2004 Volvo V70XC recalls & problems
The 2004 Volvo V70XC has no safety recalls on file with NHTSA, and 5 owner complaints. The most-reported problem area is fuel/propulsion system (2 complaints).
Recalls0safety recalls
Complaints5filed by owners
Crashes · fires0 · 1reported in complaints
Injuries · deaths1 · 0reported in complaints
Safety recalls
No safety recalls have been filed for the 2004 Volvo V70XC.
Recall repairs are free at any authorised dealer. A recall listed here may already have been fixed on a particular car: enter its 17-character VIN at nhtsa.gov/recalls to see open recalls.
What owners report
| Problem area | Complaints | Typical mileage* |
|---|---|---|
| Fuel/propulsion system | 2 | — |
| Fuel system, gasoline | 1 | — |
| Seats | 1 | — |
| Suspension | 1 | — |
*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.
Recent owner complaints
- Apr 29, 2017 · 101,000 milesSuspension
I WAS DEPARTING MY HOME VILLAGE ABOUT A BLOCK FROM MY HOME AND I HEARD A LOUD BANG IN THE FRONT DRIVER SIDE AT ABOUT 15 MPH!! NO BUMP.. NOTHING! I LOOKED UNDER THE CAR AND THERE WAS NO OBVIOUS ISSUE AT THE INITIAL LOOK AND I DROVE ANOTHER QUARTER MILE AND HEARD A SLIGHT GRIND OR NOISE ON SMALL BUMPS... THEN A CLANK. I BACKED UP AND THERE WAS A PIECE OF THE COIL SPRING ON THE ROAD!!!! THE FRONT LEFT - DRIVERS SIDE - COIL SPRING SNAPPED IN TWO. AT 101,000 MILES. THE CLEAN BREAK AND NO RUST OR UNUSUAL CORROSION INDICATES A FAULTY METAL. HOW CAN I TRUST THE VOLVO XC AGAIN!! SAFETY AND VOLVO ARE NO LONGER WORDS THAT SHOULD BE USED TOGETHER. MY COMPLAINTS TO VOLVO AMERICA WERE RESPONDED TO WITH… - Sep 1, 2015 · 890,000 milesFuel/propulsion system
ENTERING MY VEHICLE I SMELLED A STRONG ODOR OF GASOLINE. UPON INVESTIGATION, I FOUND THIS WAS DUE TO A CRACKED FUEL PUMP. BECAUSE OF THIS VERY PROBLEM, THIS MAKE AND MODEL OF VEHICLE WAS OFFICIALLY RECALLED BY VOLVO IN 2009 AS PART OF NHTSA ACTION NUMBER : PE09039 NHTSA RECALL CAMPAIGN NUMBER : 09V483000 . HOWEVER THE RECALL ONLY APPLIES TO VEHICLES SOLD IN AL, AZ, AR, CA, FL, GA, HI, KY, LA, MS, NV, NM, NC, OK, SC, TN, TX, UT, VA AND THE US TERRITORIES. THE PROBLEM CAN HAPPEN TO ANY OF THESE CARS REGARDLESS OF WHERE THEY WERE SOLD. THE TEMPERATURE FLUCTUATIONS THAT MAY BE RESPONSIBLE FOR THE SAFETY HAZARD OCCUR IN NEW ENGLAND AS WELL AS THE SOUTH AND WEST. THE DEFECTIVE PART AND SAFETY… - Mar 14, 2015 · 234,123 miles · fire · 1 injurySeats
THE DRIVER SIDE SEAT WARMER CAUGHT FIRE. IT BURNED A HOLE THROUGH THE SIDE OF THE SEAT COVER AND ALSO CAUSED A MILD BURN TO MY LEG. I STOPPED THE CAR, SHUT OF THE SEAT WARMER, AND WAS ABLE TO EXTINGUISH THE FIRE WHILE IT WAS STILL SMALL. A SEARCH ON THE INTERNET REVEALED THAT OTHER OWNERS HAVE EXPERIENCED THIS PROBLEM. *TR - Dec 13, 2012 · 105,000 milesFuel/propulsion system
FUEL SMELL COMING FROM TRUNK. POSSIBLE COMBUSTION. PREVIOUS RECALL WAS NOT EXTENDED TO COLORADO, BUT AS THE FRONT RANGE SUMMER TEMPERATURES AND DRYNESS ARE AN INDICATOR OF FAILURE, I WORRY THAT THIS RECALL SHOULD BE EXTENDED TO COLORADO OWNERS. *TR - Aug 25, 2009 · 57,000 milesFuel system, gasoline
THE FUEL PUMP IN MY 2004 VOLVO XC70 FAILED, CAUSING GAS TO LEAK FROM THE VEHICLE. I UNDERSTAND FROM A NYT ARTICLE THAT THERE ARE SEVERAL COMPLAINTS INTO NHTSA REGARDING A SIMILAR CONDITION IN THE 2004 XC90. THE LEAKING PUMP WAS REPAIRED BY A VOLVO DEALER AT CONSIDERABLE ($1300) COST. *TR
Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.