Model year record

1996 Chevrolet Lumina APV recalls & problems

The 1996 Chevrolet Lumina APV has 2 safety recalls and 35 owner complaints on file with NHTSA. The most-reported problem area is visibility (10 complaints).

Recalls2safety recalls

Complaints35filed by owners

Crashes · fires2 · 4reported in complaints

Injuries · deaths1 · 0reported in complaints

Safety recalls

Fuel system, otherMar 12, 2007

Storage › Tank assembly › Pressure relief devices

Recall 07E021000742 vehicles

Problem: CERTAIN DELPHI FUEL PRESSURE REGULATORS, P/NOS. FP10020-11B1, FP10026-11B1, AND FP10027-11B1, SOLD AFTER JANUARY 9, 2007, AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES LISTED ABOVE. THE UNIVERSAL PRESSURE REGULATORS (UPR) WERE PRODUCED WITHOUT AN O'RING AND RETAINER.
Risk: FUEL MAY LEAK, POSSIBLY RESULTING IN A FIRE.
Fix: DELPHI WILL NOTIFY OWNERS AND REPLACE THE UPR FREE OF CHARGE. THE RECALL BEGAN ON APRIL 23, 2007. OWNERS CAN CONTACT DELPHI AT 877-411-8770.

SteeringNov 4, 2002

Rack and pinion

Recall 02V2860001,159,156 vehiclesopened after NHTSA action (ODI)

Problem: CERTAIN PASSENGER VEHICLES AND MINI VANS HAVE LOWER PINION BEARINGS IN THE POWER RACK AND PINION ASSEMBLY IN WHICH THE RETAINER TABS WERE NOT CRIMPED PROPERLY. THESE AND SOME OTHER RETAINERS USED IN VEHICLES ASSEMBLED BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997, COULD FAIL AND PERMIT THE BALL BEARINGS TO ESCAPE.
Risk: IF THIS OCCURS, THE PINION SHAFT CAN BE FORCED UPWARD DURING LEFT TURNS AND BACK DOWN AS THE STEERING WHEEL IS MOVED BACK AND TO THE RIGHT. IF THE PINION SHAFT MOVES FURTHER, THE DRIVER WILL NEED TO EXERT MORE EFFORT TO TURN THE STEERING WHEEL, SIMILAR TO A VEHICLE WITHOUT POWER ASSISTED STEERING. IF THE PINION SHAFT MOVES EVEN FURTHER, THE DRIVER WILL REQUIRE MUCH HIGHER EFFORT TO TURN LEFT AND MAY NOT BE ABLE TO TURN THE WHEEL AS MUCH AS INTENDED. WITH THE MAXIMUM PINION SHAFT MOVEMENT, WHICH REQUIRES INTERNAL GEAR COMPONENT DAMAGE, THE DRIVER CAN ENCOUNTER HIGH RESISTANCE TO TURNING LEFT, FOLLOWED BY UNINTENDED POWER ASSIST TO THE RIGHT. IN ANY OF THESE CONDITIONS, A CRASH COULD OCCUR.
Fix: DEALERS WILL INSTALL A NEW LOWER PINION BEARING UNLESS INSPECT OF THE EXISTING BEARING INDICATES THAT REPLACEMENT OF THE GEAR ASSEMBLY IS NECESSARY. OWNER NOTIFICATION BEGAN JANUARY 24, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, OR OLDSMOBILE AT 1-800-442-6537.

Recall repairs are free at any authorised dealer. A recall listed here may already have been fixed on a particular car: enter its 17-character VIN at nhtsa.gov/recalls to see open recalls.

Crash test ratings

1996 Chevrolet Lumina/APV

OverallNot Rated

Frontal crash	Not Rated
Side crash	Not Rated
Rollover	Not Rated

NHTSA 5-Star Safety Ratings (New Car Assessment Program). Ratings are comparable only between vehicles of similar size and weight, and ratings from 2011 on use tougher tests than earlier years. Photos: NHTSA.

What owners report

Problem area	Complaints	Crashes	Fires	Injuries	Typical mileage*
VisibilityWindshield wiper/washer › Motor; Windshield wiper/washer	10	0	0	0	86,303 mi
Electrical systemIgnition; Wiring	5	0	2	0	—
SeatsFront assembly › Head restraint; Front assembly › Recliner	4	1	0	1	—
Engine and engine coolingEngine; Exhaust system › Emission control › Catalytic convertor	4	0	1	0	—
StructureBody › Door	3	0	0	0	—
Service brakes, hydraulicAntilock/traction control/electronic limited slip; Foundation components › Hoses, lines/piping, and fittings	3	0	0	0	—
EquipmentAppliance › Air conditioner	2	0	0	0	—
SteeringHydraulic power assist system; Rack and pinion	2	1	0	0	—
Power trainAutomatic transmission	1	0	0	0	—
SuspensionFront	1	0	0	0	—
Fuel system, gasolineFuel injection system	1	0	0	0	—
Vehicle speed control	1	0	0	0	—

*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.

Recent owner complaints

Latches/locks/linkages › Doors › LatchFire
I SMELLED SMOKE IN MY VEHICLE, SO I PULLED OVER. IT SEEMED TO BE COMING FROM THE VENT. MY FRIEND THOUGHT IT WAS ELECTICAL, SO HE STARTED PULLING FUSES TO STOP THE PROBLEM. I DISCERNED THAT THE PROBLEM WAS THE MOTOR THAT OPENED AND CLOSED THE AUTOMATIC DOOR OPENER ON THE VAN. I TOLD MY FRIEND TO JUST GET OUT AND I CALLED THE FIRE DEPARTMENT IMMEDIATELY, BUT BY THE TIME THEY HAD ARRIVED MY CAR WAS FULLY ENGULFED IN FLAMES. I AM THANKFUL THAT I DID NOT HAVE MY CHILDREN WITH ME AT THE TIME AS I DON'T KNOW IF I COULD HAVE GOTTEN THEM OUT IN TIME. MY THREE YEAR OLD WOULD HAVE BEEN IN THE BUILT-IN CAR SEAT WHICH IS NEXT TO THE DOOR. THE FIRE HAPPENED SO FAST. I MIGHT ADD I HAVE NEVER HAD ANY…
Apr 7, 2007 · 218,000 miles
Visibility › Windshield wiper/washer › Motor
WINDSHIELD WIPER MOTOR FAILURE. WINDSHIELD WIPERS WORK INTERMITTENTLY AND SOMETIMES NOT AT ALL ! *AK
Oct 14, 2004 · 126,200 miles
Electrical systemFire
LOUD TAPPING SOUND FROM ENGINE WHEN FIRST STARTED.*AK
Feb 1, 2005
Visibility › Windshield wiper/washer › Motor
THE WINDSHIELD WIPERS FAILEED INTERMITTENTLY. DEALER STATED PROBLEM COULD NOT DUPLICATED. *AK
Nov 15, 2004 · 84,286 miles
Steering › Rack and pinion
EXPERIENCED INTERMITTENT OF POWER STEERING, LOST STEERING CONTROL OF THE VEHICLE. REPLACED RACK AND PINION. *BF THE VEHICELK RACK AND PINION FAIELD PRIOR TO RECEIVING THE RECALL NOTICE. THE DRIVER'S SIDE POWER WINDOW MOTOR FAILED, THE ALTERNATOR, AIR CONDITIONING AND WINDSHIELD WIPER ASSEMBLY ALSO FAILED. *NM
Apr 8, 2004
Engine and engine cooling › Exhaust system › Manifold/header/muffler/tail pipe
ENGINE OVERHEATED DUE TO INTAKE GASKET FAILURE. WIFE AND MINOR CHILD STUCK ON THE SIDE OF INTERSTATE AT 9:30 PM.,WITH STRANDED VEHICLE. *AK
Apr 15, 2003 · 91,000 miles
Engine and engine cooling › Engine
WHILE DRIVING, THE ENGINE WILL CUT OUT, THEN RUN SMOOTH AGAIN, CAUSING THE CAR TO JERK. SEVERAL TIMES THE ENGINE WOULD DIE. THE CAR WOULD START BACK UP, WHEN YOU PUT INTO GEAR AND PUSH THE GAS, THE ENGINE WOULD CUT OUT, THE CAR WOULD JERK AS THE ENGINE CUT OUT AND THEN REENGAGE, BUT EVENTUALLY THE ENGINE WOULD DIE. WE SENT TO OUR LOCAL REPAIR SHOP, HE REPLACED THE SPARK PLUGS, MINOR TUNE, REPLACE AIR FILTER, CHECK FUEL PUMP - OK, AND REPLACE FUEL FILTER. CAR RAN FINE FOR THREE DAYS AND THEN REPEATED THE SAME PROBLEM. TOOK BACK INTO SHOP, REPLACED IGNITION SWITCH AND COILS. ENGINE RUNS OK, BUT WHEN ENGAGING INTO GEAR ENGINE DID NOT HAVE THE SAME RESPONSE AS BEFORE, IT FELT LIKE IT WAS…
Mar 10, 2004 · 109,000 miles
Electrical system › WiringFire
MY 1996 LUMINA MINI VAN CAUGHT ON FIRE AT THE REAR RIGHT WHEEL WELL BECAUSE OF A WIRING SHORT. LUCKILY MY GRANDCHILDREN WERE IN THE STORE WHEN THEY CAME OUT THE FIRE DEPARTMENT WAS PUTTING THE FIRE OUT. BOTH THE SIDE AND BACK DOORS COULD NOT OPEN BECAUSE THE POWER LOCK MODULE HAD MELTED. IF ANYONE WOULD HAVE BEEN INSIDE THEY WOULD NOT BEEN ABLE TO GET OUT OF THE VEHICLE SAFELY. *LA
Sep 22, 2003 · 130,000 miles

Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.