*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.
Fuel/propulsion system
The bike is a 2008 BMW R1200RT. The throttle bodies for each cylinder has a plastic cam that is the point of attachment for the throttle cable. That plastic cam broke and completely detached from the bike. I was accelerating to merge into traffic on Interstate 64E at Corydon, IN. Once established in the right lane, the bike suddenly lost power and slowed rapidly while I was approached from the rear by a tractor trailer that had to apply brakes and continuously sounded his horn while abruptly maneuvering to the left lane to avoid me while I was attempting to assess what had just happened. This is a critical safety component and its failure has been documented countless number of times on…
Apr 10, 2022Fuel/propulsion system
My forth vehicle with throttle body cams that are cracked and broken on both sides. No symptoms or warning lights of a problem that could have lead to a catastrophic failure, total engine propulsion failure, breakdown. My safety and others were in danger of injury or death. Dealer has confirmed and repaired all vehicles.
Aug 2, 2021Fuel/propulsion system
This is a two-cylinder engine with an independent throttle body for each cylinder. The throttle is actuated by a cable and pulley which rotate the throttle plate on a shaft. The pulley is attached to the shaft with molded plastic. Upon inspection during service, both plastic moldings (both cylinders) were discovered to be cracked and near failure. Failure of this part will cause that cylinder to go to idle power. If the vehicle is in motion, there will be a sudden loss of power, and high vibration until the throttle is closed. Until repair, the motorcycle will be inoperable. This has become a known defect with this series of motorcycles. I repaired mine using an aftermarket aluminum part…
Apr 23, 2019Fuel/propulsion system
THIS SERIES OF MOTORCYCLES HAS A COMMON PROBLEM WITH CRACKS IN THE THROTTLE PULLEYS ON THE THROTTLE BODY. FAILURE OF THIS PLASTIC PART WILL RESULT IN INSTANT LOSS OF POWER. I HAVE BEEN READING ABOUT THIS PROBLEM, AND DECIDED TO INSPECT THE TWO THROTTLE BODIES ON MY MOTORCYCLE AS A PRECAUTION. BOTH OF MINE WERE CRACKED. ONE OF THE PULLEYS HAS THREE CRACKS IN IT, AND WOULD LIKELY HAVE FAILED WITHIN A SHORT TIME. SEE PHOTOS INCLUDED WITH THIS REPORT.
Apr 22, 2019 · 42,000 milesService brakes
ABS PUMP MOTOR IS FAILING ON MANY OF THE SAME MODEL BIKES AND SOME OTHER 2006-2008 MODEL BMW BIKES WITH LOW MILEAGE, BECAUSE THE BRUSH HOLDERS IN THE ABS ELECTRICAL MOTOR ARE TOO TIGHT AND BRUSHES GET STUCK IN THEM - BAD DESIGN OF THE ABS PUMP MOTOR. BMW WILL ASK YOU LOADS OF MONIES FOR THE REPLACEMENT OF THE PUMP, EVEN THO THEY ARE FULLY AWARE IT'S A PROBLEM WITH MANY OF THE BIKES.
Jul 26, 2017 · 30,000 milesFuel/propulsion system
FUEL PUMP LEAKING FROM A CRACK IN THE HIGH PRESSURE OUTPUT LINE SPRAYED GASOLINE ON THE INSIDE OF THE FAIRING, MOTOR AND MY LEG. THE PUMP SPRAYS GASOLINE ANYTIME THE KEY IS IN THE ON POSITION.
Aug 8, 2017 · 12,000 milesElectrical systemFire
VEHICLE BEGAN EXHIBITING ENGINE STALLING SYMPTOMS FOR ABOUT A MONTH (ENGINE DIES WITHOUT WARNING AS IF IGNITION HAD BEEN CUT) DURING CITY DRIVING, WHILE TURNING AND PULLING INTO A PARKING SPACE AT ABOUT 5 MPH, THE VEHICLE ENGINE QUIT ALONG WITH INSTRUMENT PANEL GOING BLANK. ELECTRICAL SMOKE BEGAN TO BILLOW BETWEEN THE FRONT FORKS. THIS LASTED FOR ABOUT 10 SECONDS. AFTER GETTING THE VEHICLE HOME, I DISCOVERED THAT THE FIRE APPEARED TO HAVE ORIGINATED IN THE IGNITION WIRING HARNESS SOMEWHERE BETWEEN THE FRONT FORKS. THE HARNESS WRAP APPEARS TO HAVE FRICTION WEAR INDICATIONS EXPOSING BARE WIRING. THE FAULTY WIRE MELTED THE INSULATION ALL THE WAY FROM THE IGNITION SWITCH DOWN INTO THE MAIN…
Mar 17, 2017 · 35,000 milesService brakes
THE BRAKE FAILURE LIGHT CAME ON, BMW SHOP SAID ABS UNIT IS BAD $2000 FIX. ON MANY BMW MOTORCYCLE FORUMS THERE ARE MANY ABS UNIT FAILURES. BMW KNOWS ABOUT THESE FAILURES BUT DOES NOTHING.
Jan 9, 2017 · 22,000 miles
Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.