*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.
Electrical system
On XXX, at midday, in the Haggen parking lot in [XXX], I unlocked the passenger door with the silver exterior door button. At that moment the side-view camera display glitched, and afterwards the exterior door buttons stopped working. The key fob and the interior door buttons still worked. Restarting the infotainment system did not fix it, and the passive-unlock setting was not the cause. After I left the truck locked and asleep for about 20 minutes, the buttons and cameras both worked again. I use the side cameras for lane centering while driving. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Oct 17, 2026Unknown or other
I own a 2024 Chevrolet Silverado EV WT equipped with the OEM soft tonneau cover. The original cover and its warranty replacement have both failed in the same way. The cover material appears to shrink over time so that the side flaps will no longer reach and stay attached to the Velcro along the bed rails. At highway speeds the cover flaps and âballoonsâ upward, and the Velcro strips will not stay connected even when properly installed and tightened. The dealer has already replaced the cover once under warranty, but the replacement has the same problems. This suggests a design or materials defect, not a oneâtime bad part or installation error. In my opinion, the flapping and ballooning…
Nov 1, 2024Visibility › Defroster/defogger/hvac system
The contact owns a 2024 Chevrolet Silverado EV. The contact stated that while operating the vehicle in sub-zero temperatures, the HVAC unit failed to blow hot air through the vents. During the failur,e the contact was unable to defrost the windows. The vehicle was taken to the local dealer who determined that the heater control module was inoperable and needed to be replaced. The vehicle was not repaired. The contact was informed that the heater control module part was on a national back order and currently not available. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was 13,000.
Jan 2, 2026 · 13,000 milesUnknown or other
When charging my Silverado EV at Level 3 DC Fast chargers it is not charging at the same Voltage / Power as it has been in the past at the same stations (roughly half the power). I have taken it to the service center for diagnostics but they were unable to isolate the component that caused this problem, only reproduce the problem. Further details below. What component or system failed or malfunctioned, and is it available for inspection upon request? - The Level 3 DC high voltage charging is not charging at the same voltage as a comparable Silverado EV. (Pictures attached) - I can demonstrate the problem with my car on request, I have attached pictures of a new Silverado EV charging as…
Dec 16, 2025Structure › Body
On 1/20/26, we purchased a â24 Chevy Silverado EV from a Chevrolet dealership. 2 days later, on 1/22/26, while my husband was driving on the interstate, the tonneau cover partially detached and flew backwards lifting upwards and flapping violently. One of the metal crossbars detached completely from the tonneau cover and flew off the truck, and a second crossbar began to tear away. The cover was flapping forcefully which created a highly unstable and dangerous condition. My husband pulled over on the side of the interstate to remove the tonneau cover to prevent it from fully detaching. He placed the cover into the truck bed. This incident occurred suddenly, with no warning. This was a…
Jan 23, 2026Power trainCrash1 injury
The contact owned a 2024 Chevrolet Silverado EV. The contact stated that when idle, the vehicle would hesitate before accelerating. Continuing to drive at approximately 55 MPH, the accelerator was released, and the vehicle continued to accelerate. The vehicle veered off the road, where the vehicle flipped a total of 5 times before coming to a stop. The contact received injuries to their back, whipflash, and a contusion of the stomach. Medical treatment was needed and had been ongoing. The vehicle was towed and totaled. A police report was filed. The manufacturer was not informed of the failure. The failure mileage was unknown.
Apr 25, 2025 · 55 milesStructure
See attached document for complaint.
Oct 22, 2025Steering
Under heavy acceleration the vehicle swerves from lane to lane and the operator is unable to counter the steering. The behavior continues until the acceleration is halted. The vehicle was grounded due to it being deemed unsafe by the originating dealership technician and repairs were attempted but were unsuccessful. The dealership had another vehicle like mine in inventory so they tested that one and found the same erratic behavior but rather than deeming it to be a problem they declared the steering issue it to be normal for that model. This is section 4 of the attached dealership service report.
Feb 10, 2025
Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.