2012 BMW 535xi recalls & problems

Safety recalls

Recall repairs are free at any authorised dealer. A recall listed here may already have been fixed on a particular car: enter its 17-character VIN at nhtsa.gov/recalls to see open recalls.

What owners report

*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.

Recent owner complaints

• Exterior lighting

  FRONT HEADLIGHTS BUILDS UP CONDENSATION AND ALOT OF WATER. LOWERING VISIBILITY.

  Dec 2, 2015 · 49,000 miles
• Air bags › Sensor › Occupant classification › Front passenger

  MY CAR HAS 76,000 MILES ON IT AND THE ERROR POPPED UP ON THE MAIN SCREEN OF " "PASSENGER RESTRAINT SYSTEM MALFUNCTION." IT ADVISED ME TO TAKE THE CAR TO A SERVICE CENTER WHICH I DID. BMW OF WICHITA DIAGNOSED THE ISSUE AS THE PASSENGER SEAT MAT NEEDED TO BE REPLACED. THEY QUOTED ME $2,500 TO FIX THE ISSUE AND I ASKED THEM IF THIS WAS BECAUSE OF DAMAGE OR ABUSE BY THE OWNER AND THEY SAID NO IT JUST A PART THAT FAILED. I CALLED BMW OF NORTH AMERICA AND ASKED IF THEY WOULD OFFER ASSISTANCE IN THE REPAIR AND THEY SAID THERE WERE NOT ANY RECALLS OR SERVICE BULLETINS ON THE VEHICLE AND THEREFORE THEY WOULD NOT HAVE ASSISTANCE AVAILABLE. AFTER RESEARCHING THIS ISSUE ONLINE I SET THERE ARE OTHERS…

  Dec 27, 2018 · 76,000 miles
• Exterior lighting

  WATER CONDENSES INSIDE THE FRONT HEADLIGHTS IMPACTING THE PERFORMANCE OF THE LIGHTING SSYSTEM. REPORTED THIS WHEN THE CAR WAS NEW BUT WAS TOLD IT WAS NORMAL. SINCE THEN I HAVE FOUND MANY OTHERS REPORTING THE SAME PROBLEM

  Jan 1, 2019
• Seats

  THE PASSENGER SIDE SEAT HEATER SUDDENLY BEGAN TO OVERHEAT WHEN THE CAR WAS APPROXIMATELY 3 YEARS OLD. THE HEAT BECAME SO INTENSE IT WAS NECESSARY TO TURN OFF THE HEATER FOR FEAR OF BURNS. THE SEAT WAS REPLACED UNDER WARRANTY. THE PROBLEM JUST RECURRED WITH THE NEW SEAT, THREE YEARS AFTER THE FIRST SEAT WAS REPLACED; THE WARRANTY HAS EXPIRED. THIS APPEARS TO BE A PERSISTENT DESIGN OR MANUFACTURING FLAW, OCCURRING IN TWO CONSECUTIVE SEATS.

  Mar 2, 2018 · 60,000 miles
• Fuel/propulsion system

  TL* THE CONTACT OWNS A 2012 BMW 535XI. WHILE OPERATING THE VEHICLE IN STOP AND GO TRAFFIC, THE ENGINE SUDDENLY STALLED. THE VEHICLE WAS TOWED TO A DEALER WHERE IT WAS DIAGNOSED THAT THE FUEL PUMP WAS FAULTY AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 42,000.

  Oct 1, 2014 · 42,000 miles
• Wheels

  CAR WAS PURCHASED USED WITH 10,000 MI. WITHIN 1 YEAR, ABOUT 13,000 MI. BUBBLES APPEARED ON 2 GOODYEAR RUNFLAT TIRES, DUE TO POTHOLES. AFTER REPLACING 2 TIRES, I REPLACED ALL 4 WITH BRIDGESTONE RUNFLATS. NO ISSUES WITH BRIDGESTONE TIRES. GOODYEARS ARE NOT GOOD, AND SHOULD NOT BE USED ON THESE CARS.

  May 21, 2014 · 23,000 miles
• Unknown or other

  BMW HAS AN ISSUE WITH RUN FLAT TIRE ON CERTAIN MODELS AND CONTINUES TO REPLACE THESE TIRES, KNOWING THAT THERE IS A SAFETY ISSUE WITH GOODYEAR EAGLE LS2 TIRES. HAVING RECENTLY REPLACED 5 TIRES RECENTLY AND A 6TH TIRE TWO YEARS AGO THE PROBLEM CONTINUES. BMW CORPORATE CUSTOMER SERVICE CLAIMS THESE ARE THE TIRES FOR THESES MODEL CARS. OUT OF SIX TIRES BMW DID AGREE TO REPLACE TWO LAST DECEMBER. THEY NOW SAY THIS IS THE TIRE FOR THIS CAR...LUCKILY, NO ONE SUFFERED SERIOUS INJURIES WITH THESE HIGHWAY BLOWOUTS OCCURRED. NO MORE BMW"S FOR ME UNTIL THE COMPANY ADMITS THEY HAVE A "PROBLEM" THIS IS NOT A NEW PROBLEM AND A RECALL SHOULD HAVE BEEN DONE MONTHS AGO.

  Oct 16, 2015 · 35,000 miles
• Unknown or other

  CAR HAS HAD 3 BLOW OUTS OF RUN FLAT GOODYEAR LS2 TIRES ON HIGHWAY AND 3 TIRES WITH SIDEWALL BUBBLES THAT WERE UNSAFE TO DRIVE VEHICLE. 5 TIRES HAVE BEEN REPLACED IN LESS THAN 10 MONTHS AND LESS THAN 5,000 MILE ON A TIRE. THE VEHICLE HAS 35,000 MILES IN 37 MONTHS OF OWNERSHIP.

  Oct 16, 2015 · 35,719 miles

Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.