Model year record
The 2004 BMW R 1150 RT has 1 safety recall and 18 owner complaints on file with NHTSA. The most-reported problem area is power train (13 complaints).
Recall repairs are free at any authorised dealer. A recall listed here may already have been fixed on a particular car: enter its 17-character VIN at nhtsa.gov/recalls to see open recalls.
| Problem area | Complaints | Typical mileage* |
|---|---|---|
| Power trainClutch assembly; Manual transmission | 13 | 33,095 mi |
| Fuel system, gasoline | 2 | — |
| Fuel/propulsion system | 2 | — |
| Tires | 1 | — |
| Service brakes | 1 | — |
*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.
TOTAL BRAKE FAILURE .I COULD NOT STOP THE MOTORCYCLE.I WENT RITE THROUGH AN INTERSECTION,THANK GOD THERE WAS NO VEHICLES DRIVING THROUGH THE INTERSECTION AT THE SAME TIME.
MY MOTORCYCLE KEPT LOSING FUEL. I NEVER LEAVE IT LOW ON GAS, BUT ON NUMEROUS OCCASIONS WENT TO RIDE IT AND THE TANK WAS EMPTY. SINCE THEN I FOUND A YOUTUBE VIDEO SHOWING HOW TO REPLACE WHAT BMW NEVER SHOULD HAVE INSTALLED, SAYING THIS IS COMMON IN CA BECAUSE BMW DID NOT USE METAL QUICK DISCONNECTS ON THE FUEL LINES; OUR GAS EATS THE PLASTIC. AT LEAST 10 GALLONS OF GAS DISAPPEARED OVER 4 MONTHS LAST SUMMER. THIS IS A MAJOR FIRE HAZARD AND I AM LUCKY TO BE ALIVE, I GUESS. IT ALSO IS NOT CHEAP TO FIX. THE PARTS ARE AROUND $100. BMW SHOULD FIX THIS, OR PAY FOR PARTS SO I CAN DO IT.
FUEL LINE QUICK DISCONNECTS ON BOTH SUPPLY AND RETURN FAILED CAUSING FUEL LEAK ON TO ENGINE AND EXHAUST. EXTREME FIRE POTENTIAL. QUICK DISCONNECT SEALS AND COMPONENTS ARE INSUFFICIENT TO HANDLE EXPOSURE TO RAW FUEL, IT IS A POOR DESIGN AND BMWNA SHOULD RECALL R1150RT'S DUE TO THIS FAILURE AND FIRE RISK. *TR
THE REAR TIRE BECAME OIL COVERED AND SLICK BECAUSE OF A FAILED OIL SEAL IN THE FINAL DRIVE. THE OIL SEAL HAD FAILED AS RESULTS OF THE FINAL DRIVE BEARING FAILURE. THESE FAILURES CAUSED AN UNSAFE CONDITION AS THERE WAS EXCESSIVE MOVEMENT IN THE REAR WHEEL AND THE REAR TIRE WAS OIL SOAKED FROM THE SEAL FAILURE. THE FAILURE GAVE LITTLE ADVANCED WARNING AS ROAD AND TIRE NOISE CHANGES AND SOUND SIMILAR. I HAVE HAD TWO FINAL DRIVE FAILURES ON THE SAME MOTORCYCLE, THE FIRST 06/04/2006 AT 33,095 MILES AT 25 MPH AND THE SECOND 07/13/2012 AT 74,341 MILES AT 65 MPH ON THE INTERSTATE SYSTEM.
TL* THE CONTACT OWNS A 2004 BMW R1150RT MOTORCYCLE. THE CONTACT STATED THAT THE FINAL DRIVE ASSEMBLY FAILED. THE FAILURE CAUSED THE REAR END TO SEVERELY KNOCK. THE CONTACT STATED THAT OIL SPILLED OUT FROM THE VEHICLE AS WELL. THE CONTACT WAS TOLD BY THE DEALER THAT THERE WAS A 3-6 MONTH BACK ORDER ON THE PART THAT WAS NEEDED TO CORRECT THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND THE CURRENT MILEAGE WAS 17,000.
FINAL DRIVE, CROWN GEAR BEARING FAILED. NO EARLY WARNING OF OIL LEAKAGE, JUST WENT SUDDENLY WHEN ON CROSS COUNTRY TRIP WHILE IN CO. FAILED CATASTROPHICALLY CAUSING THE REAR WHEEL TO WOBBLE SIGNIFICANTLY, THE OIL SEAL TO FAIL AND REAR LUBE OIL LEAKED ALL OVER REAR WHEEL. (HAVE PICTURE) SAME FAILURE AS DESCRIBED IN ODI NO. 10439549, AND CURRENTLY BEING INVESTIGATED UNDER CAMPAIGN DP12001. *KB
FAILURE OF FINAL DRIVE CROWN GEAR BEARING. THE BEARING SHATTERED CAUSING THE SEAL TO BE DAMAGED WITH OIL LOSS. *KB
MOTORCYCLE FINAL DRIVE GEAR BEARING FAILURE. GEAR OIL LEAKING FROM FINAL DRIVE. *KB
Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.