Model year record
2003 Chevrolet Pickup recalls & problems
The 2003 Chevrolet Pickup has no safety recalls on file with NHTSA, and 10 owner complaints. The most-reported problem area is service brakes, hydraulic (3 complaints).
Safety recalls
No safety recalls have been filed for the 2003 Chevrolet Pickup.
Recall repairs are free at any authorised dealer. A recall listed here may already have been fixed on a particular car: enter its 17-character VIN at nhtsa.gov/recalls to see open recalls.
What owners report
| Problem area | Complaints | Typical mileage* |
|---|---|---|
| Service brakes, hydraulicAntilock/traction control/electronic limited slip | 3 | — |
| SuspensionFront › Control arm › Lower ball joint; Front › Control arm › Upper ball joint | 3 | 24,000 mi |
| TiresTemporary/emergency spare tire | 2 | — |
| SteeringLinkages › Tie rod assembly | 1 | — |
| VisibilityRearview mirrors/devices | 1 | — |
| Vehicle speed controlAccelerator pedal | 1 | — |
| Fuel/propulsion system | 1 | — |
*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.
Recent owner complaints
- Fuel/propulsion system
TL* THE CONTACT OWNS A 2003 CHEVROLET PICKUP. THE CONTACT STATED THAT THE FUEL SYSTEM WAS LEAKING. THE VEHICLE WAS TAKEN TO THE DEALER, BUT THE DIAGNOSTIC RESULTS WERE UNKNOWN. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VIN WAS UNKNOWN. THE FAILURE MILEAGE WAS 148,000.
- Vehicle speed control › Accelerator pedal
WHILE DRIVING THE ACCELERATOR PEDAL FAILED. VEHICLE WAS TOWED THE NEAREST DEALER.*AK
- Visibility › Rearview mirrors/devices
ALL SIX TIRES HAS HAD SIDEWALL DISINTEGRATION OUTSIDE THE TIRE. OUTSIDE OF THE TIRES BUBBLES BLEW UP TO THE SIZE OF BALLOONS AND THEN THE TIRE BLEW OUT. GOODYEAR, RANGLER SR LT, LT 215/85R16, TREAD 6 PLY, ROAD RANGE E, E13007822 / T305727GRF96 MVSM, PPC 2011 ALSO, SIDE VIEW MIRROWS DID NOT EXTEND FAR ENOUGH FOR THE CONSUMER TO SEE THE BACK OF THE VEHICLE. *AK THE CONSUMER STATED THAT ALL ORIGINAL FACTORY EQUIPMENT PURCHASED TO USE WITH SLIDE IN CAMPER USE. MIRRORS FULLY EXTENDED CAN ONLY VIEW 1 1/2 INCH ON END. THE CONSUMER STATED THAT ALL 7 TIRES FAILED. BOTH TIRES AND MIRRORS WERE INSPECTED BY THE SAME MECHANIC. *TC
- Suspension › Front
AFTER HITTING A BUMP IN THE ROAD CONSUMER HEARD A RATTLING NOISE COMING FROM THE FRONT SUSPENSION. DEALERSHIP WAS NOTIFIED, BUT DID NOT RESOLVE THE PROBLEM. *AK
- Service brakes, hydraulic › Antilock/traction control/electronic limited slip
WHILE DRIVING WARNING SERVICE BRAKE SYSTEM ILLUMINATED ON THE DASHBOARD. THE ABS AND PARKING BRAKE LIGHTS ALSO ILLUMINATED. VEHICLE WAS TAKEN TO THE DEALER, AND TOLD CONSUMER THAT ABS BRAKES WERE INOPERABLE. *AK
- Tires
FIRESTONE BRIDGESTONE V-STEEL RIB 625. LT245/75R16 , DOT# 7X1165V1803 . OWNER WAS DRIVING ON THE FREEWAY ABOUT 55 TO 60 MPH WHEN THE TIRE BLEW OUT THE SIDEWALL. THE TIRE PRESSURE WAS CHECKED PRIOR TO TAKING THE TRIP. *JB *NM
- Service brakes, hydraulic › Antilock/traction control/electronic limited slip
WHEN APPLYING THE BRAKES PEDAL WENT TO THE FLOOR WITHOUT WARNING. DEALER STATED THAT WAS THE WAY THE VEHICLE WAS DESIGNED.*AK
- Suspension › Front › Control arm › Lower ball joint
BALL JOINTS BROKE WHILE VEHICLE WAS COMING OFF THE DRIVEWAY. ALSO, WHILE VEHICLE WAS PULLING ANOTHER VEHICLE TIE-RODS SNAPPED. *AK
Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.
NHTSA defect investigations
- HYDRAULIC PUMP FAILRESClosedLed to recall 05V005000
GM IS CONDUCTING A RECALL ON ALL SUBJECT VEHICLES BUILD BETWEEN MAY 1999 AND OCTOBER 14, 1999.SIGNIFICANT CHANGES WERE INCORPORATED INTO PRODUCTION IN EARLY OCTOBER 1999, AND VEHICLES BUILT AFTER THAT DATE HAVE LOWER WARRANTY FAILURE RATES.THE COMPLAINT AND WARRANTY DATA APPEAR TO SUPPORT THE EFFECTIVENESS OF THESE CHANGES. GM MADE ADDITIONAL CHANGES IN NOVEMBER 1999, FEBRUARY 2000, MAY 2001, AND FEBRUARY 2004.ODI WILL CONTINUE TO MONITOR THIS PROBLEM AND WILL TAKE FURTHER ACTION, IF WARRANTED, IN THE FUTURE.FOR FURTHER TECHNICAL DETAILS SEE THE ATTACHED ENGINEERING ANALYSIS REPORT.
- PARKING BRAKE FAILUREClosedLed to recall 05V161000
IN A LETTER DATED APRIL 20, 2005, GM NOTIFIED NHTSA THAT IT HAD DECIDED THAT DEFECTS THAT RELATE TO MOTOR VEHICLE SAFETY EXIST IN CERTAIN MODEL YEAR (MY) 1999-2002 C/K 1500 SERIES (PBR PARKING BRAKE SYSTEM) AND MY 2001-2005 C/K 2500 AND 3500 SERIES (TRW PARKING BRAKE SYSTEM) PICKUPS WITH MANUAL TRANSMISSIONS.ACCORDING TO GM, SOME OF THESE VEHICLES MAY HAVE CONDITIONS THAT CAUSE THE FRICTION LININGS TO WEAR TO AN EXTENT WHERE THE PARKING BRAKE CAN BECOME INEFFECTIVE IN IMMOBILIZING A PARKED VEHICLE.GM'S ACTION COVERS AN ESTIMATED TOTAL OF 142,585 VEHICLES.DEALERS WILL INSTALL A LOW-FORCE SPRING CLIP RETAINER FOR VEHICLES EQUIPPED WITH THE PBR PARKING BRAKE SYSTEM AND INSTALL A REDESIGNED PARKING BRAKE CABLE ASSEMBLY ON VEHICLES EQUIPPED WITH THE TRW PARKING BRAKE SYSTEM. A TOTAL OF 58 NON-DUPLICATIVE COMPLAINTS WERE RECEIVED BY ODI AND GM CONCERNING THE APPROXIMATELY 59,000 MY 1999-2002…