INSTEAD RPMS INCREASED EVEN HIGHER TO OVER 5500 RPMS. TURNED THE CAR OFF. TRIED TO RESTART CAR AND RPMS IMMEDIATELY WENT HIGH AGAIN. TURNED THE CAR OFF A SECOND TIME. COULD NOT RESTART THE CAR. A SIMILAR INCIDENT HAPPENED 36 HOURS LATER AFTER THE CAR HAD BEEN AT THE REPAIR SHIP. THAT INCIDENT HAPPENED AFTER DRIVING AROUND A PARKING LOT LOOKING FOR A SPACE. RPM'S INCREASED. WHEN PUT IN PARK THE RPM'S INCREASED TO OVER 4000 RPMS. CAR TOWED TO REPAIR SHOP. *TR
FAILURE OF UPPER STRUT MOUNT BUSHINGS CAUSING LOSS OF SUSPENSION / STEERING. REPLACED FOR THE THIRD TIME ON 2000 V-40 VOLVO. RECENTLY VOLVO OFFERED A NEWLY DESIGNED HEAVY DUTY MOUNT AT THREE TIME THE REPLACEMENT COST DEMONSTRATING THAT ORIGINAL EQUIPMENT MOUNT WAS SEVERELY UNDER DESIGNED. *TR
EVER SINCE I BOUGHT THE 2000 VOLVO V40 STATIONWAGON FROM A PRIVATE DEALERSHIP I'VE HAD NOTHING BUT PROBLEMS TRYING TO START THE CAR. WHEN TRYING TO CRANK UP VEHICLE IT TAKES A COUPLE OF SECONDS BEFORE THE CAR ACTUALLY STARTS AND IT SMELLS LIKE GAS AFTERWARDS. I'VE TAKEN IT TO THE MECHANICS AND THEY HAVE GIVEN IT A FULL TUNE UP AND REPLACED THE INJECTORS BUT STILL I HAVE THE SAME PROBLEM. *TR
ON JULY 19,2008, OUR 2000 VOLVO V40 LOST POWER WHILE DRIVING 65 MPH ON US 29 IN VIRGINIA. THE CAR WAS STILL RUNNING, BUT IT DID NOT RESPOND TO THE ACCELERATOR. WE WERE ABLE TO SAFELY PULL OFF THE ROAD, AND HAVE CAR TOWED TO OUR MECHANIC. WE WERE TOLD THE PROBLEM WAS A SENSOR FAILURE. ACCORDING TO OUR SERVICE RECORDS, THE BOOST PRESSURE SENSOR AND CAMSHAFT RESET VALVE WAS REPLACED. THREE DAYS LATER, ON JULY 26, 2008, THE SAME THING HAPPENED - THIS TIME IN THE MIDDLE OF A BUSY INTERSECTION. AGAIN, FORTUNATELY, THE CAR REMAINED RUNNING AND SEEMED TO LIMP ALONG TO GET OUT OF THE WAY OF TRAFFIC. AGAIN, THE CAR WAS TOWED TO OUR MECHANIC, WHERE THEY HAVE BEEN UNABLE TO DIAGNOSE THE PROBLEM. A…
WE PURCHASED OUR 2000 V40 FROM THE ORIGINAL OWNER AT 81K. WE NEEDED BOTH REAR SPRINGS REPLACED RIGHT AWAY. THIS WAS THE SECOND TIME THEY WERE REPLACED. DEALER SAID A COMMON FLAW WITH THE V40. WE ARE ALSO NOTICING A SHAKING IN THE FRONT END WHEN ACCELERATING BETWEEN 50-60MPH. NOT SURE WHAT THIS IS. ALSO NOTICING THAT THERE IS A SHAKE IN THE BRAKE PEDAL AND TOLD NEED NEW BRAKE PADS AND ROTORS. THEY WERE JUST REPLACED BEFORE WE GOT THE CAR AT 75K AND NOW CAR HAS 100K WHICH IS A ALL HIGHWAY MILES. WE HAVE ALSO NOTICED DIFFICULTY WITH THE BRAKING SYSTEM, SOMETIMES TROUBLE STOPPING AND BRAKES SQUEAL AFTER SITTING FOR A COUPLE OF DAYS. HEAD LIGHTS AND TAIL LIGHTS ALSO HAVE BURNT OUT QUITE…
Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.
IN A NOVEMBER 6, 2003 SAFETY DEFECT REPORT, VOLVO INDICATED THAT THEY WILL CONDUCT A SAFETY-RELATED DEFECT RECALL OF THE 2000 MODEL YEAR (MY) SUBJECT VEHICLES (ABOUT 36,000 VEHICLES).VOLVO WILL ALSO CONDUCT A SERVICE CAMPAIGN OF ABOUT 31,000 2001 MY SUBJECT VEHICLES.ODI INVESTIGATED BOTH THE 2000 AND 2001 MY VEHICLES AND DETERMINED THAT THE 2001 MY VEHICLES EXPERIENCED SUBSTANTIALLY LOWER RATES OF FAILURES BASED ON THE NUMBER OF OWNER REPORTS AND WARRANTY CLAIMS SUBMITTED TO ODI.ODI BELIEVES THAT THE PROPOSED ACTION IS SUFFICIENT TO RESOLVE THIS INVESTIGATION'S SAFETY ISSUES. FOR THE CRASHES, IN ADDITION TO THE 22 SUBMITTED BY VOLVO, ODI FOUND 10 ADDITIONAL CRASH ALLEGATIONS IN THE OWNER REPORTS, FIELD REPORTS, AND WARRANTY CLAIMS SUBMITTED BY VOLVO.OF THESE 32 CRASHES, ODI BELIEVES THAT 10 ARE CLEARLY RELATED TO THE ALLEGED DEFECT, AND 5 APPEAR TO BE RELATED.OF THE 17 REMAINING CASES,…