Model year record
2009 BMW F 800 Gs Us recalls & problems
The 2009 BMW F 800 Gs Us has no safety recalls on file with NHTSA, and 12 owner complaints. The most-reported problem area is wheels (5 complaints).
Safety recalls
No safety recalls have been filed for the 2009 BMW F 800 Gs Us.
Recall repairs are free at any authorised dealer. A recall listed here may already have been fixed on a particular car: enter its 17-character VIN at nhtsa.gov/recalls to see open recalls.
What owners report
| Problem area | Complaints | Typical mileage* |
|---|---|---|
| Wheels | 5 | 6,000 mi |
| Suspension | 3 | 8,002 mi |
| Fuel system, gasoline | 3 | 4,620 mi |
| Engine and engine cooling | 1 | — |
*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.
Recent owner complaints
- Wheels
FAILURE OF CHAIN AND REAR WHEEL BEARING AT 7139 MILES ON A 8 MONTH OLD BMW F800GS. BIKE WAS TAKEN INTO BMW DEALER FOR NEW CHAIN AS OLD CHAIN WAS LOSING 'O' RINGS REAR WHEEL WAS REMOVED AND AT MY REQUEST BEARINGS CHECKED AS I HAD HEARD OF FAILURES ON FROM THE INTERNET. REAR BEARING WAS FOUND TO BE HIGHLY WORN AND 'GRITTY' FEELING. DEALER REPLACED BEARING UNDER WARRANTY. *TR
- Fuel system, gasoline
NOTICED A CRACK ON THE SIDE OF THE GAS TANK. THE GAS TANK IS SPLIT OPEN. THIS SEEMS TO GREATLY INCREASE THE RISK OF EXPLOSION DUE TO GAS FUMES IF ANY HEAT SOURCE/SPARK MADE GETS CLOSE. *TR
- Fuel system, gasoline
FUEL TANK ON NEW (600 MILES) BMW F800GS MOTORCYCLE HAS DEVELOPED A SIX (6") CRACK. SEPARATION IS APPROX 1/16". RETURNED MOTORCYCLE TO DEALER WHERE PURCHASED AND ISSUE HAS NOT BEEN RECTIFIED. *TR
- Fuel system, gasoline
GAS TANKS HAS CRACKS ON BOTH SIDES. *TR
- Wheels
REAR WHEEL BEARING FAILED AT 6000 MILES. THIS COULD HAVE LED TO CATASTROPHIC INJURY HAD I NOT FOUND THE PROBLEM DURING ROUTINE MAINTENANCE. CHECKING THE WHEEL BEARING IS NOT ROUTINE AT 6000 MILES. *TR
- Wheels
AFTER READING ABOUT SEVERAL FAILURES OF REAR WHEEL BEARINGS ON F800GS MOTORCYCLES I CHOSE TO INSPECT THE REAR WHEEL BEARINGS ON MY 2009 BMW F800GS MOTORCYCLE. I DISCOVERED THEM TO BE WORN AND ROUGH FEELING WITH EVIDENCE OF SERIOUS BRINNELING. THE MOTORCYCLE HAS 8800 MILES. UPON DISASSEMBLY I FOUND THE FIT BETWEEN THE WHEEL BORE AND THE BEARING ON THE DISC BRAKE SIDE TO BE TIGHTER THAN A P7 FIT FOR A HEAVY ROTATING OUTER RING WHEEL LOAD. THE FIT ON THE DRIVE SPROCKET SIDE WAS CLOSE TO A N7 FIT. I HONED THE DISC BRAKE SIDE OF THE REAR WHEEL HUB TO A N7 FIT AND REASSEMBLED WITH NEW BEARINGS. *TR
- Wheels
M / Y 2009 BMW F800GS MOTORCYCLE, BUILD DATE 10/08. REAR WHEEL BEARING FAILURE NOTED DURING ROUTINE MAINTENANCE AT APPROXIMATELY 5,500 MILES. CATASTROPHIC FAILURE COULD RESULT IN REAR TIRE LOCKING UP, CAUSING SEVERE INJURY OR DEATH. BMW DEALER IS REPLACING PARTS UNDER WARRANTY. *TR
- Suspension
I HAVE A 2009 BMW F800GS. I READ ABOUT CATASTROPHIC BEARING FAILURES HAPPENING ON OTHER F800GS REAR WHEELS AND CHECKED MY BEARING BY HAND WHEN I HAD THE REAR WHEEL OFF AT 8000 MILES FOR TIRE REPLACEMENT. THE BEARING ON THE ROTOR SIDE OF THE WHEEL WAS VERY NOTCHY AND IT WOULD NOT ROLL IN A CLOCKWISE ROTATION UNLESS MUCH FORCE WAS APPLIED. THE BEARING TYPICALLY RUNS IN A COUNTER CLOCKWISE ROTATION IF LOOKING AT THE REAR WHEEL FROM THE LEFT SIDE. THE BMW DEALER IN LAS VEGAS AGREED THAT THE BEARING WAS BAD AND REPLACED IT UNDER WARRANTY. EXPERTS HAVE EXAMINED OTHER HUBS FROM THIS SAME MODEL AND YEAR AND HAVE DECLARED THAT THE BORE IN THE HUB FOR THE BEARING IS TOO SMALL FOR WHICH CAUSES TOO…
Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.