Model year record
2006 Yamaha FZ1 recalls & problems
The 2006 Yamaha FZ1 has no safety recalls on file with NHTSA, and 9 owner complaints. The most-reported problem area is structure (6 complaints).
Safety recalls
No safety recalls have been filed for the 2006 Yamaha FZ1.
Recall repairs are free at any authorised dealer. A recall listed here may already have been fixed on a particular car: enter its 17-character VIN at nhtsa.gov/recalls to see open recalls.
What owners report
| Problem area | Complaints | Typical mileage* |
|---|---|---|
| StructureBody; Frame and members | 6 | 18,000 mi |
| Electrical system | 2 | — |
| Engine | 2 | — |
*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.
Recent owner complaints
- Structure › Body
The weld that holds the different sections of the frame of the motorcycle has a crack. The weld from the manufacture is defective. The crack is in parallel and in the middle of the weld. It is clearly visible on both sides of the bike just below the gas tank. The crack can cause the bike to fall apart during riding putting the rider and nearby traffic in mortal danger.
- Electrical system
DUE TO MANUFACTURER DESIGN THE MAGNETS ON THE STATOR FLY WHEEL BECAME COMPROMISED. THE RESULT IS A FAILED CHARGING SYSTEM. POSSIBLE INTERNAL MOTOR DAMAGE AS WELL. I WAS ON THE FREEWAY WHEN I SMELLED THE COMPONENTS BURNING UP AND MY SEAT BECAME VERY HOT. *TR
- Engine
WHILE TURNING LEFT THROUGH A CITY INTERSECTION THE ENGINE DIED FORCING ME TO PUSH MOTORCYCLE THROUGH REMAINDER OF TURN TO AVOID A COLLISION WITH APPROACHING TRAFFIC. ALTHOUGH THE MILEAGE/TIME ON MY PARTICULAR VEHICLE IS OUT OF FACTORY WARRANTY, A SMALL AMOUNT OF RESEARCH SHOWS THIS TO BE A COMMON ISSUE WITH YAMAHA FZ1, FZ8, & 2004-2006 YAMAHA R1 (SAME ENGINE CONFIGURATION). ALSO THE MANUFACTURER HAS RELEASED A REDESIGNED COMPONENT TO ADDRESS THIS SITUATION.
- Structure › Body
TL* THE CONTACT OWNS A 2006 YAMAHA FZ1. WHILE DRIVING 40 MPH, THE MOTORCYCLE FELT UNSTABLE. THE CONTACT PULLED OVER AND NOTICED THAT THE FRAME OF THE MOTORCYCLE HAD FOLDED AND SUBSEQUENTLY COLLAPSED. THE CONTACT SAW THAT THE FRAME HAD FAILED AND FRACTURED IN HALF. THE MOTORCYCLE WAS NOT TAKEN TO A DEALER OR MECHANIC. THE DEALER WAS NOT CONTACTED. THE MOTORCYCLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND WAS DECIDING ON A COURSE OF ACTION. THE APPROXIMATE FAILURE MILEAGE WAS 18,000.
- Structure › Body
FRAME CRACKED ALONG FACTORY WELD ON THE RIGHT SIDE INSIDE/OUTSIDE VERTICAL AND LOWER HORIZONTAL. THE MOTORCYCLE HAS NEVER BEEN DROPPED OR CRASHED AND PASSED MARYLAND STATE SAFETY INSPECTION YESTERDAY. WHEN WASHING THE BIKE TODAY, I NOTICED A LINEAR CRACK THAT RAN VERTICALLY ALONG THE WELD ON THE RIGHT SIDE OF THE FRAME BELOW THE TANK. NO WRECKS, EXCESSIVE STRESS OR TEMPERATURE CHANGE PRECEDED CRACK. THE BIKE HAD ONLY MADE A 3 MILE TRIP FROM THE INSPECTION STATION TO MY HOME WHEN I NOTICED THE CRACK. THIS IS CLEARLY A MANUFACTURING DEFECT AND IT IS AN OUTRAGE THAT THESE FRAMES WEREN'T RECALLED FOR SAFETY.
- Electrical system
ROTOR ASSEMBLY MAGNETS CAME UNGLUED WHILE RIDING AND RUIN ENGINE FORCING THE MOTORCYCLE TO STOP RUNNING AT HIGH SPEED.
- Structure › Body
MY SON AND MYSELF WENT FOR A SHORT RIDE IN THE WARM OF THE DAY AFTER ATTENDING CHURCH. AFTER RIDING ABOUT AN HOUR WE STOPPED AT A FRIENDS HOUSE WHERE THE FRIEND CAME OUT TO CHECK OUT MY BIKE.WE THEN NOTICED THE CRACK ON THE RIGHT SIDE OF THE FRAME JUST ABOVE THE ENGINE.THE CRACK GOES ALL THE WAY DOWN THE WELD LINE OF THE FRAME AND UNDER THE BOTTOM OF THE FRAME IN THE WELD LINE,COULD BE ON THE BACK SIDE OF THE FRAME ALSO,BUT THE BIKE WOULD NEED TO BE DISASSEMBLED TO INSPECT ANY FURTHER. *TR
- Structure › Frame and members › Underbody shields
MOTORCYCLE RIGHT SIDE FRAME WELD ABOVE CLUTCH ENGINE COVER WAS FOUND WITH A CRACK. THE CRACK IN THE WELD APPEARS TO RUN ALONG THE OUTSIDE OF THE FRAME AND CONTINUOUSLY UNDER THE FRAME AND BACK UP THE INSIDE OF THE FRAME. THE MOTORCYCLE HAS NEVER BEEN INVOLVED IN A CRASH. THE FRAME WELD HAS JUST FAILED. *TR
Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.