*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.
Unknown or other
I am submitting this complaint regarding my 2018 BMW 530e, VIN [XXX], which is affected by BMW safety recall 26V-441. I received a recall notice from BMW advising that a defect involving the engine starter may result in overheating and a potential vehicle fire, even while the vehicle is parked and turned off. BMW advised owners to park their vehicles outdoors and away from structures until the recall repair is completed. The notice stated that the remedy was not yet available. I have contacted BMW seeking assistance with alternative transportation while awaiting the repair. Unfortunately, the dealershipâs loaner vehicle arrangement does not accept my insurance carrier, The General.…
Sep 14, 2026Visibility › Windshield
The contact owns a 2018 BMW 530E. The contact vehicle was left outside due to not being able to store the vehicle in the garage, and the front windshield cracked. The dealer was contacted, but no assistance was provided.
Jan 1, 2026Electrical system
The contact owns a 2018 BMW 530E. The contact stated that while driving 60 MPH, the vehicle was shaking abnormally, with electrical system failures. The âDriving Assistanceâ, TPMS, Emergency Call Service, check engine, and several other unknown warning lights were illuminated. The contact associated the failure with NHTSA Campaign Number: 26V441000 (Electrical System); however, the part to do the recall repair was not yet available. The dealer was contacted and diagnosed the vehicle with undisclosed sensor failures. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was contacted by phone and was made aware of the…
May 5, 2025 · 79,000 milesElectrical system
My 2018 BMW 530e suddenly shut down while I was driving. I charged it overnight, but the next day it showed a checkâengine light and a drivetrain failure warning. I tried driving it again, and it drove for some distance and shutdown after few minutes. Luckily, i was able to park the car on the side of the road. I brought(towed) it to a mechanic, and he told me the issue was a CCU failure, which would cost about $12,000 to fix. I believe this should be covered by the manufacturer because this isnât a normal wearâandâtear problem, and I canât absorb such a high repair cost."
Mar 2, 2026Engine and engine cooling
The contact owns a 2018 BMW 530E. The contact stated that while the vehicle was at the dealer for water pump repairs, the wrench warning light was illuminated, and the message "Passenger Seat Restraint Sensor Failure" was displayed. The contact stated that the dealer inspected the vehicle and diagnosed that the passenger's seat occupant weight sensor had failed. The vehicle was not repaired due to cost. The contact stated that the failure had persisted. The manufacturer was made aware of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 79,000.
Apr 16, 2025 · 79,000 milesAir bags
Passenger seat occupancy sensor faulty causing restraint system malfunction and seat belt warning
Nov 1, 2025Electrical system
I got a "Drivetrain malfunction" error on my 2018 530e bmw, which is a hybrid plug-in model. I sent the car to the local dealer. They did all the diagnosis and concluded the high voltage battery needed to be replaced. However, they told me that the warranty (80K/8 years) will not cover it although my card is still in the warranty period. The dealer said that the BMW North America made the decision and there was nothing they could do. Without replacing the battery, the car could fail on the highway, which could be a huge safety concern. I called BMW North America and talked to the warranty department, the guy sounded stoned/disillusioned with his job/just woke up and said thereâs nothing…
Jul 1, 2025Seat belts1 injury
The seatbelt/passenger seat fails to recognize a passenger is occupying the seat and turns off the airbag. This issue has been reported many times to BMW and on vehicle forums. This is an expensive fix ($2800) that should be issued a recall by the manufacture and not passed onto the owner of the car.
Apr 8, 2025
Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.