Problem: ON CERTAIN PASSENGER VEHICLES, DUE TO A SOFTWARE ERROR, A DESYNCHRONIZATION OF THE VALVETRONIC MOTORS FOR ENGINE BANKS I AND II MAY OCCUR. IF THIS OCCURS, THE ENGINE COULD STALL.
Risk: IN THOSE CASES, THE DRIVER MAY NOT BE ABLE TO RESTART THE ENGINE. DEPENDING ON THE LEVEL OF ENGINE ROUGHNESS, OR STALLING, AS WELL AS TRAFFIC CONDITIONS AND THE DRIVER'S REACTIONS, THIS COULD LEAD TO A CRASH.
Fix: DEALERS WILL REPROGRAM THE DIGITAL ENGINE MANAGEMENT CONTROL UNIT. OWNER NOTIFICATION BEGAN JULY 8, 2003. OWNERS SHOULD CONTACT BMW AT 1-800-831-1117.
Fuel system, gasoline › Delivery
NHTSA recall 02V150000 · Jun 3, 2002 · 8,412 vehicles
Problem: ON CERTAIN PASSENGER VEHICLES, THE ELECTRIC FUEL PUMP RUNS AT A ROTATIONAL SPEED THAT COULD RESULT IN REDUCED LUBRICATION OF ITS INTERNAL COMPONENTS. OVER AN EXTENDED PERIOD OF TIME, WEAR-INDUCED INTERNAL DAMAGE TO THE FUEL PUMP COULD RESULT IN INSUFFICIENT FUEL SUPPLY TO THE ENGINE WHEN THE FUEL TANK CONTAINS ONE-THIRD OR LESS OF ITS MAXIMUM FUEL CAPACITY.
Risk: IF THIS WERE TO OCCUR, THE ENGINE COULD STALL AND NOT BE RESTARTED UNTIL MORE FUEL WAS ADDED TO THE FUEL TANK. THIS COULD OCCUR EVEN THOUGH THE FUEL GAUGE INDICATED THAT FUEL STILL REMAINED IN THE TANK.
Fix: DEALERS WILL REPROGRAM THE FUEL PUMP CONTROL SYSTEM. OWNER NOTIFICATION BEGAN JUNE 28, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BMW AT 1-800-332-4269.
Recall repairs are free at any authorised dealer. A recall listed here may already have been fixed on a particular car: enter its 17-character VIN at nhtsa.gov/recalls to see open recalls.
Fuel economy
745i
19mpg combined
City / highway
16 / 24 mpg
Fuel
Premium Gasoline
4.4 L · 8 cyl · Automatic 6-spd · Rear-Wheel Drive · about $4,350/year to fuel
EPA estimates from fueleconomy.gov for each engine and transmission sold. Annual cost is the EPA's estimate for 15,000 miles a year at its current fuel and electricity price assumptions. Your results will vary.
What owners report
Problem area
Complaints
Crashes
Fires
Injuries
Typical mileage*
Power train Automatic transmission; Driveline
17
2
0
0
102,000 mi
Air bags Frontal
11
0
0
0
89,500 mi
Service brakes, hydraulic Power assist › Vacuum
10
1
0
0
92,350 mi
Electrical system Ignition
8
0
0
0
66,000 mi
Engine and engine cooling Engine › Gasoline; Exhaust system › Manifold/header/muffler/tail pipe
5
0
1
0
13,000 mi
Parking brake
3
1
0
0
60,000 mi
Seat belts
3
0
0
0
144,300 mi
Engine
3
0
0
0
—
Fuel system, gasoline
2
0
1
0
—
Seats
2
0
0
0
—
Service brakes
2
0
0
0
—
Unknown or other
1
0
1
0
—
*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.
Recent owner complaints
Nov 16, 2018Engine I BOUGHT THE CAR FROM SOMEONE IN CASH. IT HAS SMOKE COMING OUT OF THE TAIL PIPES. WHEN ITS SITTING AND IDLING FOR A WHILE IT SMOKES TERRIBLY.
Jan 7, 2014 · 90,000 milesAir bags AIR BAG LIGHT ON SEAT DRIVER WANT ADJUST PROPER
Jan 15, 2012 · 100,000 milesAir bags TL* THE CONTACT OWNS A 2002 BMW 745I. WHILE DRIVING APPROXIMATELY 55 MPH, THE AIR BAG LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO A LOCAL DEALER WHO CHECKED ALL CONNECTIONS TO THE AIR BAGS, SCANNED THE COMPUTER, AND THE LIGHT DIMMED. THE FAILURE RECURRED AFTER TWO WEEKS AND THE LIGHT REMAINED ILLUMINATED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND STATED THAT THERE WAS NO RECALL. A FOLLOW-UP APPOINTMENT WAS SCHEDULED WITH THE DEALER. THE FAILURE MILEAGE WAS APPROXIMATELY 100,000.
Jan 26, 2016Service brakes VEHICLE HAS A RECALL FOR BRAKE VACUUM PUMP 10V-446. VEHICLE WAS BROUGHT INTO A LOCAL MECHANIC AND HE SAID THE BRAKE MASTER CYLINDER WAS NOT WORKING PROPERLY. HE DID RESEARCH AND SAID THAT IT WAS A BMW RECALL. FINALLY TOOK VEHICLE INTO BMW (TUCSON) AND THE SAID THEY SAW NO OIL LEAK, THEREFORE MASTER CYLINDER WOULD NOT BE REPLACED. THEY WANT TO CHARGE $1,175 TO FIX IT. THE BRAKE VACUUM PUMP AND MASTER CYLINDER WORK TOGETHER. BMW IS NOT FIXING THE REAL PROBLEM, THEY ARE EXPECTING ME TO FIX THE FLAWED BRAKE SYSTEM. THE HEAT OF THE ENGINE CAN BURN OIL OFF, SO JUST BECAUSE THEY DIDN'T SEE IT, DOESN'T MEAN IT WASN'T THERE AND CAUSED THE FAILURE OF THE MASTER CYLINDER DIAPHRAGM. WHEN THE PART…
Jun 30, 2015 · 144,300 milesSeat belts ALL OF A SUDDEN, I GOT INTO MY 745I 2002,"FAULT IN PASSENGER RESTRAINT SYSTEM AFFECTING AIRBAG BELT TENSIONER OR BELT FORCE LIMITER. CONTINUE TO WEAR SAFETY BELT DESPITE FAULT." THIS IS AN OBVIOUS DEFECTIVE MATERIALS FROM BMW MANUFACTURING PLANT.
Mar 2, 2015 · 150,000 milesService brakes TL* THE CONTACT OWNS A 2002 BMW 745I. WHILE DRIVING AT APPROXIMATELY 35 MPH, THE BRAKE PEDAL HAD TO BE DEPRESSED WITH EXTREME FORCE IN ORDER FOR THE VEHICLE TO STOP WITHOUT WARNING. THE FAILURE RECURRED NUMEROUS TIMES. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE TECHNICIAN DIAGNOSED THAT THE BRAKE BOOSTER NEEDED TO BE REPAIRED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND STATED THAT THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 10V446000 (SERVICE BRAKES, HYDRAULIC). THE FAILURE MILEAGE WAS APPROXIMATELY 150,000.
Oct 13, 2014 · 80,000 milesPower train TL* THE CONTACT OWNS A 2002 BMW 745I. THE CONTACT STATED THAT THE VEHICLE FAILED TO SHIFT INTO DRIVE INTERMITTENTLY AND THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE FAILURE OCCURRED ON NUMEROUS OCCASIONS. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 80,000.
May 26, 2014 · 149,000 milesSeat belts STARTED MY 745I UP FOR A QUICK TRIP TO THE STORE AND RECEIVED A RESTRAINT SYSTEM FAILURE LIGHT. AFTER SOME RESEARCH IT SEEMS THAT THIS HAS BEEN A PROBLEM WITH THE 7 SERIES FOR SOME TIME AND BMW HAS EVEN ISSUED A RECALL WITH A 10 YEAR RESTRICTION. I CANNOT UNDERSTAND WHY MY 2002 IS NOT COVERED UNDER THIS RECALL SINCE BMW IS AWARE THAT THIS HAS BEEN A PROBLEM. PRESENTLY MY CAR IS UNSAFE TO DRIVE AND THE COST TO REPAIR BY DEALER IS EXTREMELY HIGH. BMW NEEDS TO OWN UP TO ALL MODELS WITH THIS PROBLEM SINCE THIS IS A SERIOUS SAFETY ISSUE. *TR
Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.
NHTSA defect investigations
EA12002 · opened Apr 10, 2012 · closed Jan 24, 2013 · led to recall 12V502000Vehicle Rollaway In a letter dated October 16, 2012, BMW of North America, LLC (BMW) submitted a Defect Information Report (DIR), NHTSA Recall No. 12V-502 to NHTSA identifying a safety defect involving the possibility of unattended vehicle rollaway in MY 2005 through 2008 BMW 7-Series (approximately 45,000) vehicles equipped with the Comfort Access Option.The Comfort Access option allows the driver to start and stop the engine (by pressing the engine start / stop button) without inserting the key fob into the vehicles key slot in the instrument panel.Subject vehicles not equipped with the Comfort Access option require the key fob be inserted the key slot to start the engine.Upon removal of the key from the key slot the vehicle will automatically shift to Park if the driver has not done so using the gearshift lever.Sunject vehicles equipped with the Comfort Access option are designed such that when the…
PE11025 · opened Aug 5, 2011 · closed Apr 23, 2012Vehicle Rollaway In response to the Office of Defects Investigation's (ODI) Information Request (IR) for PE11-025, BMW provided ODI with 1 complaint and 46 field reports relating to either incidents of unattended vehicle rollaway or vehicle movement after the driver expected the vehicle gearshift to automatically shift to park. ODI's analysis of the data provided by BMW identified 14 crashes and 5 alleged injuries. ODI has also identified 3 additional reports in its database alleging vehicle rollaway incidents of which 2 resulted in crashes.The subject vehicles are all equipped with push-buttons (Start/Stop button) to control starting/stopping the engine and Shift-by-Wire gearshift systems controlled by a column mounted selector lever behind the steering wheel. The Start/Stop button also controls switching the ignition and the radio ready state On and Off. Shift-by-wire systems replace the traditional…