Model year record

2006 BMW 650i recalls & problems

The 2006 BMW 650i has 1 safety recall and 20 owner complaints on file with NHTSA. The most-reported problem area is service brakes (4 complaints).

Recalls1safety recalls

Complaints20filed by owners

Crashes · fires1 · 2reported in complaints

Injuries · deaths2 · 0reported in complaints

Safety recalls

Engine and engine coolingOct 12, 2007

Engine and engine cooling

Recall 07V47900029,250 vehicles

Problem: ON CERTAIN VEHICLES EQUIPPED WITH V8 ENGINES, IN CONDITIONS OF BELOW FREEZING TEMPERATURES COMBINED WITH LOW HUMIDITY, IT IS POSSIBLE FOR ELECTROSTATIC DISCHARGE TO OCCUR AT THE FUEL RAILS. IF THIS WERE TO OCCUR, THE ENGINE ELECTRONIC CONTROL UNIT (ECU) COULD BE AFFECTED SO THAT ENGINE STALLING COULD RESULT.
Risk: IF STALLING WERE TO OCCUR, THE DRIVER MAY NOT BE ABLE TO MAINTAIN VEHICLE SPEED OR ACCELERATE AND THE POWER STEERING COULD FAIL INCREASING THE RISK OF A CRASH.
Fix: DEALERS WILL ATTACH TWO GROUND CABLES IN THE ENGINE COMPARTMENT FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 29, 2007. OWNERS MAY CONTACT BMW AT 1-800-831-1117.

Recall repairs are free at any authorised dealer. A recall listed here may already have been fixed on a particular car: enter its 17-character VIN at nhtsa.gov/recalls to see open recalls.

What owners report

Problem area	Complaints	Crashes	Fires	Injuries	Typical mileage*
Service brakes	4	1	0	1	84,000 mi
Seats	4	0	1	1	65,999 mi
TiresSidewall	3	0	0	0	—
Air bags	3	0	0	0	75,998 mi
Steering	2	0	0	0	—
Seat belts	2	0	0	0	—
Service brakes, hydraulic	1	0	0	0	—
Structure	1	0	0	0	—
Engine and engine cooling	1	0	0	0	—
Electrical system	1	0	1	0	—
Unknown or other	1	0	0	0	—
Fuel/propulsion system	1	0	0	0	—

*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.

Recent owner complaints

Fuel/propulsion system
Leak from fuel pump located under passenger rear side (right rear). Gasoline pooling next to electrical connection and excess gasoline dripping into interior and exterior. Explosion risk. Gasoline fumes.
Dec 12, 2021
Unknown or other
Constant malfunctions of convertible top. Top wonât stay in locked position. Once top malfunctions windows wonât operate. This has been an ongoing problem. Has been in shop for repair of this item multiple times. Research shows many owners having same issues. Warning sign from BMW says drive slow and report to nearest BMW shop. BMW refuses to address the issueâ¦. After spending hundreds if not thousands to get this issue resolved the latest BMW shop said replace the hydraulic system at a cost of 4400.00. The 2006 650 I convertible top has a manufacturing issue in my opinion. Please investigate.
Jun 3, 2021
Steering
THE ACTIVE STEERING SYSTEM OPERATES ON AND OFF. STEERING IS NORMAL THEN THE ACTIVE STEERING SYSTEM SHUTS OFF. STEERING BECOMES VERY HEAVY. THE WARNINGS LIGHT NOW STAYS ON ALL THE TIME THIS IS UNDER ALL DRIVING CONDITIONS AND ROADS.
Oct 7, 2017 · 118,000 miles
Seats1 injury
I WAS DRIVING DOWN THE HIGHWAY WHEN I SMELLED SOMETHING FUNNY. A MINUTE LATER I FELT AN EXTREMELY HOT SENSATION ON MY LEFT LEG. I REACHED DOWN AND THE SEAT WAS SO HOT THAT IT BURNT MY HAND FROM THE BRIEF CONTACT. I PULLED OVER TO FIND THAT THE HEATED SEAT ELEMENT HAD BURNT A HOLE IN THE LEATHER SEAT AS WELL AS BURNT A HOLE IN MY WOOL COAT. IRONICALLY, THIS OCCURRED IN MY LAST BMW AS WELL, A 2004 3-SERIES, JUST TO A LESSER EXTENT. I DID NOT RECEIVE BURNS FROM THAT INCIDENT, IT JUST MELTED THE LEFT SIDE OF MY SEAT. *TR
Jan 19, 2017 · 85,000 miles
Air bags
PASSENGER SEATBELT/AIRBAG WARNING AS FOLLOWS: "PASS. RESTRAINT SYSTEM - FAULT ON PASSENGER RESTRAINT SYSTEM AFFECTING AIRBAG, BELT TENSIONER OR BELT-FORCE LIMITER. CONTINUE TO WEAR THE SAFETY BELT." NOTE: THE VEHICLE IS CURRENTLY WITH A MECHANIC WHO HAS CONFIRMED THIS IS THE "PASSENGER SEAT MAT SENSOR." I CALLED BMW OF NORTH AMERICA TODAY TO REPORT THE PROBLEM AND CHECK FOR RECALLS. I WAS INFORMED I SHOULD GO TO A BMW DEALERSHIP TO GET A "FORMAL DIAGNOSIS FROM THE DEALER" AND TO "CONFIRM IF THE ISSUE COULD'VE BEEN INCLUDED IN PRIOR RECALL." NOTE: I SEARCHED THE NHTSA WEBSITE FOR MY YEAR, MAKE AND MODEL VEHICLE AND FOUND THIS EXACT SAME ISSUE WAS UNDER "INVESTIGATION" FROM JAN. 4, 2008 TO…
Nov 24, 2016 · 75,998 miles
Air bags
TL* THE CONTACT OWNS A 2006 BMW 650I CONVERTIBLE. WHILE DRIVING 55 MPH, THE AIR BAG AND SEAT BELT WARNING LIGHTS ILLUMINATED. THE FAILURE OCCURRED CONSTANTLY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE FRONT PASSENGER SEAT OCCUPANT DETECTION MAT FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 124,000.
Sep 14, 2014 · 124,000 miles
Steering
ELV ROBLEM
Jun 1, 2016
Service brakesCrash1 injury
TL* THE CONTACT OWNED A 2006 BMW 650I. WHILE DRIVING 15 MPH AND COMING TO A STOP, THE BRAKES FAILED TO RESPOND. THE CONTACT STATED THAT THE BRAKE PEDAL WAS SOFT AND TRAVELED TO THE FLOORBOARD. THE HARDER THE BRAKE PEDAL WAS APPLIED, THE FURTHER TO THE FLOOR IT WENT WITHOUT A RESPONSE. THE CONTACT CRASHED INTO THE REAR OF ANOTHER VEHICLE. IN TURN, THE OTHER VEHICLE STRUCK THE PRECEDING VEHICLE. THE AIR BAGS DEPLOYED. A POLICE REPORT WAS FILED. THE CONTACT SUSTAINED INJURIES TO BOTH LEGS, THE LEFT HAND, AND BREASTS, WHICH REQUIRED MEDICAL ATTENTION. THE VEHICLE WAS TOWED TO THE CONTACT'S HOME. THE VEHICLE WAS DESTROYED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE…
Apr 5, 2016 · 106,000 miles

Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.

NHTSA defect investigations

BMW AIRBAG LIGHT ILLUMINATIONClosedLed to recall 08V384000
BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S…
EA08001 · opened Jan 4, 2008 · closed Dec 31, 2008