The 2004 Audi allroad has 3 safety recalls and 15 owner complaints on file with NHTSA. The most-reported problem area is vehicle speed control (5 complaints).
Recalls3safety recalls
Complaints15filed by owners
Crashes · fires3 · 2reported in complaints
Injuries · deaths2 · 0reported in complaints
Safety recalls
Fuel system, gasoline › Storage › Tank assembly
NHTSA recall 08V157000 · Apr 8, 2008 · 68,240 vehicles · opened after NHTSA action (ODI)
Problem: VOLKSWAGEN IS RECALLING 68,240 MY 2001-2004 AUDI A6 QUATTRO VEHICLES EQUIPPED WITH 2.7L, 2.8L, OR 3.0L ENGINES AND MY 2001-2005 ALLROAD QUATTRO VEHICLES EQUIPPED WITH 2.7L OR 4.2L ENGINES. THE AGING OF THE PLASTIC MATERIAL IN THE FUEL TANK ROLLOVER VALVE COMBINED WITH BENDING STRESS FROM THE ALUMINUM VENTILATION LINE TO THE ROLLOVER VALVE NIPPLE MAY LEAD TO CRACKING OF THE NIPPLE. IF THIS HAPPENS, A FUEL LEAK MAY RESULT.
Risk: A FUEL LEAK IN THE PRESENCE OF AN IGNITION SOURCE COULD LEAD TO A VEHICLE FIRE.
Fix: DEALERS WILL REINFORCE THE NIPPLE ON THE ROLLOVER VALVE TO PREVENT LEAKAGE OR REPAIR THE CRACKING AT THE NIPPLE. THE RECALL BEGAN ON JUNE 27, 2008. OWNERS MAY CONTACT AUDI AT 1-800-822-2834.
Electrical system
NHTSA recall 06V198000 · Jun 5, 2006 · 70,512 vehicles · opened after NHTSA action (ODI)
Problem: ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH HALOGEN LOW BEAM HEADLIGHTS, CERTAIN CONNECTOR PINS IN THE HEADLIGHT SWITCH CONNECTOR COME INTO CONTACT WITH EACH OTHER CAUSING A SHORT CIRCUIT. NOTE: VEHICLES WITH XENON LOW BEAM HEADLIGHTS ARE NOT AFFECTED BECAUSE THE CIRCUIT IN THESE VEHICLES CONTAINS A FUSE, WHICH PRECLUDES EXCESSIVE CURRENT FLOW IN THE CASE OF A SHORT CIRCUIT. AUDI S6 AND S6 AVANT VEHICLES ARE ALL EQUIPPED WITH XENON LOW BEAM HEADLIGHTS AND, THEREFORE, ARE NOT LONGER AFFECTED BY THIS RECALL.
Risk: THIS CONDITION COULD LEAD TO OVERHEATING OR FIRE.
Fix: DEALERS WILL REROUTE THE WIRING HARNESS BY INSTALLING A JUMPER WIRING HARNESS. THE RECALL BEGAN ON DECEMBER 16, 2006. OWNERS MAY CONTACT AUDI AT 1-800-822-2834.
Electrical system
NHTSA recall 04V133000 · Mar 18, 2004 · 172,866 vehicles · opened after NHTSA action (ODI)
Problem: ON CERTAIN PASSENGER VEHICLES, IF A DRIVER'S KNEES PUSH AGAINST THE KNEE BOLSTER (CRASH ELEMENT) LOCATED UNDER THE DASHBOARD, IT CAN CONTACT THE HEADLIGHT SWITCH WIRING HARNESS, AND AN ELECTRICAL SHORT COULD OCCUR.
Risk: A FIRE COULD ORIGINATE IN THE LEFT DASHBOARD AREA.
Fix: DEALERS WILL INSTALL A PROTECTIVE COVERING ON THE KNEE BOLSTER (CRASH ELEMENT). IN ADDITION, THE WIRING HARNESS AS WELL AS THE FELT PROTECTOR ON THE LEFT SIDE OF THE DASHBOARD CARRIER WILL BE CHECKED, AND REPLACED IF NECESSARY. THE RECALL BEGAN ON JULY 26, 2004. OWNERS SHOULD CONTACT AUDI AT 1-800-822-2834.
Recall repairs are free at any authorised dealer. A recall listed here may already have been fixed on a particular car: enter its 17-character VIN at nhtsa.gov/recalls to see open recalls.
Crash test ratings
2004 Audi Allroad w/SAB
Overall
Not Rated
Frontal crash
Not Rated
Side crash
Not Rated
Rollover
Not Rated
NHTSA 5-Star Safety Ratings (New Car Assessment Program). Ratings are comparable only between vehicles of similar size and weight, and ratings from 2011 on use tougher tests than earlier years. Photos: NHTSA.
Fuel economy
Allroad quattro
17mpg combined
City / highway
14 / 21 mpg
Fuel
Premium Gasoline
2.7 L · 6 cyl · Manual 6-spd · 4-Wheel or All-Wheel Drive · about $4,850/year to fuel
Allroad quattro
17mpg combined
City / highway
15 / 20 mpg
Fuel
Premium Gasoline
2.7 L · 6 cyl · Automatic (S5) · 4-Wheel or All-Wheel Drive · about $4,850/year to fuel
Allroad quattro
16mpg combined
City / highway
14 / 19 mpg
Fuel
Premium Gasoline
4.2 L · 8 cyl · Automatic (S5) · 4-Wheel or All-Wheel Drive · about $5,150/year to fuel
EPA estimates from fueleconomy.gov for each engine and transmission sold. Annual cost is the EPA's estimate for 15,000 miles a year at its current fuel and electricity price assumptions. Your results will vary.
What owners report
Problem area
Complaints
Crashes
Fires
Injuries
Typical mileage*
Vehicle speed control
5
3
0
1
38,840 mi
Suspension
2
0
0
0
—
Visibility Sun/moon roof assembly
2
0
0
1
—
Tires
2
0
0
0
—
Seats Front assembly › Seat heater/cooler
2
0
2
0
—
Engine
2
2
0
0
—
Fuel/propulsion system
2
0
1
0
—
Air bags Frontal › Sensor/control module
1
0
0
0
—
Unknown or other
1
0
0
0
—
Structure
1
0
0
0
—
Electrical system
1
0
1
0
—
*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.
Recent owner complaints
Mar 14, 2016 · 195,800 milesFuel/propulsion system WHILE DRIVING MY ENGINE LIGHT CAME ON, AND I SMELLED GAS. I BROUGHT THE CAR TO A SHOP TO HAVE IT REPAIRED. THERE IS A GAS LEAK FROM ROLLOVER VALVE ON THE GAS TANK. WAS RECALLED IN 2009, REPAIRED BY THE DEALER. I HAVE JUST BOUGHT THE CAR USED AND FOUND THAT THE SAME PROBLEM IS OCCURRING AGAIN. WITH SOME RESEARCH I FOUND OUT THAT THE DEALER FIXED THE PROBLEM WITH EPOXY.
Aug 23, 2015 · 162,000 miles · fireElectrical system TL* THE CONTACT OWNS A 2004 AUDI ALLROAD. WHILE DRIVING AT AN UNKNOWN SPEED, BURNING FUMES EMITTED INTO THE VEHICLE. AFTER INSPECTING THE VEHICLE, THE CONTACT NOTICED THAT A FIRE ERUPTED NEAR THE TURN SIGNALS AND THE STEERING COLUMN AREA. THE CONTACT WAS ABLE TO EXTINGUISH THE FLAMES WITH WATER. THE VEHICLE WAS TOWED TO A REPAIR SHOP AND LATER TO A DEALER FOR INSPECTION AND DIAGNOSTIC TESTING. THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBERS: 08V157000 (FUEL SYSTEM, GASOLINE), 06V198000 (ELECTRICAL SYSTEM), AND 04V133000 (ELECTRICAL SYSTEM). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND PROVIDED NO REMEDY. THE APPROXIMATE FAILURE MILEAGE WAS 162,000.
Sep 11, 2014 · 95,000 milesVisibility › Sun/moon roof assembly WHILE DRIVING DOWN THE INTERSTATE THE MOON ROOF SPONTANEOUSLY EXPLODED! IT WAS NOT HIT BY ANYTHING, IT JUST EXPLODED. I HAVE DONE A LITTLE RESEARCH AND HAVE FOUND THAT AUDI HAS HAD A PROBLEM IN THE PAST WITH FAULTY GLASS CAUSING THEIR MOON ROOFS TO EXPLODE AND HAD TO ISSUED A RECALL FOR THIS PROBLEM. I CONTACTED AUDI AND REQUESTED THEM TO REPLACE MY MOON ROOF. THEY GAVE ME THE RUN AROUND AND THEN UNFORTUNATELY, DECIDED THAT THEY ARE UNWILLING TO ASSIST ME WITH THE REPLACEMENT OF MY OWN MOON ROOF BECAUSE IT WAS NOT ONE OF THE MODELS RECALLED AND MY CAR IS OVER 10 YEARS OLD SO IT IS OUT OF WARRANTY. THANK GOD MY CHILDREN WERE NOT IN THE CAR TO BE INJURED BY EXPLODING GLASS AND THANK GOD IT…
Aug 9, 2014 · 38,840 miles · crashEngine ON AUG. 09 2014 COMMING TO A STOP I APPLIED THE BRAKES. ALL OF A SUUDEN THE ENGINE STARTED TO ACCELERATE UNCONTROLABLE TRYING TO MOVE THE CAR FORWARD. I PRESSED THE BRAKES AS HARD AS I COULD AND I STOPED THE CAR AFTER I HIT THE CAR IN FRONT WHEN I WAS ABLE TO TURN THE IGNITION KEY OFF. THIS SUDDEN UNINTENDED ACCELERATION MALFUNCTION ALSO HAPPENED ON JAN. 29, 2006 AND JAN. 30, 2011, ALSO REPORTED TO NHTSA AT THOSE TIMES. IT IS A LIFE SAFETY ISSUE AND SHOULD BE ADDRESSED A.S.A.P. THE MANUFACTURER REFUSE TO TAKE ANY ACTION. *TR
Aug 9, 2014 · 38,840 miles · crashEngine TL* THE CONTACT OWNS A 2004 AUDI ALLROAD. THE CONTACT STATED THAT THE BRAKES FAILED INTERMITTENTLY. THE VEHICLE WAS TAKEN TO THE DEALER SEVERAL TIMES, BUT THE FAILURE COULD NOT BE DUPLICATED. WHILE DRIVING 30 MPH, THE CONTACT DEPRESSED THE BRAKE PEDAL AND THE VEHICLE DID NOT STOP. THE FAILURE CAUSED THE CONTACT TO REAR END ANOTHER VEHICLE. THERE WERE NO INJURIES AND A POLICE REPORT WAS FILED. THE VEHICLE WAS NOT REPAIRED. THE CONTACT WAS WAITING ON THE RESULTS OF THE DIAGNOSTIC TEST FROM THE DEALER. THE MANUFACTURER WAS NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 10,848. UPDATED 09/15/14*LJ THE CONSUMER STATED THE FAILURE IS UNINTENDED ACCELERATION NOT BRAKE FAILURE. MANUFACTURER REFUSED…
Nov 12, 2013 · 102,000 miles · fireSeats › Front assembly › Seat heater/cooler TL * THE CONTACT OWNS A 2004 AUDI ALLROAD. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, A FIRE ERUPTED IN THE VEHICLE DUE TO THE HEATED SEATS. THE VEHICLE WAS TAKEN TO DEALER WHERE THE REPAIRS WERE UNKNOWN. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 102,000 AND THE CURRENT MILEAGE WAS 108,000.
Apr 13, 2012Suspension THE SUSPENSION IN FRONT TIRES KEEP GOING OUT. AND WHEN I DID THE RESEARCH AS TO HOW TO FIX THIS PROBLEM ON AN AUDI IT STATED THAT THEY ARE FAMILIAR WITH THE PROBLEM AND ARE OF THIS PROBLEM BUT SEE ANY REASON AS TO WHY THEY SHOULD FIX IT. EVEN THOUGH THE PROBLEM EXISTED WHEN THE CAR REACHED A CERTAIN PART. *JS
Jan 30, 2011 · 27,745 milesUnknown or other SUDDEN UNINTENDED ACCELERATION , COMING TO A STOP SIGN, APPLYING THE BRAKES, THE ENGINE STARTED TO ACCELERATE UNCONTROLLED. I WAS ABLE TO STOP IT AFTER I PUSHED THE CAR IN FRONT. I SHIFTED IN PARK, THE ENGINE CONTINUED TO ACCELERATE AT HIGHER RATE WHEN I WAS ABLE TO TURN THE KEY OFF. *LN
Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.
NHTSA defect investigations
PE08008 · opened Jan 31, 2008 · closed May 30, 2008 · led to recall 08V156000FUEL TANK LEAK VOLKSWAGEN (VW) IS RECALLING CERTAIN VW PASSAT 4MOTION AND AUDI A6 QUATTRO AND ALLROAD QUATTRO ALL-WHEEL DRIVE PASSENGER CARS.VW VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM NOVEMBER 22, 2000 THROUGH MAY 31, 2005 AND AUDI VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM JUNE 2, 2001 TO JUNE 1, 2005.THE NHTSA RECALL NUMBER FOR THE VW VEHICLES IS 08V-156 (VW ALSO IS CORRECTING DEFECTS RELATED TO HEAT SHIELD AND FUEL LINE HAZARDS FOR THESE VEHICLES AND FOR 1999-2000 PASSATS IN THIS RECALL ACTION.)THE NHTSA RECALL NUMBER FOR THE AUDI VEHICLES IS 08V-157.SINCE 2006, ODI HAS RECEIVED 17 COMPLAINTS OF FUEL LEAKING FROM THE SUBJECT VEHICLES' FUEL TANKS.THE 400 COMPLAINTS SHOWN ABOVE MAY INCLUDE DUPLICATE REPORTS TO ODI AND THE MANUFACTURER. WHILE THE CONSEQUENCE (FUEL LEAKS FROM THE TOP OF THE TANK) IS SIMILAR FOR BOTH THE PASSAT AND AUDI SUBJECT VEHICLES, DIFFERENCES IN DESIGN AND…