Model year record

1996 Cadillac Deville recalls & problems

The 1996 Cadillac Deville has 2 safety recalls and 218 owner complaints on file with NHTSA. The most-reported problem area is steering (45 complaints).

Recalls2safety recalls

Complaints218filed by owners

Crashes · fires11 · 7reported in complaints

Injuries · deaths12 · 0reported in complaints

Safety recalls

Fuel system, gasolineMar 4, 2004

Delivery › Hoses, lines/piping, and fittings

Recall 04V110000483,477 vehiclesopened after NHTSA action (ODI)

Problem: SOME PASSENGER VEHICLES EQUIPPED WITH 4.0L V8 ENGINES HAVE A CONDITION IN WHICH THE NYLON TUBING USED IN THE FUEL RAIL CONSTRUCTION MAY DEGRADE AND CRACK. ADDITIONALLY, THE 1995 MODEL YEAR USES A UNIQUE UNDERHOOD FUEL RETURN LINE THAT MAY CRACK. CRACKING OF THE FUEL RAIL OR RETURN LINE TUBING CAN RESULT IN A FUEL LEAK INTO THE ENGINE COMPARTMENT.
Risk: FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Fix: DEALERS WILL INSPECT AND, IF NECESSARY, REPLACE THE ENGINE FUEL RAIL WITH A NEW STAINLESS STEEL FUEL RAIL. DEALERS WILL ALSO INSTALL A REVISED CHASSIS FUEL RETURN LINE. THE RECALL BEGAN ON JUNE 2, 2004, FOR 1996-1997 OLDSMOBILE AURORA VEHICLES. OWNERS OF 1995 CADILLACS AND 1996-1997 OLDSMOBILE AURORA WERE SENT LETTERS ON AUGUST 6, 2004. ADDITIONAL LETTERS TO OWNERS WILL BE FORTHCOMING. OWNERS SHOULD CONTACT OLDSMOBILE AT 1-800-630-6537.

StructureDec 5, 1995

Body › Hood › Hinge and attachments

Recall 95V22900012,783 vehicles

Problem: THESE VEHICLES COULD HAVE BEEN PRODUCED WITH AN IMPROPERLY ADJUSTED SECONDARY HOOD LATCH. THIS DOES NOT CONFORM TO THE REQUIREMENTS OF FMVSS NO. 113, "HOOD LATCH SYSTEM."
Risk: CONSEQUENCE OF NON-COMPLIANCE: IF THE SECONDARY LATCH IS NOT PROPERLY ENGAGED AND THE PRIMARY HOOD LATCH WAS ALSO NOT ENGAGED, THE HOOD LATCH WAS ALSO NOT ENGAGED, THE HOOD COULD OPEN UNEXPECTEDLY. IF THIS WERE TO OCCUR WHILE THE VEHICLE IS IN MOTION, THE HOOD CAN CONTACT THE WINDSHIELD REDUCING THE VISION OF THE DRIVER AND INCREASING THE RISK OF A VEHICLE ACCIDENT.
Fix: DEALERS WILL ADJUST THE SECONDARY HOOD LATCH.

Recall repairs are free at any authorised dealer. A recall listed here may already have been fixed on a particular car: enter its 17-character VIN at nhtsa.gov/recalls to see open recalls.

Crash test ratings

1996 Cadillac Deville 4-DR.

OverallNot Rated

Frontal crash	Not Rated
Side crash	Not Rated
Rollover	Not Rated

NHTSA 5-Star Safety Ratings (New Car Assessment Program). Ratings are comparable only between vehicles of similar size and weight, and ratings from 2011 on use tougher tests than earlier years. Photos: NHTSA.

Fuel economy

DeVille

18mpg combined

City / highway	15 / 24 mpg
Fuel	Premium Gasoline

4.6 L · 8 cyl · Automatic 4-spd · Front-Wheel Drive · about $4,550/year to fuel

EPA estimates from fueleconomy.gov for each engine and transmission sold. Annual cost is the EPA's estimate for 15,000 miles a year at its current fuel and electricity price assumptions. Your results will vary.

What owners report

Problem area	Complaints	Crashes	Fires	Injuries	Typical mileage*
SteeringHydraulic power assist system; Hydraulic power assist › Pump	45	0	1	0	100,000 mi
Engine and engine coolingEngine › Gasoline; Engine	44	0	3	0	75,000 mi
Fuel system, gasolineFuel injection system › Fuel rail; Delivery › Hoses, lines/piping, and fittings	34	0	2	0	77,000 mi
Service brakes, hydraulicAntilock/traction control/electronic limited slip; Foundation components	22	1	1	0	—
Vehicle speed controlAccelerator pedal; Cruise control	21	0	0	0	70,100 mi
Electrical systemHorn; Wiring	18	0	3	0	89,000 mi
Air bagsFrontal	14	9	0	10	—
Exterior lightingTurn signal; Turn signal › Flasher unit	13	0	0	0	—
Power trainAutomatic transmission; Automatic transmission › Park/neutral start interlock switch	12	1	0	1	—
SuspensionFront; Rear	11	0	0	0	—
SeatsFront assembly › Recliner; Front assembly › Power adjust	7	3	0	5	—
EquipmentElectrical › Radio/tape deck/cd etc.; Appliance › Air conditioner	7	0	0	0	—

*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.

Recent owner complaints

Fuel/propulsion system
ONE DAY I COULD SMELL GAS FAIRLY STRONG, AND THEN I STOPPED AT A FRIENDS SHOP, OPENED THE HOOD AND YOU COULD SEE GAS SPURTING OUT. AS I WAS LOOKING UP THIS PART AND THEN SPOKE WITH SOMEONE THAT INFORMED ME THAT YES THERE HAD BEEN A RECALL ON THE FUEL RAIL AND THAT IT WAS CLOSED. OF COURSE I HAD TO PARK IT TO KEEP IT FROM CATCHING ON FIRE.. IT'S A 1996 CADILLAC DEVILLE AND IT'S IN MINT CONDITION. I AM ASKING FOR SOME HELP IN GETTING THIS REPAIRED/REPLACED.
Dec 26, 2018 · 250,000 miles
Fuel/propulsion system
TL* THE CONTACT OWNS A 1996 CADILLAC DEVILLE. WHILE PLACING FUEL IN THE VEHICLE, THE CONTACT OBSERVED FUEL LEAKING FROM UNDERNEATH THE VEHICLE BY THE FUEL TANK. THE VEHICLE WAS SERVICED PER NHTSA CAMPAIGN NUMBER: 04V110000 (FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS), BUT THE REMEDY FAILED TO REPAIR THE VEHICLE. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 160,000.
Dec 3, 2016 · 160,000 miles
Seat belts
TL* THE CONTACT OWNS A 1996 CADILLAC DEVILLE. THE CONTACT STATED THAT THE FRONT DRIVER AND REAR SEAT BELTS FAILED TO LOCK. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 106,000.
Aug 15, 2014 · 106,000 miles
Seat belts
MY SEAT BELT ON THE DRIVER SIDE WILL NOT LATCH. THE TONGUE WILL NOT INSERT INTO THE BUCKLE. I REPORTED THE PROBLEM TO GM/ CADILLAC AND WAS TOLD TO VISIT THE LOCAL DEALER. THE REPRESENTATIVE OF THE DEALER IN ZANESVILLE, OHIO TOLD ME THE SEAT BELT BUCKLE WAS NO LONGER AVAILABLE. SINCE I NEVER USE THE MIDDLE BACK SEAT AND IT HAS THE IDENTICAL BUCKLE, MY SUGGESTION WAS TO REMOVE THE SEAT BELT FOR THE MIDDLE BACK SEAT AND USE THE BUCKLE FOR MY DRIVER'S SEAT. I WAS TOLD FOR LEGAL REASON THEY COULD NOT DO THIS. SO IT IS OK FOR ME THE DRIVER NOT TO HAVE A SEAT BELT WHEN THE PART IS NOT AVAILABLE THROUGH GM BUT IS AVAILABLE IN MY MIDDLE BACK SEAT WHICH IS NEVER USED. I NOTICED THE 91 CADILLAC…
Jun 29, 2015 · 189,102 miles
Engine
TL* THE CONTACT OWNS A 1996 CADILLAC DEVILLE. THE CONTACT STATED THAT THE VEHICLE BEGAN TO RUN HOT AS SOON AS THE ENGINE WAS STARTED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSIS WHERE HE WAS INFORMED THAT THE ENGINE BLOCK WAS CRACKED. THE MANUFACTURER WAS NOTIFIED AND STATED THAT THEY WOULD REPAIR THE VEHICLE AT THEIR COST AND ADVISED THE CONTACT TO TAKE THE VEHICLE TO A LOCAL DEALER. THE DEALER STATED TO THE CONTACT THAT THE MANUFACTURER ADVISED THEM NOT TO MAKE ANY REPAIRS TO THE VEHICLE. A LETTER WAS WRITTEN TO THE CHIEF EXECUTIVE OFFICER WHO RESPONDED THAT THEY WOULD NOT ASSIST IN THE REPAIR OF THE VEHICLE. THE FAILURE AND CURRENT MILEAGE WAS 74,000.
Mar 1, 2012 · 74,000 miles
Engine and engine cooling
MY FATHER PURCHASED A 1996 SEDAN DEVILLE BRAND NEW. HE PASSED AWAY IN APRIL 1998. MY MOTHER DROVE THE CAR UNTIL THIS YEAR. SHE GAVE ME THE CAR. THE CAR HAS APPROX 17,000 MILES. I JUST FOUND OUT THE CAR HAS A BLOWN REAR HEAD GASKET. I REALIZE THE CAR IS 15 YRS OLD BUT I FEEL THIS SHOULD NOT HAVE HAPPENED WITH SUCH LOW MILEAGE. THE CAR WAS NEVER ABUSED AND STILL SMELLS NEW INSIDE. DO I HAVE ANY RECOURSE WITH GM? *TR
Mar 14, 2011 · 17,000 miles
Fuel system, gasoline › Delivery › Hoses, lines/piping, and fittings
TL* THE CONTACT OWNS A 1996 CADILLAC DEVILLE. THE CONTACT STATED THAT THE VEHICLE WAS REPAIRED UNDER NHTSA CAMPAIGN ID NUMBER: 04V110000 (FUEL SYSTEM, GASOLINE: DELIVERY: HOSES, LINES/PIPING, AND FITTINGS) YET THE CONTACT CONTINUED TO EXPERIENCE FAILURES WITH THE VEHICLE AFTER REPAIRS. THE VEHICLE WAS TAKEN TO A LOCAL REPAIR FACILITY WHERE A DIAGNOSTIC WAS PERFORMED AND THE MECHANIC ADVISED THE CONTACT THAT THE PLASTIC TUBING CONNECTED TO THE STAINLESS STEEL FUEL RAIL FAILED, CAUSING FUEL TO SPRAY INTO THE ENGINE. THE MANUFACTURER ADVISED THE CONTACT THAT THE TUBING WAS NO LONGER MANUFACTURED THEREFORE THEY COULD NOT AUTHORIZE THE REPAIR. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND…
Oct 15, 2010 · 154,000 miles
Visibility › Defroster/defogger/hvac system › Heater core1 injury
TL*THE CONTACT OWNS 1996 CADILLAC DEVILLE. THE CONTACT STATED THAT THE ANTI FREEZE CAME OVER THE FIREWALL AND CAUSED SECOND DEGREE BURNS TO HIS FEET. THE CONTACT WAS TRAVELING 55 MPH WHEN THIS OCCURRED. THE MECHANIC STATED THAT THE HEATER CORE FAILED ON THE VEHICLE AND ALLOWED THE ANTI FREEZE TO LEAK INTO THE VEHICLE. THE VIN WAS NOT AVAILABLE AT THE TIME OF THE COMPLAINT. THE FAILURE MILEAGE WAS 160000 AND THE CURRENT MILEAGE WAS 167000.
Aug 3, 2010 · 160,000 miles

Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.

NHTSA defect investigations

FUEL RAIL LEAKSClosedLed to recall 04V110000
ON MARCH 3, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS RECALLING APPROXIMATELY 94,000 MY 1995-97 OLDSMOBILE AURORA VEHICLES EQUIPPED WITH 4.0L V8 ENGINES (RPO L47 - VIN8 C) TO ADDRESS CONCERNS WITH UNDERHOOD FUEL LEAKAGE FROM CRACKED FUEL RAILS AND, IN SOME OF THE VEHICLES, CRACKED FUEL RETURN LINES. ACCORDING TO GM, THE NYLON TUBING (PA12) USED IN THE FUEL RAIL CONSTRUCTION IN THESE VEHICLES MAY DEGRADE AND CRACK.GM'S SUPPLIER ATTRIBUTED THE CRACKING TO THE COMBINED EFFECTS OF HEAT, TIME, ALCOHOL FUEL, FUEL PRESSURE CYCLING, AND DESIGN STRESSES.IN ADDITION, GM STATED THAT THE MY 1995 AURORA USES A UNIQUE UNDERHOOD FUEL RETURN LINE THAT MAY ALSO CRACK AT UNUSUALLY HIGH RATES.GM DEALERS WILL INSTALL A NEW FUEL RAIL CONSTRUCTED OUT OF STAINLESS STEEL IN ALL OF THE RECALLED VEHICLES AND WILL ALSO INSTALL A REVISED CHASSIS FUEL RETURN LINE IN THE MY 1995 AURORAS. ON APRIL 16, 2004,…
EA04003 · opened Feb 3, 2004 · closed Apr 23, 2004
FUEL RAIL LEAKAGEClosed
THE FUEL RAIL ASSEMBLIES USED IN THE SUBJECT VEHICLES WERE MANUFACTURED BY DANA.THE FUEL RAIL JUMPER TUBES WERE MADE OF MONOLAYER NYLON 12 (PA12).IN MODEL YEAR (MY) 1998, THE JUMPER TUBE MATERIAL WAS CHANGED FROM PA12 TO M-BOND (A MULTI-LAYER PTFE/PA12).IN ADDITION, ALL SERVICE PARTS PRODUCED SINCE THE END OF PRODUCTION 1997 USE THE M-BOND JUMPER TUBES. MATERIAL ANALYSIS PERFORMED BY DANA ON FAILED FUEL RAILS SHOWED THAT THE MONO-LAYER NYLON 12 JUMPER TUBES ARE SUSCEPTIBLE TO ENVIRONMENTAL STRESS CRACKING (ESC).GM BELIEVES THE ESC IS A RESULT OF HEAT, TIME, ALCOHOL BLENDED FUEL, FUEL PRESSURE CYCLING, AND DESIGNED IN STRESS. EIGHT OF THE GM COMPLAINTS ARE DUPLICATIVE OF ODI COMPLAINTS.ODI HAS RECEIVED 77 OF IT'S 123 COMPLAINTS IN THE PAST 12 MONTHS.FUEL RAIL PART SALES OVER THE LAST THREE YEARS RANGE FROM 3.0 PERCENT OF PRODUCTION FOR THE MY 1997 CADILLAC VEHICLES TO 13.1 PERCENT FOR…
PE03050 · opened Oct 30, 2003 · closed Feb 3, 2004
POWER RACK AND PINION STEERING FAILUREClosed
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED…
RQ03001 · opened Jan 2, 2003 · closed Sep 15, 2003
INADVERTENT AIR BAG DEPLOYMENTClosedLed to recall 98V115000
There is no summary currently available
EA98004 · opened Feb 24, 1998 · closed Jun 16, 1998
ERRATIC TURN SIGNAL OPERATIONClosed
PE98005 · opened Feb 6, 1998 · closed Aug 27, 1998