Model year record

2004 BMW 7 Series recalls & problems

The 2004 BMW 7 Series has 4 safety recalls and 28 owner complaints on file with NHTSA. The most-reported problem area is power train (4 complaints).

Recalls4safety recalls

Complaints28filed by owners

Crashes · fires0 · 1reported in complaints

Injuries · deaths2 · 0reported in complaints

Safety recalls

Service brakes, hydraulicOct 1, 2010

Power assist › Vacuum

Recall 10V446000198,352 vehicles

Problem: BMW IS RECALLING CERTAIN MODEL YEAR 2004-2010 5-SERIES, 6-SERIES, AND MODEL YEAR 2002-2008 7-SERIES VEHICLES. A CHECK VALVE OF THE BRAKE VACUUM PUMP MAY LEAK A SMALL AMOUNT OF LUBRICATING OIL. OVER TIME THIS COULD RESULT IN CONTAMINATION OF THE BRAKE BOOSTER.
Risk: POWER ASSIST BRAKING PERFORMANCE COULD BE ADVERSELY AFFECTED. IN EXTREME CASES THERE COULD BE A COMPLETE LOSS OF POWER ASSIST BRAKING. AN UNEXPECTED REDUCTION OR LOSS IN POWER BRAKING ASSIST MAY INCREASE THE RISK OF A CRASH.
Fix: BMW WILL NOTIFY OWNERS AND DEALERS WILL REPAIR THE VEHICLES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON NOVEMBER 24, 2010. OWNERS MAY CONTACT BMW AT 1-800-525-7417.

SeatsDec 6, 2004

Front assembly › Seat heater/cooler

Recall 04V57500017,905 vehicles

Problem: ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH FRONT SEAT HEATING SYSTEMS, UPON ENTERING AND EXITING THE VEHICLE, EXCESSIVE CONTACT WITH THE SIDE BOLSTER THAT IS CONTAINED IN THE SEAT'S BACKREST MAY DAMAGE THE HEATING MAT LOCATED IN THIS AREA. IF SUCH DAMAGE WERE TO OCCUR, WITH THE SYSTEM TURNED ON, THE VEHICLE OCCUPANT MAY FEEL EXCESSIVE HEAT FROM THIS AREA.
Risk: IT IS POSSIBLE THAT THE HEATING MAT IN THE BACKREST'S SIDE BOLSTER COULD OVERHEAT AND DAMAGE, OR MELT A SMALL HOLE IN, THIS AREA OF THE SEAT COVER. IF THIS HAPPENED, IT COULD LEAD TO AN OCCUPANT BEING BURNED.
Fix: DEALERS WILL MODIFY THE SEAT HEATING CIRCUIT. THE RECALL IS EXPECTED TO BEGIN DURING DECEMBER 2004. OWNERS SHOULD CONTACT BMW AT 1-800-831-1117.

SeatsAug 9, 2004

Seats

Recall 04V3790003,940 vehicles

Problem: ON CERTAIN PASSENGER VEHICLES, THE SOFTWARE PROGRAMMING OF THE DRIVER'S SEAT OCCUPANT DETECTION SYSTEM (ODS) MAY NOT BE ABLE TO RELIABLY DETERMINE IF THE DRIVER'S SEAT IS OCCUPIED.
Risk: IN CERTAIN CRASH CONDITIONS, THE DRIVER'S FRONT AIR BAG, HEAD PROTECTION SYSTEM, SAFETY BELT PRETENSIONER, AND KNEE AIR BAG MAY NOT DEPLOY, INCREASING THE RISK OF INJURY TO A SEAT OCCUPANT.
Fix: DEALERS WILL REPROGRAM THE SOFTWARE FOR THE DRIVER'S SEAT OCCUPANT DETECTION SYSTEM. THE RECALL BEGAN OCTOBER 13, 2004. OWNERS SHOULD CONTACT BMW AT 1-800-831-1117.

Power trainJul 14, 2004

Automatic transmission › Control module (tcm/pcm/tecm)

Recall 04V3440004,102 vehicles

Problem: ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH 8 AND 12 CYLINDER ENGINES, THE DIGITAL ENGINE MANAGEMENT CONTROL (EMC) UNITS WERE NOT PRODUCED ACCORDING TO SPECIFICATIONS.
Risk: AS A RESULT, ENGINE STALLING WILL OCCUR AFTER A SHORT PERIOD OF OPERATION. THE VEHICLE MAY NOT BE ABLE TO RESTART. ALSO, A LOSS OF POWER STEERING AND, AFTER REPEATED ACTUATION OF THE BRAKE PEDAL, A LOSS OF BRAKE POWER ASSIST WILL OCCUR. THESE CONDITIONS COULD RESULT IN A VEHICLE CRASH.
Fix: DEALERS WILL INSTALL A NEW DIGITAL ENGINE MANAGEMENT CONTROL UNIT. THE RECALL BEGAN ON JULY 16, 2004. OWNERS SHOULD CONTACT BMW AT 1-800-831-1117.

Recall repairs are free at any authorised dealer. A recall listed here may already have been fixed on a particular car: enter its 17-character VIN at nhtsa.gov/recalls to see open recalls.

Crash test ratings

2004 BMW 7 Series w/SAB

OverallNot Rated

Frontal crash	Not Rated
Side crash	Not Rated
Rollover	Not Rated

NHTSA 5-Star Safety Ratings (New Car Assessment Program). Ratings are comparable only between vehicles of similar size and weight, and ratings from 2011 on use tougher tests than earlier years. Photos: NHTSA.

What owners report

Problem area	Complaints	Fires	Injuries	Typical mileage*
Power trainAutomatic transmission; Automatic transmission › Control module (tcm/pcm/tecm)	4	0	0	11,693 mi
Service brakes, hydraulicPower assist › Vacuum	4	0	0	67,000 mi
Engine and engine cooling	3	0	0	—
Electrical systemHorn	3	0	0	44,827 mi
SteeringHydraulic power assist system	3	0	0	54,500 mi
Seats	3	1	2	51,200 mi
Air bagsFrontal	3	0	0	76,000 mi
Fuel system, gasolineDelivery › Fuel pump	3	0	0	64,385 mi
VisibilityPower window devices and controls	2	0	0	—
EquipmentElectrical › Navigational system(global positioning system); Electrical	2	0	0	—
Service brakes	2	0	0	—
StructureBody › Bumpers	1	0	0	—

*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.

Recent owner complaints

Air bags
I HAVE BEEN GETTING THIS ERROR IN MY IDRIVE SYSTEM: "FAULT IN PASSIVE RESTRAINT SYSTEM AFFECTING AIRBAG, BELT TENSIONER OR BELT-FORCE LIMITER. FASTEN AND CONTINUE TO WEAR BELTS. PLEASE CONTACT THE NEAREST BMW CENTER."
May 2, 2016 · 185,000 miles
Electrical system
THE REAR SIDE DOOR UNEXPECTEDLY OPEN WHILE DRIVING, A WEEK LATER THE OTHER SIDE DID THE SAME THING THE FOR OPEN THEN IT CLOSED BY ITS SELF. I WAS DRIVING STRAIGHT ON A HIGHWSY.
Sep 25, 2015 · 140,000 miles
Service brakes
I APPLIED THE BRAKES AND THEY GOT HARD AND WENT TO THE FLOOR. BRAKES WOULD BE SOFT INITIALLY AND AS PRESSURE WAS CONTINUED WOULD GET HARD AND REQUIRED SUSTAINED INTENSE EFFORT TO STOP THE VEHICLE. THIS IS A KNOWN PROBLEM BY BMW INVOLVING THE BOOSTER AND THEY CLAIM TO HAVE INSPECTED VEHICLE FOR THIS PROBLEM IN 2011 AND IT DID NOT REQUIRE BEING FIXED. THIS WAS BEFORE I BOUGHT THE VEHICLE FROM THE DEALER. THEY NOW REFUSE TO FIX THE VEHICLE. THIS IS A SAFETY ISSUE THAT OBVIOUSLY HAS NOT BEEN APPROPRIATELY ADDRESSED BY BMW. SADLY BMW PRIDES ITSELF IN GOOD BRAKES BUT REFUSES TO ADEQUATELY ADDRESS A PROBLEM THEY IDENTIFIED. IT WAS LISTED BY BMW AS A RECALL ON MY VEHICLE ON THEIR WEBSITE.…
May 1, 2013 · 114,000 miles
Service brakes
VEHICLE IS LEAKING OIL INTO THE BRAKE BOOSTER AND I HAVE TO ADD MORE PRESSURE TO THE BRAKE PEDAL TO STOP THE VEHICLE. VEHICLE HAD A RECALL CAMPAIGN NOVEMBER 2010 NO. 10V-446: BRAKE VACUUM PUMP. I TOOK THE VEHICLE TO FIELDS BMW AND THEY PROVIDED ME WITH DOCUMENTATION STATING; "11/30/2010 0034910100 CK BRAKE BOOSTER LINE N62. B34, 04, 10". I WAS TOLD THAT THERE WAS NO RECALL ON THE VEHICLE, AND I COULD PAY FOR A DIAGNOSTIC, AND THE EXPENSES FOR THE BRAKE BOOSTER TO BE REPLACED. I HAD TAKEN MY VEHICLE TO A BMW TECH FOR A FULL DIAGNOSTIC, AND HE INFORMED ME THAT THE BRAKE BOOSTER NEEDED TO BE REPLACED DUE TO THE ABOVE, AND IT'S DANGEROUS TO DRIVE THE CAR. YOUR ASSISTANCE REGARDING THIS MATTER…
Apr 13, 2013
Service brakes, hydraulic
CHECK VALVE OF THE BRAKE VACCUM PUMP LEAKING. CHIRPING SOUND DURING IDLE. SHOULD BE COVERED UNDER NHTSA CAMPAIGN ID NUMBER 10V446000. *JS
Apr 12, 2012
Fuel system, gasoline
HARD TO START, CRANKS FOR A WHILE TILL IT BUILDS UP PRESSURE THEN STARTS. IDLES ROUGH AND SOMETIMES DIES WHEN SITTING AT STOP LIGHT, AND SPUTTERING POWER AT TIME WHEN TAKING OFF, LEAKS FUEL FROM RIGHT REAR WHEEL WELL WHEN FILLING WITH FUEL. ALSO STALLS WHILE DRIVING AND TOTAL LOSS OF POWER FOR STEERING AND OTHER CONTROLS, VERY DANGEROUS WHEN IT OCCURS. I'M TOLD IT IS THE HIGH PRESSURE FUEL PUMP AND I MUST SAY THAT I CANNOT SEE HOW THIS PART CAN BE SO EXPENSIVE ($2,700) AND SURPRISED THAT BMW DID NOT RECALL THESE AND REPLACE IF THIS IN AN ENDEMIC FAULT. I WAS LUCKY THAT MY CAR FAILED 20 YARDS FROM MY HOUSE AS I RETURNED FROM A 200 MILE ROUND TRIP ON THE HIGHWAY. I DREAD TO THINK WHAT MIGHT…
Aug 7, 2011 · 64,385 miles
Fuel system, gasoline › Delivery › Fuel pump
IN REFERENCE TO BMW 760LI FUEL PUMP. RECENTLY HAD TO REPLACE MINE, AFTER CAR STALLED WHILE DRIVING ON THE THE HIGHWAY. CAR ALSO WAS HARD TO START, HAD TO CRANK ALONG TIME TO BUILD UP ENOUGH PRSSURE TO START. PROBLEM BECAME WORSE OVER TIME. *TT
Jul 5, 2011 · 82,000 miles
Air bags › Frontal
OWNER OF '04 745I AS OF 4/8/11. LAST MONTH RECEIVED NOTICE STATING "DEFAULT IN DRIVER RESTRAINT SYSTEM & AIRBAG ILLUMINATED CONSTANTLY & MESSAGE STATING AIRBAG MAY NOT OPERATE." TOOK A TRIP TO MISSOURI LAST WK & RECEIVED A NOTICE THAT THERE'S A FAULT IN PASS RESTRAINT SYSTEM, RED ILLUMINATED LIGHT, AIRBAG MAY NOT OPERATE." BMW STATED THAT THEY WOULD HAVE TO HOOK IT UP TO A MACHINE ($225) TO READ THE CODE AND THAT IT MAY BE FROM PEOPLE MOVING AROUND IN THE SEAT AND THAT AFTER RETRIEVING THE CODE, THE LABOR & PARTS COULD RANGE FROM $250-$3000. *TT
May 11, 2011 · 76,000 miles

Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.

NHTSA defect investigations

Vehicle RollawayClosedLed to recall 12V502000
In a letter dated October 16, 2012, BMW of North America, LLC (BMW) submitted a Defect Information Report (DIR), NHTSA Recall No. 12V-502 to NHTSA identifying a safety defect involving the possibility of unattended vehicle rollaway in MY 2005 through 2008 BMW 7-Series (approximately 45,000) vehicles equipped with the Comfort Access Option.The Comfort Access option allows the driver to start and stop the engine (by pressing the engine start / stop button) without inserting the key fob into the vehicles key slot in the instrument panel.Subject vehicles not equipped with the Comfort Access option require the key fob be inserted the key slot to start the engine.Upon removal of the key from the key slot the vehicle will automatically shift to Park if the driver has not done so using the gearshift lever.Sunject vehicles equipped with the Comfort Access option are designed such that when the…
EA12002 · opened Apr 10, 2012 · closed Jan 24, 2013
Vehicle RollawayClosed
In response to the Office of Defects Investigation's (ODI) Information Request (IR) for PE11-025, BMW provided ODI with 1 complaint and 46 field reports relating to either incidents of unattended vehicle rollaway or vehicle movement after the driver expected the vehicle gearshift to automatically shift to park. ODI's analysis of the data provided by BMW identified 14 crashes and 5 alleged injuries. ODI has also identified 3 additional reports in its database alleging vehicle rollaway incidents of which 2 resulted in crashes.The subject vehicles are all equipped with push-buttons (Start/Stop button) to control starting/stopping the engine and Shift-by-Wire gearshift systems controlled by a column mounted selector lever behind the steering wheel. The Start/Stop button also controls switching the ignition and the radio ready state On and Off. Shift-by-wire systems replace the traditional…
PE11025 · opened Aug 5, 2011 · closed Apr 23, 2012
BMW AIRBAG LIGHT ILLUMINATIONClosedLed to recall 08V384000
BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S…
EA08001 · opened Jan 4, 2008 · closed Dec 31, 2008