Model year record

2001 Audi allroad recalls & problems

The 2001 Audi allroad has 3 safety recalls and 17 owner complaints on file with NHTSA. The most-reported problem area is suspension (5 complaints).

Recalls3safety recalls

Complaints17filed by owners

Crashes · fires1 · 0reported in complaints

Injuries · deaths1 · 0reported in complaints

Safety recalls

Fuel system, gasolineApr 8, 2008

Storage › Tank assembly

Recall 08V15700068,240 vehiclesopened after NHTSA action (ODI)

Problem: VOLKSWAGEN IS RECALLING 68,240 MY 2001-2004 AUDI A6 QUATTRO VEHICLES EQUIPPED WITH 2.7L, 2.8L, OR 3.0L ENGINES AND MY 2001-2005 ALLROAD QUATTRO VEHICLES EQUIPPED WITH 2.7L OR 4.2L ENGINES. THE AGING OF THE PLASTIC MATERIAL IN THE FUEL TANK ROLLOVER VALVE COMBINED WITH BENDING STRESS FROM THE ALUMINUM VENTILATION LINE TO THE ROLLOVER VALVE NIPPLE MAY LEAD TO CRACKING OF THE NIPPLE. IF THIS HAPPENS, A FUEL LEAK MAY RESULT.
Risk: A FUEL LEAK IN THE PRESENCE OF AN IGNITION SOURCE COULD LEAD TO A VEHICLE FIRE.
Fix: DEALERS WILL REINFORCE THE NIPPLE ON THE ROLLOVER VALVE TO PREVENT LEAKAGE OR REPAIR THE CRACKING AT THE NIPPLE. THE RECALL BEGAN ON JUNE 27, 2008. OWNERS MAY CONTACT AUDI AT 1-800-822-2834.

Electrical systemJun 5, 2006

Electrical system

Recall 06V19800070,512 vehiclesopened after NHTSA action (ODI)

Problem: ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH HALOGEN LOW BEAM HEADLIGHTS, CERTAIN CONNECTOR PINS IN THE HEADLIGHT SWITCH CONNECTOR COME INTO CONTACT WITH EACH OTHER CAUSING A SHORT CIRCUIT. NOTE: VEHICLES WITH XENON LOW BEAM HEADLIGHTS ARE NOT AFFECTED BECAUSE THE CIRCUIT IN THESE VEHICLES CONTAINS A FUSE, WHICH PRECLUDES EXCESSIVE CURRENT FLOW IN THE CASE OF A SHORT CIRCUIT. AUDI S6 AND S6 AVANT VEHICLES ARE ALL EQUIPPED WITH XENON LOW BEAM HEADLIGHTS AND, THEREFORE, ARE NOT LONGER AFFECTED BY THIS RECALL.
Risk: THIS CONDITION COULD LEAD TO OVERHEATING OR FIRE.
Fix: DEALERS WILL REROUTE THE WIRING HARNESS BY INSTALLING A JUMPER WIRING HARNESS. THE RECALL BEGAN ON DECEMBER 16, 2006. OWNERS MAY CONTACT AUDI AT 1-800-822-2834.

Electrical systemMar 18, 2004

Electrical system

Recall 04V133000172,866 vehiclesopened after NHTSA action (ODI)

Problem: ON CERTAIN PASSENGER VEHICLES, IF A DRIVER'S KNEES PUSH AGAINST THE KNEE BOLSTER (CRASH ELEMENT) LOCATED UNDER THE DASHBOARD, IT CAN CONTACT THE HEADLIGHT SWITCH WIRING HARNESS, AND AN ELECTRICAL SHORT COULD OCCUR.
Risk: A FIRE COULD ORIGINATE IN THE LEFT DASHBOARD AREA.
Fix: DEALERS WILL INSTALL A PROTECTIVE COVERING ON THE KNEE BOLSTER (CRASH ELEMENT). IN ADDITION, THE WIRING HARNESS AS WELL AS THE FELT PROTECTOR ON THE LEFT SIDE OF THE DASHBOARD CARRIER WILL BE CHECKED, AND REPLACED IF NECESSARY. THE RECALL BEGAN ON JULY 26, 2004. OWNERS SHOULD CONTACT AUDI AT 1-800-822-2834.

Recall repairs are free at any authorised dealer. A recall listed here may already have been fixed on a particular car: enter its 17-character VIN at nhtsa.gov/recalls to see open recalls.

Fuel economy

Allroad

16mpg combined

City / highway	14 / 19 mpg
Fuel	Premium Gasoline

2.7 L · 6 cyl · Manual 6-spd · 4-Wheel or All-Wheel Drive · about $5,150/year to fuel

Allroad

16mpg combined

City / highway	14 / 19 mpg
Fuel	Premium Gasoline

2.7 L · 6 cyl · Automatic (S5) · 4-Wheel or All-Wheel Drive · about $5,150/year to fuel

EPA estimates from fueleconomy.gov for each engine and transmission sold. Annual cost is the EPA's estimate for 15,000 miles a year at its current fuel and electricity price assumptions. Your results will vary.

What owners report

Problem area	Complaints	Crashes	Injuries	Typical mileage*
SuspensionRear › Springs › Air suspension system › Springs/bags; Rear › Springs › Air suspension system › Lines and fittings	5	0	0	49,400 mi
Power trainDriveline; Automatic transmission › Control module (tcm/pcm/tecm)	4	0	0	47,900 mi
Vehicle speed controlAccelerator pedal	3	0	0	47,900 mi
Fuel/propulsion system	3	0	0	—
Fuel system, otherStorage › Fuel gauge system; Delivery	2	0	0	—
Equipment	2	0	0	—
Engine and engine coolingEngine; Exhaust system › Emission control › Catalytic convertor	2	0	0	—
Electrical system	2	0	0	—
Air bags	2	1	1	—
Tires	1	0	0	—
Equipment adaptive/mobility	1	0	0	—
Steering	1	0	0	—

*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.

Recent owner complaints

Fuel/propulsion system
FUEL AND FUEL VAPOR LEAKS FROM THE TOP OF THE FUEL TANK PRESENTING A SERIOUS FIRE HAZARD WHEN MOVING (SLOWLY OR AT HIGHWAY SPEEDS) OR STATIONARY. THE FUEL LEAK IS MOST OBVIOUS WHEN THE TANK IS MORE THAN 1/2 FULL. VAPOR EMISSIONS OCCUR AT ALL TIMES RESULTING IN A FAILURE TO MEET EMISSIONS STANDARDS. A HARD PLASTIC MATERIAL IS USED FOR THE FUEL TANK'S VENT. IT IS CONNECTED TO A RIGID ALUMINUM VENT LINE. RELATIVE MOVEMENT AND AGING HAS RESULTED IN A FAILURE OF THE PLASTIC VENT. AUDI'S RECALL FIX FROM 2008 (NHTSA 08V-157) - I.E., INSTALLING AN EPOXY-FILLED MOLD - HAS NOT PREVENTED FAILURE OF THE PLASTIC VENT. SINCE THE PLASTIC VENT IS 'WELDED' TO THE TOP OF THE HDPE TANK, THE ENTIRE TANK MUST…
Aug 1, 2017 · 127,000 miles
Fuel/propulsion system
TL* THE CONTACT OWNS A 2001 AUDI ALLROAD. WHEN FILLING THE FUEL TANK, THE CONTACT NOTICED THAT THE TANK LEAKED FUEL. THE VEHICLE WAS TAKEN TO THE DEALER, BUT WAS NOT DIAGNOSED OR REPAIRED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 08V157000 (FUEL SYSTEM, GASOLINE). THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 100,800.
Jan 26, 2016 · 100,800 miles
Fuel/propulsion system
TL* THE CONTACT OWNS A 2001 AUDI ALLROAD. THE CONTACT STATED THAT FUEL WAS LEAKING FROM THE VEHICLE. THE VEHICLE WAS TAKEN TO A DEALER AND IT WAS DETERMINED THAT THE REINFORCEMENT NIPPLE TO THE ROLLOVER ON THE FUEL TANK FAILED. THE MANUFACTURER STATED THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 08V157000 (FUEL SYSTEM) AND WOULD NOT BE REPAIRED UNDER THE RECALL. THE FAILURE MILEAGE WAS UNKNOWN.
May 25, 2015
Suspension › Front
TL* THE CONTACT OWNS A 2001 AUDI ALLROAD QUATTRO. WHILE DRIVING APPROXIMATELY 30 MPH, THE FRONT DRIVER SIDE AIR SUSPENSION SYSTEM FAILED WITHOUT WARNING CAUSING THE VEHICLE TO COLLAPSE. THE CONTACT WAS ABLE TO DRIVE THE VEHICLE TO AN AUTHORIZED DEALER WHERE THEY INFORMED HIM THAT THERE WAS A LEAK IN THE AIR SUSPENSION AIR BAG. THE VEHICLE WAS NOT REPAIRED. THE CONTACT STATED THAT THE FRONT DRIVER AND PASSENGER SIDE AIR BAG SUSPENSION WERE PREVIOUSLY REPLACED IN 2005 AND 2006. THE FAILURE MILEAGE WAS APPROXIMATELY 70,000.
Aug 6, 2005 · 70,000 miles
Air bags
AIRBAG LIGHT ON AND CONTROL MODULE NEEDS REPLACING. *TR
Dec 13, 2010 · 83,500 miles
Visibility › Power window devices and controls
TROUBLE OCCURRED WITH BOTH DRIVER AND PASSENGER WINDOWS, BUT AT DIFFERENT TIMES. PASSENGER WINDOW WAS STILL UNDER WARRANTY AT THE TIME. WINDOW WOULD NOT CLOSE PROPERLY AND THEN WOULD SPONTANEOUSLY OPEN. ATTEMPTS TO CLOSE IT ENTIRELY WERE OFTEN NOT SUCCESSFUL. MOTOR WAS REPLACED ON BOTH WINDOWS-ONE UNDER WARRANTY, THE OTHER NOT. A SECOND OCCURRENCE WITH DRIVER WINDOW REQUIRED ANOTHER COSTLY REPAIR, ALTHOUGH THE CAUSE WAS DIFFERENT. THIS HAPPENS ALSO CURRENTLY WITH REAR PASSENGER WINDOW WHEN IT IS COLD. I HAVE HAD NOTHING BUT MECHANICAL ISSUES WITH THIS VEHICLE. *TR
Sep 10, 2008 · 67,000 miles
Electrical system
I OWN A 2001 AUDI ALLROAD, WHICH I PURCHASED THROUGH A DEALER CERTIFIED PRE-OWNED. THERE HAVE BEEN SEVERAL UNUSUAL ISSUES WITH THIS VEHICLE, SUCH AS THE WATER PUMP BREAKING DOWN AT 50,000 MILES AND MANY ELECTRICAL ISSUES. THE MOST RECENT IS THE CAR SEAT HEATER, WHICH MALFUNCTIONED CAUSING A SHORT AND BURNING A HOLE IN THE DRIVER'S SEAT (WHICH IS LEATHER). LUCKILY, I CAUGHT IT BEFORE SMOLDERING OR A FIRE COULD HAVE ENSUED, WHICH COULD HAVE CAUSED ME BODILY HARM OR RISKED THE LIVES OF MY CHILDREN HAD WE BEEN ON A LONG DISTANCE TRIP. I AM IN CONTACT WITH AUDI AND A LOCAL DEALER WHO UPON INSPECTION OF THE VEHICLE WILL DETERMINE HOW TO PROCEED WITH THE REPAIR. MY BIGGEST CONCERN IS THAT I AM…
Oct 17, 2008 · 67,000 miles
Air bagsCrash1 injury
I BOUGHT AN AUDI ALLROAD 2001 2.7T A6 AT A DEALERSHIP IN ALBUQUERQUE NEW MEXICO. THE CAR, AT FIST, WAS HANDLING SO WELL. EVERYTHING SEEMED TO BE IN GREAT SHAPE AND WELL MAINTAINED. I TOOK A TRIP TO COLORADO AND UPON MY ARRIVAL TO MY DESTINATION, THE YELLOW "CAR UNEVEN SUSPENSION" LIGHT CAME ON. THE CAR IMMEDIATELY MADE SOME WEIRD NOISES AND SHIFTED WEIGHT WHILE I WAS DRIVING AT 80MPH ON THE HIGH WAY. I PULLED OVER AND VISUALLY INSPECTED THE CAR. NOTHING COULD BE SEEN. I TOOK IT TOO A VW DEALERSHIP TO HAVE THEM TELL ME WHAT THEY THOUGHT WAS WRONG. LONG STORY SHORT. NO ONE KNEW THE AUDI ALLROAD WELL ENOUGH... HOW CONVENIENT!! UPON MY RETURN TO NM AFTER COLORADO, I HAD THE CAR TAKEN TO AUDI IN…
Dec 30, 2007 · 84,600 miles

Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.

NHTSA defect investigations

FUEL TANK LEAKClosedLed to recall 08V156000
VOLKSWAGEN (VW) IS RECALLING CERTAIN VW PASSAT 4MOTION AND AUDI A6 QUATTRO AND ALLROAD QUATTRO ALL-WHEEL DRIVE PASSENGER CARS.VW VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM NOVEMBER 22, 2000 THROUGH MAY 31, 2005 AND AUDI VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM JUNE 2, 2001 TO JUNE 1, 2005.THE NHTSA RECALL NUMBER FOR THE VW VEHICLES IS 08V-156 (VW ALSO IS CORRECTING DEFECTS RELATED TO HEAT SHIELD AND FUEL LINE HAZARDS FOR THESE VEHICLES AND FOR 1999-2000 PASSATS IN THIS RECALL ACTION.)THE NHTSA RECALL NUMBER FOR THE AUDI VEHICLES IS 08V-157.SINCE 2006, ODI HAS RECEIVED 17 COMPLAINTS OF FUEL LEAKING FROM THE SUBJECT VEHICLES' FUEL TANKS.THE 400 COMPLAINTS SHOWN ABOVE MAY INCLUDE DUPLICATE REPORTS TO ODI AND THE MANUFACTURER. WHILE THE CONSEQUENCE (FUEL LEAKS FROM THE TOP OF THE TANK) IS SIMILAR FOR BOTH THE PASSAT AND AUDI SUBJECT VEHICLES, DIFFERENCES IN DESIGN AND…
PE08008 · opened Jan 31, 2008 · closed May 30, 2008