The 1995 BMW 325iS has 2 safety recalls and 5 owner complaints on file with NHTSA. The most-reported problem area is engine and engine cooling (4 complaints).
Recalls2safety recalls
Complaints5filed by owners
Crashes · fires1 · 0reported in complaints
Injuries · deaths1 · 0reported in complaints
Safety recalls
Engine and engine cooling › Cooling system
NHTSA recall 98V178000 · Aug 4, 1998 · 340,000 vehicles
Problem: VEHICLE DESCRIPTION: PASSENGER VEHICLES. A MALFUNCTION OR FAILURE OF A COOLANT SYSTEM COMPONENT, SUCH AS A THERMOSTAT, WATER PUMP, OR FAN BELT, CAN RESULT IN SIGNIFICANTLY INCREASED COOLANT TEMPERATURE AND SYSTEM PRESSURE. IF THE INDICATIONS OF A CRITICAL OVERHEATING CONDITION IS NOT NOTICED BY THE DRIVER, IT IS POSSIBLE THAT DAMAGE TO, OR FAILURE OF, A COOLANT SYSTEM COMPONENT COULD OCCUR.
Risk: IF A CRACK WERE TO FORM OR A SEAM WERE TO SEPARATE IN THE HEATER CORE END PIECE, HOT COOLANT COULD SUDDENLY BE EXPELLED, INCREASING THE RISK OF PERSONAL INJURY TO A VEHICLE OCCUPANT.
Fix: DEALERS WILL INSTALL A NEW DESIGN RADIATOR CAP TO CONTROL PRESSURE AND PROVIDE GREATER COOLANT OVERFLOW IN THE EVENT OF OVERHEATING.
Vehicle speed control
NHTSA recall 97V131000 · Aug 19, 1997 · 410,000 vehicles
Problem: THE CRUISE CONTROL AND THROTTLE CABLES ARE ATTACHED TO THE SAME THROTTLE VALVE ACTUATING LEVER AT THE THROTTLE HOUSING. IT IS POSSIBLE THAT THE PLASTIC BUSHING ON EITHER CABLE COULD BREAK DUE TO ENVIRONMENTAL INFLUENCES COUPLED WITH VIBRATION. IF THE BUSHING BREAKS, THE OUTER CABLE HOUSING CAN SEPARATE FROM THE BUSHING. IN THIS CASE, DURING APPLICATION OF THE THROTTLE PEDAL WITHOUT CRUISE CONTROL BEING ENGAGED, THE OUTER TUBE COULD CATCH ON THE EDGE OF THE BROKEN BUSHING.
Risk: THIS COULD CAUSE THE THROTTLE VALVE TO REMAIN PARTIALLY OPEN. IT HIS WERE TO OCCUR, THE CAR MIGHT NOT DECELERATE AS EXPECTED INCREASING THE RISK OF A VEHICLE CRASH.
Fix: DEALERS WILL INSTALL A SPRING STEEL CLIP ON THE OUTER TUBE OF EACH CABLE IN THE AREA OF THE ADJUSTING SCREW AND PLASTIC BUSHING. THE CLIP IS DESIGNED TO PREVENT THE OUTER TUBE FROM DISLODGING FROM THE BUSHING.
Recall repairs are free at any authorised dealer. A recall listed here may already have been fixed on a particular car: enter its 17-character VIN at nhtsa.gov/recalls to see open recalls.
What owners report
Problem area
Complaints
Crashes
Fires
Injuries
Typical mileage*
Engine and engine cooling Cooling system; Cooling system › Radiator assembly
4
0
0
0
—
Air bags Frontal
1
1
0
1
—
Suspension Rear
1
0
0
0
—
Equipment
1
0
0
0
—
*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.
Recent owner complaints
May 26, 2009 · 183,313 milesEngine and engine cooling › Cooling system CARS RPM WILL NOT STAY STABLE . GO UP @DOWN WHEN IDLING. CHECK ENGINE LIGHT COMES ON GOES OUT WHEN ACCELERATING. REPLACE THERMOSTAT . RADIATOR. FAN AND FUEL PUMP PRIOR TO THIS DUE TO CAR OVER HEATING THEN CAME FAILURE OF CRACKED CYLINDER IN ENGINE. STILL NO MECHANIC CAN DIAGNOSIS EVEN WITH COMPUTER SCOPE HELP. *TR
Nov 26, 2006 · 51,818 milesSuspension › Rear DT*: THE CONTACT STATED WHILE BACKING UP OUT OF A DRIVEWAY AT 5 MPH, A NOISE WAS HEARD. THE CONTACT INSPECTED THE VEHICLE AND NOTICED THE REAR PASSENGER SIDE WHEEL SEPARATED FROM THE CONTROL ARM SUPPORT. THE BOLTS THAT ATTACHED THE WHEEL WERE FRACTURED. PRIOR TO THE INCIDENT, THERE WERE NO WARNING LIGHTS TO ALERT THE CONTACT. THE DEALERSHIP WAS CONTACTED WHO INFORMED THE CONTACT THE REPAIR MUST BE COVERED AT THE CONTACT'S EXPENSE. THE MANUFACTURER WAS ALSO CONTACTED WHO COINCIDED WITH THE DEALERSHIP. THE CONTACT EXPRESSED CONCERN BECAUSE THIS TYPE OF FAILURE AT HIGHER SPEEDS COULD RESULT IN FATAL CONSEQUENCES AND THE MANUFACTURER SHOULD BE RESPONSIBLE FOR SUCH DEFECT. THE VEHICLE REMAINED…
Jul 17, 2003Engine and engine cooling › Cooling system › Radiator assembly THE RADIATOR MALFUNCTIONED ABOUT A MONTH AGO. IT WAS FIXED BY AN INDEPENDENT MECHANIC. CONSUMER NOTICED THAT THIS HAS HAPPENED TO OTHER CONSUMERS IN THE AREA. *AK
Mar 9, 2003 · 180,000 miles · crash · 1 injuryAir bags › Frontal THE VEHICLE WAS INVOLVED IN A FRONTAL COLLISION, AND THE AIR BAGS FAILED TO DEPLOY, THE CONSUMER WAS INJURED. *JB
Mar 1, 2001Engine and engine cooling › Cooling system CONSUMER RECEIVED RECALL 98V178000/ MANUFACTURER'S RECALL # SAME/ COOLANT SYSTEM. CONSUMER TOOK VEHICLE TO FERMA BMW ON US19 IN SAFETY HARBOR, FLORIDA WHERE THEY DENIED DOING RECALL WORK. A MECHANIC LOOKED AT VEHICLE AND ENGINE HAD CRACKS FROM BEING OVERHEATED. ALSO, CONSUMER STATED THAT VEHICLE CAN'T BE MOVED TO HOME DRIVEWAY. *AK
Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.