Model year record
2001 Chevrolet Sierra recalls & problems
The 2001 Chevrolet Sierra has no safety recalls on file with NHTSA, and 9 owner complaints. The most-reported problem area is exterior lighting (1 complaint).
Safety recalls
No safety recalls have been filed for the 2001 Chevrolet Sierra.
Recall repairs are free at any authorised dealer. A recall listed here may already have been fixed on a particular car: enter its 17-character VIN at nhtsa.gov/recalls to see open recalls.
What owners report
| Problem area | Complaints | Typical mileage* |
|---|---|---|
| Exterior lightingHeadlights | 1 | — |
| Tires | 1 | — |
| Vehicle speed controlAccelerator pedal | 1 | — |
| SteeringGear box › Shaft sector | 1 | — |
| SuspensionFront › Wheel bearing | 1 | — |
| Service brakes, hydraulicFoundation components › Disc › Rotor | 1 | — |
| Engine and engine cooling | 1 | — |
| Service brakes | 1 | — |
| Engine | 1 | — |
*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.
Recent owner complaints
- Engine
TL* THE CONTACT OWNS A 2001 CHEVROLET SIERRA. WHILE DRIVING VARIOUS SPEEDS, THE ENGINE STALLED AND THE BATTERY/CHARGING WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS ABLE TO RESTART. THE FAILURE OCCURRED ON SEVERAL OCCASIONS. THE DEALER STATED THAT THE CRANK SHAFT POSITION SENSOR NEEDED TO BE REPAIRED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS UNKNOWN.
- Service brakes
HAD TO STOP FOR RED LIGHT PUSHED HARD ON BRAKE PEDAL IT AND WENT TO THE FLOOR. THANKFULLY NO ONE WAS IN FRONT OF ME. SCARED TO DRIVE IT. FLUID ALL OVER THE PLACE STEEL FRAME LINES BURST. LUCKILY ONLY 1 LINE WENT STILL HAD FRONT BRAKES HAVING TRUCK TOWED TO DEALER. *TR
- Engine and engine cooling
TL*THE CONTACT OWNS A 2001 CHEVROLET SIERRA. THE CONTACT HAS EXPERIENCED DIFFICULTY STARTING THE VEHICLE SINCE 2002. THE VEHICLE FAILS TO PROVIDE AN ERROR CODE WHEN IT IS DIAGNOSED BECAUSE THE ENGINE WILL START. RECENTLY, IN JULY OF 2008, THE VEHICLE SHUT OFF AND COULD NOT BE RESTARTED WHILE STOPPED AT A RED LIGHT. THE VEHICLE WAS TAKEN TO A REPAIR SHOP AND THEY REPLACED THE CRANKSHAFT POSITION SENSOR. THE MANUFACTURER STATED THAT HIS VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER 07V521000 (ENGINE AND ENGINE COOLING). THE FAILURE MILEAGE WAS 12,000 AND CURRENT MILEAGE WAS 98,000.
- Service brakes, hydraulic › Foundation components › Disc › Rotor
AFTER TAKING THE VEHICLE IN FOR AN INSPECTION IT WAS DISCOVERED, THAT CHUNKS WERE FALLING OFF OF THE ROTORS. THE BRAKE SYSTEM WAS NOT STOPPING THE VEHICLE AS IT SHOULD. CONSUMER HAD TO APPLY HARD PRESSURE. ALL FOUR BRAKE ROTORS WERE AFFECTED. THE MANUFACTURER WAS CONTACTED WITH NO SATISFACTION.*AK
- Suspension › Front › Wheel bearing
WHEEL BEARING SENSORS DO NOT WORK, CAUSING THE BRAKES TO FAIL. *AK
- Steering › Gear box › Shaft sector
VEHICLE IS MAKING A NOISE FROM THE STEERING COLUMN. CONSUMER TOOK THE VEHICLE TO DEALER AND IT WAS DETECTED, THE INTERMEDIATE STEERING SHAFT NEEDED TO BE REPLACED. *AK
- Vehicle speed control › Accelerator pedal
WHILE STARTING UP THE VEHICLE THE ACCELERATOR PEDAL IS HARD. CONSUMER HAS TO PRESS DOWN HARD IN ORDER FOR THE ACCELERATOR PEDAL TO RELEASE WHILE STILL IN PARK. CONSUMER TOOK VEHICLE TO THE DEALER ON SEVERAL OCCASIONS, BUT THE PROBLEM RECURRED. *AK
- Tires
WHILE DRIVING AT HIGH WAY SPEED RIGHT FRONT TIRE TREAD SEPARATED. *AK
Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.
NHTSA defect investigations
- Brake line corrosion failureClosed
On January 11, 2011, ODI opened EA11-001 to investigate allegations of premature brake line corrosion failure in model year (MY) 1999 through 2003 General Motors (GM) full-size pickup trucks and sport utility vehicles sold or registered in the following region of the United States that NHTSA has viewed as salt states for investigations of corrosion related issues:Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin.The subject vehicles represent the first five MY's of GM's GMT800 platform production, of which approximately 2,038,504 vehicles were sold in salt states (the subject vehicles).The GMT800 platform includes the following vehicles:1999-2007 Chevrolet Silverado and GMC Sierra 1500, 2500 and…
- PARKING BRAKE FAILUREClosed
ODI'S REVIEW OF COMPLAINT DATA RECEIVED SINCE THE CLOSE OF EA04-011 REVEALED NO INDICATION THAT THE INVESTIGATION SHOULD BE RE-OPENED.MORE DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE ENCLOSED IN THE DP05-009 PUBLIC FILE.ODI RESERVES THE RIGHT TO REOPEN THE INVESTIGATION IN THE FUTURE SHOULD CONDITIONS WARRANT.
- UNWANTED LOW-SPEED ABS ACTIVATIONClosedLed to recall 05V379000
IN A LETTER DATED AUGUST 29, 2005, GM NOTIFIED ODI THAT IT WAS RECALLING CERTAIN MODEL YEAR 1999 THROUGH 2002 C/K PICKUP TRUCKS AND SPORT UTILITY VEHICLES TO CORRECT A PROBLEM WITH ANTI-LOCK BRAKE SYSTEM (ABS) WHEEL SPEED SENSOR CORROSION THAT MAY RESULT IN UNWANTED ABS ACTIVATION AND EXTENDED STOPPING DISTANCES DURING LOW-SPEED BRAKING (RECALL 05V-379).GM'S RECALL COVERS APPROXIMATELY 804,000 VEHICLES CURRENTLY REGISTERED IN THE FOLLOWING 14 SALT-BELT STATES:CONNECTICUT, ILLINOIS, INDIANA, MASSACHUSETTS, MAINE, MICHIGAN, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, AND WEST VIRGINIA.THE RECALL PROCEDURE WILL INVOLVE REMOVING THE SENSOR, CLEANING THE MOUNTING SURFACE, APPLYING A RUST INHIBITOR (ZINC-X) TO THE SURFACE, AND REINSTALLING THE SENSOR.IF NECESSARY, THE SENSOR WILL BE REPLACED. THE POPULATION AND FAILURE REPORT DATA GIVEN IN THIS RESUME ARE…
- HYDRAULIC PUMP FAILRESClosedLed to recall 05V005000
GM IS CONDUCTING A RECALL ON ALL SUBJECT VEHICLES BUILD BETWEEN MAY 1999 AND OCTOBER 14, 1999.SIGNIFICANT CHANGES WERE INCORPORATED INTO PRODUCTION IN EARLY OCTOBER 1999, AND VEHICLES BUILT AFTER THAT DATE HAVE LOWER WARRANTY FAILURE RATES.THE COMPLAINT AND WARRANTY DATA APPEAR TO SUPPORT THE EFFECTIVENESS OF THESE CHANGES. GM MADE ADDITIONAL CHANGES IN NOVEMBER 1999, FEBRUARY 2000, MAY 2001, AND FEBRUARY 2004.ODI WILL CONTINUE TO MONITOR THIS PROBLEM AND WILL TAKE FURTHER ACTION, IF WARRANTED, IN THE FUTURE.FOR FURTHER TECHNICAL DETAILS SEE THE ATTACHED ENGINEERING ANALYSIS REPORT.
- PARKING BRAKE FAILUREClosedLed to recall 05V161000
IN A LETTER DATED APRIL 20, 2005, GM NOTIFIED NHTSA THAT IT HAD DECIDED THAT DEFECTS THAT RELATE TO MOTOR VEHICLE SAFETY EXIST IN CERTAIN MODEL YEAR (MY) 1999-2002 C/K 1500 SERIES (PBR PARKING BRAKE SYSTEM) AND MY 2001-2005 C/K 2500 AND 3500 SERIES (TRW PARKING BRAKE SYSTEM) PICKUPS WITH MANUAL TRANSMISSIONS.ACCORDING TO GM, SOME OF THESE VEHICLES MAY HAVE CONDITIONS THAT CAUSE THE FRICTION LININGS TO WEAR TO AN EXTENT WHERE THE PARKING BRAKE CAN BECOME INEFFECTIVE IN IMMOBILIZING A PARKED VEHICLE.GM'S ACTION COVERS AN ESTIMATED TOTAL OF 142,585 VEHICLES.DEALERS WILL INSTALL A LOW-FORCE SPRING CLIP RETAINER FOR VEHICLES EQUIPPED WITH THE PBR PARKING BRAKE SYSTEM AND INSTALL A REDESIGNED PARKING BRAKE CABLE ASSEMBLY ON VEHICLES EQUIPPED WITH THE TRW PARKING BRAKE SYSTEM. A TOTAL OF 58 NON-DUPLICATIVE COMPLAINTS WERE RECEIVED BY ODI AND GM CONCERNING THE APPROXIMATELY 59,000 MY 1999-2002…
- TAILGATE CABLE BREAKAGEClosedLed to recall 04E067000
GENERAL MOTORS FILED A DEFECT NOTICE 04V-129 ON MARCH 17, 2004, WHICH OUTLINES A PROGRAM TO REPLACE THE TAILGATE CABLES INSTALLED IN AFFECTED MODEL YEAR 2000-2004 VEHICLES.REFER TO ODI'S CLOSING REPORT FOR EA04-005 FOR ADDITIONAL INFORMATION.ODI IS AWARE OF REPORTS OF TAILGATE CABLE BREAKAGE OCCURRING IN MODEL YEAR 1999 AND EARLIER VEHICLES.THESE VEHICLES WERE EQUIPPED WITH SIMILAR TAILGATE CABLES AS ADDRESSED BY 04V-129, BUT ARE NOT BEING ADDRESSED BY CAMPAIGN O4V-129.ODI IS INITIATING A SEPARATE INVESTIGATION TO ADDRESS THESE VEHICLES.THE COMPLAINT-INJURY-FATALITY STATISTICS SUMMARIZED ABOVE PERTAIN TO MODEL YEAR 2000-2004 VEHICLES. THE COMPLAINT-INJURY STATISTICS FOR MODEL YEAR 1999 AND EARLIER VEHICLES ARE SUMMARIZED ON THE OPENING RESUME FOR THAT INVESTIGATION.
- PARKING BRAKE FAILUREClosed
ODI OPENED PE03-057 TO ASSESS PARKING BRAKE INEFFECTIVENESS IN THE SUBJECT VEHICLES.THESE VEHICLES ARE EQUIPPED WITH FOUR WHEEL DISC BRAKES THAT INCORPORATE A SINGLE-SHOE DRUM-IN-HAT PARKING BRAKE INDEPENDENT OF THE SERVICE BRAKES.COMPLAINT AND WARRANTY DATA INDICATE THAT THE PARKING BRAKE LININGS TEND TO WEAR OUT EARLY IN THE LIFE OF THE VEHICLE (AT AN AVERAGE OF 24 MONTHS IN SERVICE), REDUCING THE PARKING BRAKE SYSTEM'S TORQUE BELOW THAT NEEDED TO IMMOBILIZE THE VEHICLE.GM HAS ATTRIBUTED THIS ACCELERATED WEAR TO FOREIGN MATERIAL INTRUSION AND A FAILURE OF THE BRAKE SHOE TO PROPERLY SELF-CENTER WITHIN ITS BRAKE DRUM.EFFECTIVE WITH THE START OF MY 2003 PRODUCTION, A NEWER REDUCED FORCE HOLD-DOWN CLIP WAS INTRODUCED TO FACILITATE BRAKE SHOE DISENGAGEMENT FROM THE DRUM SURFACE.THIS PART IS ALSO AVAILABLE AT THE SERVICE LEVEL FOR THE MY 1999-2002 VEHICLES.GM HAS INDICATED THAT THE PAKING…
- STEEL WHEEL RIM FRACTUREClosed
THERE HAVE BEEN LESS THAN 2 COMPLAINTS PER 100,000 SUBJECT VEHICLES RELATED TO THE ALLEGED DEFECT.THE OLDEST VEHICLES (MY 1999) HAVE ONLY 2 COMPLAINTS IN OVER 140 THOUSAND VEHICLES AFTER OVER 4 YEARS IN SERVICE.THE RATE OF WARRANTY CLAIMS POTENTIALLY RELATED TO THE ALLEGED DEFECT IS LESS THAN 0.1%.THERE ARE NO KNOWN INCIDENTS INVOLVING RAPID LOSS OF TIRE PRESSURE OR LOSS OF VEHICLE CONTROL. A DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.