Model year record

1993 BMW 740i recalls & problems

The 1993 BMW 740i has 2 safety recalls and 15 owner complaints on file with NHTSA. The most-reported problem area is engine and engine cooling (9 complaints).

Recalls2safety recalls

Complaints15filed by owners

Crashes · fires1 · 2reported in complaints

Injuries · deaths1 · 0reported in complaints

Safety recalls

Vehicle speed controlAug 19, 1997

Vehicle speed control

Recall 97V131000410,000 vehicles

Problem: THE CRUISE CONTROL AND THROTTLE CABLES ARE ATTACHED TO THE SAME THROTTLE VALVE ACTUATING LEVER AT THE THROTTLE HOUSING. IT IS POSSIBLE THAT THE PLASTIC BUSHING ON EITHER CABLE COULD BREAK DUE TO ENVIRONMENTAL INFLUENCES COUPLED WITH VIBRATION. IF THE BUSHING BREAKS, THE OUTER CABLE HOUSING CAN SEPARATE FROM THE BUSHING. IN THIS CASE, DURING APPLICATION OF THE THROTTLE PEDAL WITHOUT CRUISE CONTROL BEING ENGAGED, THE OUTER TUBE COULD CATCH ON THE EDGE OF THE BROKEN BUSHING.
Risk: THIS COULD CAUSE THE THROTTLE VALVE TO REMAIN PARTIALLY OPEN. IT HIS WERE TO OCCUR, THE CAR MIGHT NOT DECELERATE AS EXPECTED INCREASING THE RISK OF A VEHICLE CRASH.
Fix: DEALERS WILL INSTALL A SPRING STEEL CLIP ON THE OUTER TUBE OF EACH CABLE IN THE AREA OF THE ADJUSTING SCREW AND PLASTIC BUSHING. THE CLIP IS DESIGNED TO PREVENT THE OUTER TUBE FROM DISLODGING FROM THE BUSHING.

Exterior lightingJul 1, 1996

Brake lights › Switch

Recall 96V111000180,000 vehicles

Problem: THE BRAKE LIGHT SWITCH CAN FAIL ALLOWING THE SWITCH TO REMAIN IN THE "BRAKE LIGHTS OFF" POSITION OR IN THE "BRAKE LIGHTS ON" POSITION.
Risk: IF THIS HAPPENS, THE BRAKE LIGHTS EITHER WILL NOT OPERATE OR WILL BE CONTINUOUSLY ON, REGARDLESS OF BRAKE PEDAL POSITION. FOLLOWING DRIVERS WOULD NOT BE ABLE TO DETERMINE WHETHER THE VEHICLE IS STOPPING, INCREASING THE POTENTIAL FOR A VEHICLE ACCIDENT.
Fix: DEALERS WILL REPLACE THE EXISTING BRAKE LIGHT SWITCH WITH A NEWLY DESIGNED SWITCH.

Recall repairs are free at any authorised dealer. A recall listed here may already have been fixed on a particular car: enter its 17-character VIN at nhtsa.gov/recalls to see open recalls.

Fuel economy

740i

16mpg combined

City / highway	14 / 20 mpg
Fuel	Premium Gasoline

4 L · 8 cyl · Automatic 5-spd · Rear-Wheel Drive · about $5,150/year to fuel

EPA estimates from fueleconomy.gov for each engine and transmission sold. Annual cost is the EPA's estimate for 15,000 miles a year at its current fuel and electricity price assumptions. Your results will vary.

What owners report

Problem area	Complaints	Crashes	Fires	Injuries	Typical mileage*
Engine and engine coolingCooling system › Hoses/lines/piping/fittings; Engine	9	1	1	1	—
SeatsFront assembly › Power adjust; Front assembly › Recliner	4	1	0	1	—
Unknown or other	3	0	0	0	—
Electrical systemWiring › Front underhood	2	0	1	0	—
Fuel system, gasolineCarburetor system; Storage › Tank assembly	2	0	1	0	—
Air bagsFrontal › Sensor/control module	2	0	0	0	—
Power trainAutomatic transmission	1	0	0	0	—
Service brakes, hydraulic	1	0	0	0	—

*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.

Recent owner complaints

Fuel system, gasoline › Storage › Tank assembly
TL*THE CONTACT OWNS A 1993 BMW 740I. WHILE THE VEHICLE WAS PARKED THE CONTACT NOTICED GAS LEAKING OUT OF THE GAS TANK ON THE GARAGE FLOOR. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC AND THE FUEL TANK WAS REPLACED. A DAY LATER, THE FAILURE HAPPENED AGAIN AND THE FIRE DEPARTMENT WAS CALLED AND THEY PUT A PATCH ON THE GAS TANK SO THE VEHICLE COULD BE DRIVEN TO THE LOCAL MECHANIC. A LOCAL MECHANIC AGAIN REPLACED THE FUEL TANK. THE FAILURE HAPPENED AGAIN AND THE FIRE DEPARTMENT WAS CALLED AND THEY CLEANED UP THE FUEL. THE VEHICLE WAS AGAIN TAKEN TO THE LOCAL MECHANIC AND THEY ORDERED ANOTHER FUEL TANK. THE CONTACT CALLED THE DEALER AND THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER. THE DEALER…
Jul 24, 2010 · 58,471 miles
Service brakes, hydraulic
TL*THE CONTACT OWNS A 1993 BMW 740I. WHILE DRIVING 73 MPH, THE CONTACT ATTEMPTED TO DECELERATE, BUT WAS UNSUCCESSFUL. HE HAD TO SLAM ON THE BRAKE PEDAL TO PREVENT A CRASH FROM OCCURRING. THE VIN WAS UNKNOWN. THE FAILURE AND CURRENT MILAGES WERE 120,000.
May 8, 2008 · 120,000 miles
Engine and engine cooling
THE ENGINE COMPLETELY FAILED ON MY 1994 BMW 740I. I UNDERSTAND THAT THIS MODEL YEAR HAS A KNOWN PROBLEM RELATED TO THE SULPHUR CONTENT IN AMERICA GASOLINE. PLEASE INFORM ME OR ANY RECALL OR RECOURSE I MAY BE ABLE TO TAKE REGARDING THIS MATTER. DEMETRIUS BRANDON (505) 265-1130
Feb 11, 2005
Engine and engine cooling
WHILE DRIVING VEHICLE STALLED. CONSUMER TRIED TO RESTART VEHICLE, BUT WAS UNABLE TO DO SO. THE TEMPERATURE LIGHT APPEARED ON THE DASHBOARD AND REMAINED ON. CONSUMER HAD THE VEHICLE TOWED TO THE DEALER FOR INSPECTION, AND MECHANIC INFORMED THE CONSUMER THAT THE PROBLEM COULD NOT DUPLICATED. CONSUMER TOLD THE MECHANIC THAT WIRES, AND OTHER PARTS TO THE VEHICLE HAD BEEN REPLACED, BUT THE PROBLEM STILL HAD NOT BEEN RESOLVED. AK
Jun 28, 2004
Seats › Front assembly › Recliner
DRIVER'S SEAT ON MY 1993 BMW 740I RECLINED WHILE CAR WAS IN MOTION. SEAT BACK WENT ALL THE WAY DOWN AND WILL NOT MOVE. THIS MADE ME LOSE PARTIAL CONTROL OF CAR, LUCKY I WAS ABLE TO PULL OVER WITH OUT CAUSING A SERIOUS ACCIDENT. *JB
May 5, 2003
Engine and engine cooling › Engine
VEHICLE IS A 1993 BMW 740 WHICH WAS SUBJECT TO AN ENGINE RECALL IN SEPTEMBER OF 1996 AT 67,000 MILES. IMMEDIATELY AND SINCE THAT TIME, THE CAR HAS EXPERIENCED DOCUMENTED OIL LEAKS ON THE FOLLOWING DATES: 10/1996, 12/1996, 5/1999, 6/1999, 3/2000, 6/2001, 10/2001, 1/2002, 5/2002, 7/2002, 2/2003. THERE ARE OTHER INCIDENTS OF OIL LEAKS NOT DOCUMENTED. FAIRFAX BMW, OF FAIRFAX VIRGINIA WAS THE SERVICE STATION FOR EACH OF THESE INCIDENTS. MOST OF THE TIME THE SOURCE OF THE PROBLEM COULD NOT BE DETECTED OR IT WAS A GUESS THAT THE OIL GASKET WAS FAULTY (THE OIL GASKETS WERE REPLACED AT LEAST THREE TIMES, IN WHICH THE CAR WAS IN THE SHOP MORE THAN TWO DAYS FOR EACH REPLACEMENT). FEBRUARY 2003, THE…
Oct 1, 1996 · 67,000 miles
Air bags › Frontal › Sensor/control module
THE SRS LIGHT CAME ON IN MY VEHICLE AND I TOOK THE VEHICLE INTO THE DEALER TO HAVE IT INSPECTED. THEY TOLD ME THAT THE AIRBAG MODULE WAS DEFECTIVE AND WAS IN NEED OF REPLACEMENT AT A SIGNIFICANT COST. I ASKED THEM IF THE MANUFACTURER COVERED THIS SINCE AN AIRBAG MODULE WAS NOT SOMETHING THAT HAD MOVING PARTS NOR WAS IT A PART THAT AN OWNER HAS ACCESS TO. THEY TOLD ME ONLY IF THERE WAS A RECALL ON THAT PART. THEY SAID THAT THERE WERE NO CURRENT RECALLS ON THAT PART BUT I COULD FILE A COMPLAINT WITH NHTSA.
Feb 20, 2003 · 120,000 miles
Air bags › Frontal › Sensor/control module
THE AIR BAG LIGHT ILLUMINATED DUE TO FAULTY MODULE.*JB
Feb 20, 2003

Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.