Model year record
2002 Chevrolet Malibu Classic recalls & problems
The 2002 Chevrolet Malibu Classic has no safety recalls on file with NHTSA, and 16 owner complaints. The most-reported problem area is electrical system (11 complaints).
Safety recalls
No safety recalls have been filed for the 2002 Chevrolet Malibu Classic.
Recall repairs are free at any authorised dealer. A recall listed here may already have been fixed on a particular car: enter its 17-character VIN at nhtsa.gov/recalls to see open recalls.
What owners report
| Problem area | Complaints | Typical mileage* |
|---|---|---|
| Electrical system | 11 | 69,650 mi |
| Exterior lightingHazard flashing warning lights › Switch; Turn signal › Switch | 4 | 101,000 mi |
| Engine | 2 | — |
| Unknown or other | 2 | — |
| Power train | 1 | — |
| Engine and engine coolingExhaust system › Emission control › Gas recirculation valve (egr valve) | 1 | — |
*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.
Recent owner complaints
- Exterior lighting
MY 2002 CHEVROLET CLASSIC HAS A DANGEROUS CONDITION WHERE THE TURN SIGNAL/HAZARD WARNING FLASHERS BECOME INOPERATIVE. THE CONDITION IS COMPLETELY RANDOM AND OCCURS INTERMITTENTLY. THIS HAS CREATED SURPRISE UNSAFE SITUATIONS WHEN MAKING LANE CHANGES AND LEFT AND RIGHT HAND TURNS. CHEVROLET KNOWS ABOUT THE FAULTY TURN SIGNAL/HAZARD WARNING FLASHERS HOWEVER NO RECALLS HAVE BEEN MADE. IN APRIL 2006 CHEVROLET SENT A SOMEWHAT DISMISSIVE LETTER ABOUT THE CONDITION. HOWEVER THE LETTER CLEARLY STATES THIS IS NOT A RECALL AND DO NOT TAKE YOUR VEHICLE IN FOR SERVICE. AT THAT TIME MY 2002 CHEVROLET CLASSIC DID NOT HAVE THE CONDITION DESCRIBED IN THE LETTER. I FEEL THE LANGUAGE AND INTENT OF THE LETTER…
- Exterior lighting › Hazard flashing warning lights › Switch
TL* THE CONTACT OWNS A 2002 CHEVROLET MALIBU CLASSIC. WHILE DRIVING UNKNOWN SPEEDS, THE TURN SIGNAL AND EMERGENCY LIGHT INDICATORS FAILED TO ILLUMINATE WITHOUT WARNING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO STATED THAT AN UNKNOWN MODULE SWITCH NEEDED TO BE REPLACED. THE LOCAL DEALER WAS NOT CONTACTED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 113,000.
- Engine and engine cooling › Exhaust system › Emission control › Gas recirculation valve (egr valve)
TL* THE CONTACT OWNS A 2002 CHEVROLET MALIBU CLASSIC. WHILE THE ACCELERATOR PEDAL WAS DEPRESSED, THE VEHICLE FAILED TO ACCELERATE AND LOST POWER. THE CHECK ENGINE WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE EGR VALVE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE VEHICLE WAS THEN TAKEN TO GILDNER DODGE-CHRYSLER-JEEP INC (1451 N 10TH ST, ARKADELPHIA, AR 71923 (870) 246-6800), BUT NO DIAGNOSTIC FAILURE CODES WERE FOUND AND THE FAILURE COULD NOT BE REPLICATED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND THE CONTACT WAS PROVIDED A CALL BACK. THE APPROXIMATE FAILURE MILEAGE WAS 99,378.
- Electrical system
TL* THE CONTACT OWNS A 2002 CHEVROLET MAILBU CLASSIC. WHILE DRIVING APPROXIMATELY 10 MPH, THE ENGINE STALLED WHILE MAKING A LEFT TURN AND THE SECURITY WARNING LIGHT ILLUMINATED. THE CONTACT ALSOOBSERVED AN ABNORMAL NOISE DURING THE FAILURE. THE CONTACT ALSO STATED THAT THE POWER LOCKS UNLOCKED AND LOCKED WITHOUT BEING PROMPTED AND THE GAUGE LEVELS INCREASED. THE VEHICLE WAS ABLE TO RESTART AFTER VARIOUS ATTEMPTS; HOWEVER, THE FAILURE RECURRED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE CONTACT MENTIONED THAT THE ENGINE WAS SERVICED PER A RECALL, BUT THE NHTSA CAMPAIGN NUMBER WAS NOT AVAILABLE.THE FAILURE MILEAGE WAS 110,000.
- Electrical system
TL* THE CONTACT OWNS A 2002 CHEVROLET MALIBU CLASSIC. THE CONTACT STATED THAT THE VEHICLE FAILED TO START AND THE ANTI-THEFT WARNING LIGHT ILLUMINATED. THE FAILURE RECURRED SEVERAL TIMES. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE PASS LOCK SENSOR AND IGNITION CYLINDER HAD TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 20,000.
- Electrical system
WENT TO FAULKNER LANCASTER PA. FOR INSPECTION TELLING ME I NEED A IGNITION LOCK CYLINDER IN THIS VEHICLE FOR INSPECTION . THEY DID OVERALL TEST AND CHARGED ME $ 298.00 FOR THIS INFO .I HAVE BEEN CHEATED FOR THE LAST FOUR YEARS EVERY TIME I WOULD TAKE THIS IN FOR INSPECTION. THREE CATALYTIC CONVERTER LATER OVER A THREE YEAR STRETCH .THEY DID NOTHING TO HELP THEY JUST TAKE MY MONEY AND SAY THERE WAS NO RECALL FOR IGNITION LOCK CYLINDER ON THIS VEHICLE. BUT NOW THEY WANT TO REPLACE IT AT MY EXPENSES. I HAVE BEEN RIPPED OFF AND FEEL THEY DON'T CARE ABOUT MY CAR. I PURCHASED THIS CAR IN 2004 WITH 30000 MILES AND KEPT IT SERVICED .
- Unknown or other
A/C GOES ON INTERMITTENTLY. THIS HAS GONE ON SINCE 2008. OTHERS WHO ALSO OWN MALIBUS HAVE SPOKEN ABOUT THIS PROBLEM. NOT TOO GOOD IN SUMMER!!!
- Electrical system
CHEVROLET MALIBU CONSUMER IS SEEKING REIMBURSEMENT FOR EXPENSES *CN THE CONSUMER STATED THE IGNITION LOCK CYLINDER WAS REPLACED, DUE TO THE VEHICLE STALLING. *JB CONSUMER FOLLOW-UP. UPDATED 01/28/15.*JB
Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.