Model year record

2004 Cadillac CTS recalls & problems

The 2004 Cadillac CTS has 6 safety recalls and 224 owner complaints on file with NHTSA. The most-reported problem area is power train (56 complaints).

Recalls6safety recalls

Complaints224filed by owners

Crashes · fires25 · 1reported in complaints

Injuries · deaths25 · 0reported in complaints

2004 Cadillac CTS in an NHTSA crash test — NHTSA crash test

Safety recalls

Fuel system, gasolineSep 9, 2014

Delivery › Fuel pump

Recall 14V54200010,005 vehicles

Problem: General Motors LLC (GM) is recalling certain model year 2004-2007 Cadillac CTS-V vehicles manufactured October 6, 2003, to March 15, 2007, and 2006-2007 Cadillac STS-V vehicles manufactured June 23, 2005, to March 15, 2007. In the affected vehicles, the electrical terminals of the fuel pump module may overheat resulting in the melting of the flange material.
Risk: If the flange melts, a hole may be created allowing the fuel pump to leak fuel, causing the vehicle to stall, increasing the risk of a vehicle crash. Additionally, leaking fuel in the presence of an ignition source increases the risk of a fire.
Fix: GM will notify owners, and dealers will replace the fuel module and fuel tank jumper harness, free of charge. GM sent out interim notices in late October. The recall began on March 12, 2015. Owners may contact Cadillac customer service at 1-800-458-8006. GM's number for this recall is 14405.

Electrical systemJul 2, 2014

Ignition

Recall 14V394000554,328 vehicles

Problem: This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 2, 2014 that they are recalling 554,328 model year 2003-2014 Cadillac CTS vehicles manufactured August 16, 2001, to April 28, 2014, and 2004-2006 Cadillac SRX vehicles manufactured March 20, 2003, to August 11, 2006. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Risk: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Fix: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 15, 2014. Owners may contact Cadillac customer service at 1-800-458-8006. GM's number for this recall is 14172.

Service brakes, hydraulicMar 17, 2010

Foundation components › Hoses, lines/piping, and fittings

Recall 10V105000139,131 vehicles

Problem: GENERAL MOTORS HAS NOTIFIED NHTSA OF A DEFECT IN CERTAIN MODEL YEAR 2003-2007 CADILLAC CTS VEHICLES CURRENTLY REGISTERED IN OR ORIGINALLY SOLD IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WASHINGTON D.C., WEST VIRGINIA AND WISCONSIN. SOME OF THESE VEHICLES HAVE A CONDITION IN WHICH THE FRONT BRAKE HOSE FITTING AT THE CALIPER MAY CORRODE DUE TO SNOW OR WATER, CONTAINING ROAD SALT OR OTHER CONTAMINANTS, ENTERING AND BEING RETAINED IN THE ROUTING SLEEVE. IF THE FITTING CORRODES SIGNIFICANTLY, THE BRAKE HOSE-TUBE INTERFACE MAY DEVELOP A LEAK.
Risk: THE BRAKE HOSE-TUBE INTERFACE MAY RUPTURE SUDDENLY WITHOUT PRIOR WARNING AND INCREASE VEHICLE STOPPING DISTANCE MAY OCCUR INCREASING THE RISK OF A CRASH.
Fix: DEALERS ARE TO REPLACE BOTH FRONT BRAKE HOSE ASSEMBLIES FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING MAY 2010. OWNERS MAY CONTACT CADILLAC AT 1-866-982-2339 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.

Air bagsJan 20, 2005

Air bags

Recall 05V02400087,000 vehicles

Problem: ON CERTAIN PASSENGER VEHICLES, AN INTERACTION BETWEEN THE SENSING AND DIAGNOSTIC MODULE AND VEHICLE'S ELECTRICAL SYSTEM MAY CAUSE THE DRIVER'S FRONTAL AIR BAG AND/OR ROOF-MOUNTED SIDE IMPACT AIR BAG TO DEPLOY WHEN THE IGNITION KEY IS TURNED TO THE "ON" POSITION.
Risk: A PERSON POSITIONED FOR DRIVING MAY RECEIVE MINOR INJURIES, SUCH AS ABRASIONS, FROM CONTACT WITH A DEPLOYING AIR BAG.
Fix: DEALERS WILL REPLACE THE SENSING AND DIAGNOSTIC MODULE FREE OF CHARGE. THE RECALL BEGAN ON MAY 20, 2005. OWNERS MAY CONTACT CADILLAC AT 1-866-982-2339.

SteeringJun 9, 2004

Linkages

Recall 04V27300041,928 vehicles

Problem: ON CERTAIN PASSENGER VEHICLES INVOLVED IN THIS CAMPAIGN, THE LOWER CONTROL ARM BALL STUD NUT/WASHER ASSEMBLIES WITH WASHERS WERE MADE OF THE WRONG MATERIAL. THE WASHERS MAY FRACTURE AND BECOME LOOSE OR FALL AWAY FROM THE VEHICLE, REDUCING CLAMP LOAD. SEPARATION OF THE CONTROL ARM BALL STUD AND STEERING KNUCKLE, DUE TO DISENGAGEMENT OF THE TAPERED ATTACHMENT AND RETAINING NUT, IS POSSIBLE.
Risk: IF THE CONTROL ARM SEPARATES FROM THE KNUCKLE, THE AFFECTED CORNER OF THE VEHICLE WILL DROP AND THE CONTROL ARM WOULD BE FORCED DOWNWARD, CONTACTING THE WHEEL. THE AFFECTED WHEEL COULD TILT OUTWARD AND CREATE A DRAGGING ACTION THAT WOULD TEND TO SLOW THE VEHICLE AND CREATE A TENDENCY FOR THE VEHICLE TO TURN IN THE DIRECTION OF THE AFFECTED WHEEL. IN EXTREME SITUATIONS, THE AFFECTED WHEEL ASSEMBLY COULD SEPARATE FROM THE VEHICLE. SEPARATION OF THE WHEEL ASSEMBLY WOULD ALSO SEVER THAT WHEEL;S HYDRAULIC BRAKE HOSE AND RESULT IN DIMINISHED BRAKING PERFORMANCE OF THE VEHICLE, WHICH COULD RESULT IN A CRASH.
Fix: DEALERS WILL INSPECT THE BALL STUD JOINTS AND MEASURE THE TORQUE OF THE NUT FOR ALL FRONT LOWER CONTROL ARMS IN ALL MODELS AFFECTED AS WELL AS THE REAR LOWER CONTROL ARMS ON THE XLR AND CORVETTE. IF THE TORQUE IS NOT AT SPECIFICATION, THE DEALERS WILL REPLACE THE BALL STUD, THE KNUCKLE, AND THE NUT. IF THE TORQUE IS AT SPECIFICATION, THE DEALERS WILL REPLACE THE NUT/WASHER ASSEMBLY ONLY. THE RECALL WILL BEGIN ON AUGUST 25, 2004. OWNERS SHOULD CONTACT CADILLAC AT 1-866-982-2339 OR CHEVROLET AT 1-800-630-2438.

SeatsSep 29, 2003

Seats

Recall 03V3460006,771 vehicles

Problem: CERTAIN PASSENGER AND SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 207, "SEATING SYSTEMS." ONE OR BOTH FRONT ANCHOR TABS FOR THE FRONT BUCKET SEATS ARE NOT ENGAGED IN THE FLOOR PAN REINFORCEMENT SLOTS. A SEAT WITH ONLY ONE TAB ENGAGED OR NEITHER ENGAGED WOULD NOT MEET THE STATIC REARWARD LOADING TEST REQUIREMENTS OF THE STANDARD.
Risk: IN SOME CRASH CONDITIONS, THE SEAT COULD PIVOT REARWARD AND ITS OCCUPANT OR A REAR SEAT OCCUPANT COULD BE INJURED MORE SEVERELY.
Fix: DEALERS WILL ENSURE THAT BOTH FRONT ANCHOR TABS ARE FULLY SEATED IN THE FLOOR PAN REINFORCEMENT SLOTS. OWNER NOTIFICATION BEGAN SEPTEMBER 19, 2003. OWNERS SHOULD CONTACT GM AT 1-800-458-8006.

Recall repairs are free at any authorised dealer. A recall listed here may already have been fixed on a particular car: enter its 17-character VIN at nhtsa.gov/recalls to see open recalls.

Crash test ratings

2004 Cadillac CTS 4-DR. w/SAB

OverallNot Rated

Frontal crash	Not Rated
Side crash	Not Rated
Rollover	Not Rated

2004 Cadillac CTS NHTSA side crash test — NHTSA side barrier crash test

NHTSA 5-Star Safety Ratings (New Car Assessment Program). Ratings are comparable only between vehicles of similar size and weight, and ratings from 2011 on use tougher tests than earlier years. Photos: NHTSA.

Fuel economy

CTS

19mpg combined

City / highway	16 / 23 mpg
Fuel	Premium Gasoline

3.2 L · 6 cyl · Automatic 5-spd · Rear-Wheel Drive · about $4,350/year to fuel

CTS

19mpg combined

City / highway	17 / 24 mpg
Fuel	Premium Gasoline

3.2 L · 6 cyl · Manual 5-spd · Rear-Wheel Drive · about $4,350/year to fuel

CTS

19mpg combined

City / highway	16 / 25 mpg
Fuel	Regular Gasoline

3.6 L · 6 cyl · Automatic 5-spd · Rear-Wheel Drive · about $3,550/year to fuel

EPA estimates from fueleconomy.gov for each engine and transmission sold. Annual cost is the EPA's estimate for 15,000 miles a year at its current fuel and electricity price assumptions. Your results will vary.

What owners report

Problem area	Complaints	Crashes	Fires	Injuries	Typical mileage*
Power trainDriveline › Differential unit; Automatic transmission	56	3	0	3	21,827 mi
Electrical system	34	0	0	1	91,438 mi
Air bagsFrontal; Side/window	26	14	0	16	41,000 mi
Service brakes	21	1	0	0	95,500 mi
StructureBody; Body › Trunk lid	18	0	0	4	51,750 mi
Service brakes, hydraulicFoundation components › Master cylinder; Antilock/traction control/electronic limited slip	17	3	0	1	47,000 mi
SuspensionRear; Front › Control arm › Lower ball joint	16	1	0	0	17,572 mi
SteeringHydraulic power assist system; Rack and pinion › Rack	14	1	0	0	65,000 mi
Engine and engine coolingCooling system › Radiator assembly; Engine	12	0	1	0	61,971 mi
Vehicle speed controlLinkages	11	4	0	3	54,000 mi
WheelsLugs/nuts/bolts/studs	8	0	0	0	35,523 mi
Exterior lightingHeadlights › High/low beam dimmer switch; Headlights	7	0	0	0	82,324 mi

*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.

Recent owner complaints

Power train
The output shaft flange for the transmission that mounts to the driveshaft coupler the flange starts to break away and then breaks . I can provide photos but the metal on the part is close the the end and if I did not find this problem by mistake the drive shaft would have came free
Sep 11, 2024
Wheels
I am writing regarding a recent incident regarding the left front control arm of our 2004 CTS Cadillac. There was a recall for the lower control arm ball nut/washer attaching the control arm, which could lead to disengagement of the control arm, disengagement of the wheel and tire, and possible crash. We purchased the car in 2015. The Cadillac Service Center in Beverly Hills confirmed that they have records showing the car was inspected, and the recalled piece replaced in 2006. The dealer at that time was named Martin Cadillac. The night of [XXX], my son was driving the CTS on the freeway at about 50 mph, when the front left tire and wheel suddenly twisted out of place and rendered the car…
Jul 7, 2024
Wheels
Recent incident regarding the left front control arm of our 2004 CTS Cadillac. There was a recall for the lower control arm ball nut/washer attaching the control arm, which could lead to disengagement of the control arm, disengagement of the wheel and tire, and possible crash. We purchased the car in 2015. The Cadillac Service Center in Beverly Hills confirmed that they have records showing the car was inspected, and the recalled piece replaced in 2006. The dealer at that time was named Martin Cadillac. The night of [XXX], my son was driving the CTS on the freeway at about 50 mph, when the front left tire and wheel suddenly twisted out of place, impairing the steering and motion, rendering…
Jul 7, 2024
Fuel/propulsion system
fuel pump was failed replaced under recall back in 2016. Now again the fuel pump has failed again vehicle stalled. Please have GM repair it again under previous recall remedy. Please see attached photo
Jun 2, 2024
Electrical system
The contact owns a 2004 Cadillac CTS. The contact stated that after parking the vehicle, the vehicle would not restart. The contact stated that the ignition failure required her to contact roadside assistance to jump start the battery. The contact stated no warning light was illuminated. The contact stated that the failure recurred. The contact had an independent mechanic diagnose the vehicle and determined that there was an unknown electrical issue. The contact researched the failure online and related the failure to NHTSA Campaign Number: 14V394000 (Electrical System). The vehicle had not been repaired. The manufacturer had been informed of the failure. The failure mileage was…
Jan 8, 2022 · 129,000 miles
Unknown or other
VEHICLE GOES INTO THEFT MODE WHILE DRIVING, LOCKING THE DRIVER AND PASSENGERS INSIDE THE CAR. WINDOWS CANNOT BE ROLLED DOWN AND DOORS CANNOT BE UNLOCKED. CAR STOPS SHOWING SPEED, FUEL LEVEL, ETC. IN MOTION ON CITY STREETS. ALSO HAPPENS WHEN PARKED.
Mar 10, 2020 · 74,500 miles
Power train
AT ABOUT 100K I NOTICED THE AXLE SEALS ON THE REAR DIFFERENTIAL IS LEAKING. THERE ARE RECALLS ON THIS BUT NOT BASED ON MY VIN NUMBER. WHEN I NOTICED THIS THE CAR WAS ON A LIFT IN THE AIR BEING INSPECTED BY A MECHANIC.
Mar 3, 2020 · 100,000 miles
Engine
I HAVE A CTS AND I'VE GOTTEN IT SERVICE THINKING IT WAS A TUNE UP DO TO IT WAS MISFIRING. COME TO FIND OUT THAT IT WAS MY CYLINDERS GOTTEN THEN FIXED AND IT HAS DONE THE SAME. DID RESEARCH ON CTS AND COME TO FIND OUT THAT IS A MAJOR ISSUE FOR THESE CARS. WHAT KIND OF SOLUTION CAN BE MADE TO STOP THESE ISSUES
Dec 18, 2019

Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.

NHTSA defect investigations

REAR DRIVETRAIN COMPONENT FAILUREClosed
IN JULY OF 2007 THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED PE07-037 TO INVESTIGATE ALLEGATIONS THAT THE REAR DIFFERENTIAL MAY FAIL CAUSING A LOSS OF MOTIVE POWER, AND IN SOME INSTANCES A LOSS OF CONTROL, IN MODEL YEAR (MY) 2004 THROUGH 2006 CADILLAC CTS, CTS-V, AND STS VEHICLES.AS A RESULT OF THAT INVESTIGATION GM ISSUED RECALL 07V-589 TO CORRECT A LEAKING PINION SEAL PROBLEM.EA07-017 WAS OPENED TO INVESTIGATE COMPLAINTS OF FRACTURED REAR DIFFERENTIAL HOUSINGS OR REAR HALF SHAFTS IN HIGH PERFORMANCE CADILLAC CTS-V VEHICLES.ACCORDING TO GM, THESE FAILURES RESULTED FROM THE CUMULATIVE DAMAGE FROM MULTIPLE POWER HOP EVENTS THAT CAN OCCUR DURING VERY AGGRESSIVE DRIVING. IN FEBRUARY 2008 INVESTIGATORS FROM ODI MET WITH GM REPRESENTATIVES TO CONDUCT TESTING OF THE SUBJECT CTS-V VEHICLES.DURING THE TESTING THE SUBJECT VEHICLES WERE SUBJECTED TO CONSIDERABLE TORSIONAL FORCES FROM STANDING…
EA07017 · opened Dec 7, 2007 · closed Jul 16, 2008
FAILURE OF THE REAR DIFFERENTIALClosedLed to recall 07V589000
ODI EVALUATED TWO DIFFERENT ALLEGED DEFECTS INVOLVING REAR DRIVETRAIN COMPONENTS DURING THIS PRELIMINARY EVALUATION.GM IS CONDUCTING A RECALL TO ADDRESS ONE OF THE DEFECT CONDITIONS AND ODI HAS OPENED AN ENGINEERING ANALYSIS TO CONTINUE ITS INVESTIGATION OF THE OTHER ALLEGED DEFECT. ON DECEMBER 19, 2007, GM SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA CONCERNING DEFECTIVE REAR AXLE PINION SEALS IN APPROXIMATELY 275,936 MODEL YEAR (MY) 2005-07 CADILLAC CTS, STS AND SRX VEHICLES AS WELL AS MY 2006-07 PONTIAC SOLSTICE AND MY 2007 SATURN SKY VEHICLES (RECALL 07V-589).ON STS AND SRX VEHICLES WITH ALL WHEEL DRIVE, THE FRONT AXLE PINION SEAL ALSO DOES NOT MEET ALL OF GM'S SPECIFICATIONS AND MAY EXPERIENCE A FLUID LEAK.GM INDICATED THAT THE SEAL SUPPLIER MADE AN UNAUTHORIZED CHANGE TO THE PINION SEAL MATERIAL.LEAKING PINION SEALS COULD RESULT IN LOSS OF REAR DIFFERENTIAL LUBRICATION WHICH…
PE07037 · opened Jul 17, 2007 · closed Dec 27, 2007