Model year record
The 2004 BMW R 1150 R has 1 safety recall and 9 owner complaints on file with NHTSA. The most-reported problem area is fuel system, gasoline (5 complaints).
Recall repairs are free at any authorised dealer. A recall listed here may already have been fixed on a particular car: enter its 17-character VIN at nhtsa.gov/recalls to see open recalls.
| Problem area | Complaints | Typical mileage* |
|---|---|---|
| Fuel system, gasoline | 5 | 9,000 mi |
| Fuel/propulsion system | 2 | — |
| Power trainManual transmission | 1 | — |
| Service brakes, hydraulic | 1 | — |
*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.
TL* THE CONTACT OWNS A 2004 BMW R1150R. THE CONTACT STATED WHILE DRIVING 25 MPH HE BEGAN TO SMELL FUEL. THE CONTACT ALSO NOTICED THAT THE VEHICLE WAS ON FIRE NEAR THE FUEL PUMP. THE VEHICLE WAS COMPLETELY DESTROYED. THERE WERE NO INJURIES. A POLICE REPORT WAS FILED. THE MOTORCYCLE FAILURE WAS NOT DIAGNOSED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE AND CURRENT MILEAGE WAS 2,500. UPDATED 07/03/14 MA UPDATED 07/08/2014 *JS
I PURCHASED THIS BIKE LAST OCTOBER, AND UPON GETTING IT HOME SMELLED GAS, I DID GET A REPORT FROM THE DEALER WHO ORIGINALLY SOLD THE BIKE WHAT HAD BEEN DONE UNDER WARRANTY, ETC. IT WAS INDICATED THAT THE GAS TANK HAD BEEN REPLACED BECAUSE IT WAS DEFECTIVE. I TRIED 3 NEW O RINGS, A USED FUEL PUMP BASE PLATE ASSEMBLY AND WAS STILL EXPERIENCING A LIGHT WEEPING, THERE WAS ALSO INDICATIONS OF LONG TERM WEEPING THAT HAD DISCOLORED THE PAINT. I FINALLY TOOK THE TANK OFF AGAIN AND EXAMINED THE INSIDE WITH A MIRROR AND DISCOVERED 3 SMALL CRACKS ON THE BACK OF WHERE THE THREADED CERTS ARE FORMED INTO THE TANK DURING MANUFACTURER. I HAVE SINCE SCOTCH BRIGHTENED THEM AND APPLIED 3 COATS OF SEAL-ALL…
TL* THE CONTACT OWNS A 2004 BMW R1150 R. WHILE THE VEHICLE WAS AT A TRAFFIC LIGHT THE CONTACT NOTICED FUEL LEAKING FROM THE FUEL LINES QUICK DISCONNECT. THE CONTACT STOPPED THE VEHICLE IN THE EMERGENCY LANE AND INSTALLED A BRASS CLAMP IN THE FUEL LINE TO STOP THE LEAK. NHTSA RECALL CAMPAIGN ID NUMBER: 04V028000 (FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS) MAY BE RELATED TO THE FAILURE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND STATED THE VIN WAS NOT INCLUDED IN THE RECALL. THE VEHICLE WAS REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 11,000.
TL* THE CONTACT OWNS A 2006 BMW R1150(N/A). THE CONTACT TOOK THE MOTORCYCLE IN FOR SERVICE, THE DEALER INFORMED HIM THAT THE ABS UNIT WAS INOPERABLE AND NEEDED TO BE REPLACED. THE MANUFACTURER HAD NOT BEEN NOTIFIED AND THE VEHICLE HAD NOT BEEN REPAIRED. THE CURRENT AND FAILURE MILEAGES WERE 8,700. THE VIN WAS UNAVAILABLE. UPDATED 10/11/2011 *LN *TR
TL*THE CONTACT OWNS A 2004 BMW R1150 GS ADVENTURE. THE CONTACT STATED THAT THE VEHICLE WAS IN FIRST GEAR AND WHEN THE SPEED INCREASE TO 40 MPH THERE WAS A GRINDING NOISE WHEN HE SHIFTED INTO SECOND GEAR TO ACCELERATE. THE CONTACT TRIED TO SHIFT AND BACK UP, BUT THE GRINDING NOISE CONTINUED. THE CONTACT TOOK THE VEHICLE TO THE DEALER WHO STATED THE SPLINE INPUT SHAFT HAD SEVERE WEAR AND HAD TO BE REPLACED. THE CLUTCH PLATE WAS STRIPPED AS WELL. THE FAILURE AND CURRENT MILEAGES WAS 33,000.
AFTER COMING HOME FROM WORK 10 MILES AWAY, I PARKED MY CYCLE IN THE GARAGE AND IMMEDIATELY MY WIFE COULD SMELL GAS ON ME AND FUMES IN THE GARAGE. I CHECKED THE BIKE AND COULD SEE YELLOW FUEL STAINS ON THE RIGHT SIDE OF THE ENGINE. I COULD ONLY FIND THE LEAK WHEN THE KEY WAS ON AND THE FUEL PUMP FORCING FUEL THROUGH LINES BEHIND THE SHIELD. I REMOVED THE SHIELD AND FOUND ONE QUICK DISCONNECT SEPARATED. I ATTEMPTED TO CONNECT IT BUT SOON REALIZED IT WAS BROKEN. I CALLED THE DEALER WHO STATED THEY HAD A METAL REPLACEMENT TO THE ORIGINAL PLASTIC ONE THAT ALWAYS BREAKS. I ASKED HIM IF THERE WAS A RECALL AND HE STATED NO. SO I BOUGHT BOTH FITTINGS AND CLAMPS. $66. I HAVE YET TO PUT THEM ON. THEN…
TL* THE CONTACT OWNS A 2004 BMW R1150R MOTORCYCLE. WHILE DRIVING APPROXIMATELY 50 MPH, THE CONTACT BEGAN TO SMELL AN OVERPOWERING GASOLINE ODOR. THE CONTACT HAD RECENTLY REFUELED THE MOTORCYCLE. WHEN HE CAME TO A STOP, THE CONTACT NOTICED GASOLINE LEAKING FROM THE FUEL LINE AND THE QUICK DISCONNECT. HE THEN NOTICED A SLEEVE WAS FRACTURED. THE GASOLINE SPEWED ALL OVER THE CONTACT'S AND THE PASSENGER'S CLOTHING. HE THEN NOTICED A FUEL STAIN ON THE ENGINE. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING OR REPAIRS. THE APPROXIMATE FAILURE AND CURRENT MILEAGE WAS 17,020. UPDATED 9/22/10 *CN THE CONSUMER STATED THE BIKE HAS BEEN REPAIRED. UPDATED 09/24/10
I WAS STARTING AND BOARDING MY MOTORCYCLE AS NORMALLY USED. THE DAY WAS BRIGHT AND SUNNY AND ABOUT 70 DEGREES F. FUEL BEGAN TO LEAK FROM THE RIGHT SIDE JUST ABOVE THE RIGHT CYLINDER. UPON FURTHER INVESTIGATION I DISCOVERED THE QUICK DISCONNECT FUEL LINE FITTING HAD BEGUN TO LEAK GASOLINE. THE FUEL WAS COLLECTING ON THE CYLINDER HEAD AND POURING ONTO THE EXHAUST PIPING. I IMMEDIATELY SHUT DOWN THE ENGINE AND STEPPED BACK FROM THE BIKE. LUCKILY NO FIRE ENSUED BUT THE BIKE AND I WERE COVERED IN RAW GAS. I HAD A FLAT BED TOW TRUCK TRANSPORT THE BIKE TO A LOCAL BMW DEALER THE FOLLOWING DAY. REPAIRS WERE MADE AND I WAS CHARGED $102 FOR THE REPLACEMENT OF THE QUICK DISCONNECT. THE DEALER INFORMED…
Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.