Model year record

2016 Chevrolet Spark Ev recalls & problems

The 2016 Chevrolet Spark Ev has 2 safety recalls and 14 owner complaints on file with NHTSA. The most-reported problem area is service brakes (10 complaints).

Recalls2safety recalls

Complaints14filed by owners

Crashes · fires2 · 0reported in complaints

Injuries · deaths1 · 0reported in complaints

Safety recalls

Seat beltsJul 10, 2017

Pretensioner

Recall 17V43700040,683 vehicles

Problem: General Motors LLC (GM) is recalling certain model year 2014-2016 Buick Lacrosse and Chevrolet Spark EV, Caprice PPV and SS vehicles, 2014-2017 Buick Encore and Chevrolet Corvette, Silverado 1500 and GMC Sierra 1500 vehicles, 2015-2016 Cadillac Escalade and Escalade ESV, Chevrolet Tahoe, Trax, Suburban and Silverado 2500 and 3500 and GMC Yukon and Yukon XL vehicles, and 2015-2017 GMC Sierra HD 2500 and 3500 vehicles. While being previously remedied for recall 16V-651, the affected vehicles may not have received the complete software update necessary to remedy the recall condition. Without the update, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Risk: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Fix: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on August 4, 2017. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 17287.

Components: Seat belts › Pretensioner; Air bags › Frontal › Sensor/control module-inactive; Air bags › Frontal

Seat beltsSep 8, 2016

Pretensioner

Recall 16V6510003,640,162 vehicles

Problem: General Motors LLC (GM) is recalling certain model year 2015-2017 Chevrolet Silverado 2500 HD, 3500 HD, Tahoe, Suburban, GMC Sierra 2500 HD and 3500 HD, GMC Yukon, GMC Yukon XL, Cadillac Escalade and Cadillac Escalade ESV vehicles and 2014-2017 Chevrolet Corvette, Silverado 1500, Trax, Caprice Police Pursuit Vehicle, GMC Sierra 1500, Buick Encore, and 2014-2016 Buick Lacrosse, Chevrolet Spark EV and SS vehicles. In the affected vehicles, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Risk: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Fix: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on October 13, 2016. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 16007.

Components: Seat belts › Pretensioner; Air bags › Frontal › Sensor/control module-inactive; Air bags › Frontal

Recall repairs are free at any authorised dealer. A recall listed here may already have been fixed on a particular car: enter its 17-character VIN at nhtsa.gov/recalls to see open recalls.

Crash test ratings

2016 Chevrolet Spark Ev 5 HB FWD

OverallNot Rated

Frontal crash	Not Rated
Side crash	Not Rated
Rollover	Not Rated

NHTSA 5-Star Safety Ratings (New Car Assessment Program). Ratings are comparable only between vehicles of similar size and weight, and ratings from 2011 on use tougher tests than earlier years. Photos: NHTSA.

Range & efficiency

Spark EV EV

82mi range

Efficiency	28.3 kWh/100 mi
MPGe city / hwy / comb	128 / 109 / 119
Charge time (240 V)	7 h

Automatic (A1) · Front-Wheel Drive · about $650/year to charge

EPA estimates from fueleconomy.gov for each engine and transmission sold. Annual cost is the EPA's estimate for 15,000 miles a year at its current fuel and electricity price assumptions. Your results will vary.

What owners report

Problem area	Complaints	Crashes	Injuries	Typical mileage*
Service brakes	10	1	1	3,006 mi
Air bags	3	1	0	4,500 mi
Seats	1	0	0	—

*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.

Recent owner complaints

Air bags
I WAS DRIVING APPROXIMATELY 25 MPH AND HIT A POT HOLE WHICH RESULTED IN THE PASSENGER AND DRIVER SIDE AIR BAG CURTAINS DEPLOYING. THERE IS NO VISIBLE DAMAGE TO TIRE OR CAR
May 31, 2018 · 18,031 miles
Service brakes
I WAS DRIVING A 2016 CHEVROLET SPARK EV ON A CITY ROADWAY WHEN I HAD A COMPLETE BRAKE FAILURE AND ALMOST WAS INVOLVED IN A COLLISION. AT THE START OF MY COMMUTE, I TURNED THE VEHICLE ON WHICH WAS PARKED ON THE OUTSIDE OF THE GARAGE. I NOTICED THAT THERE WAS A LOUD SOUND COMING FROM THE FRONT LEFT PORTION OF THE VEHICLE AS THE BRAKE PEDAL WAS PULSATING. AS I PULLED OUT ONTO THE ROADWAY THE PULSATING AND THE LOUD SOUND CONTINUED AS A SET OF WARNING LIGHTS TURNED ON. THE WARNING LIGHTS WERE (ABS WARNING, STABILITRAK AND SERVICE BRAKES). I BEGAN TO SLOW DOWN TO APPROX. 30 MPH IN A 50 MPH ZONE AS I CAME TO AN INTERSECTION. AS I CAME TO A BUSY INTERSECTION I APPLIED THE BRAKE TO STOP FOR A RED…
Oct 7, 2017 · 11,000 miles
Seats
THE CAR WAS STOPPED AND WAS HIT FROM THE REAR ON A CITY STREET. THE IMPACT SPEED WAS APPROXIMATELY 15MPH (ESTIMATED). THE DRIVER SEAT SLID BACK UPON IMPACT AND APPEARED TO DERAIL AND WAS STOPPED BY THE REAR SEAT. AFTER THE ACCIDENT, THE SEAT WOULD NOT SLIDE FORWARD. I AM CONCERNED THAT THIS IS A MAJOR VEHICLE SAFETY ISSUE THAT SHOULD BE DOCUMENTED..
Oct 10, 2017 · 14,029 miles
Service brakes
SUDDEN AND STRONG BRAKE PEDAL APPLICATIONS OCCASIONALLY RESULTED IN SIGNIFICANTLY MORE PEDAL TRAVEL, SIGNIFICANTLY LESS BRAKING FORCE, AND SIGNIFICANTLY LONGER STOPPING DISTANCES THAN TYPICALLY EXPERIENCED DURING SIMILAR BRAKE PEDAL APPLICATIONS. EACH EVENT OCCURRED ON WARM, DRY SOUTHERN CALIFORNIA STREETS DURING DAYLIGHT HOURS, TRAVELING BETWEEN 30-40 MPH. ON EACH OCCASION, THE BRAKES -- INCLUDING REGENERATION -- FUNCTIONED AS EXPECTED JUST PRIOR TO AND JUST AFTER THE EVENT, AND THE BATTERY WAS IN A STATE OF PARTIAL DISCHARGE, BUT DURING EACH EVENT THE PEDAL FEEL WAS SIMILAR TO THE FEEL EXPERIENCED JUST AFTER CHARGING TO 100% (WHEN REGENERATIVE BRAKING IS NOT YET AVAILABLE.) I SUSPECT THAT…
Sep 1, 2017
Service brakes
4 TIMES WHILE DRIVING, 1 TIME WHILE STATIONARY, THE CAR'S BRAKE ASSIST (POWER BRAKING SYSTEM) HAS GONE OUT. EACH TIME, IT WAS DIFFICULT TO SLOW THE VEHICLE AND BRING IT TO A STOP. THERE WAS A "SERVICE STABILITRAC" WARNING FOLLOWED IMMEDIATELY BY A "SERVICE BRAKE ASSIST" WARNING. CONCURRENTLY, THE ABILITY TO BRAKE IS EXTREMELY DIMINISHED. THE BRAKE PEDAL GOES MOST OF THE WAY TO THE FLOOR WITH VERY LITTLE BRAKING CAPACITY. IT FEELS LIKE THERE ARE NO POWER BRAKES, ONLY MANUAL BRAKES THAT REQUIRE A GREAT DEAL OF EFFORT. EACH OF THE FIRST THREE TIMES IT WENT INTO THE DEALERSHIP, THEY TOLD ME THEY FULLY REPLACED THE PEDAL ASSEMBLY. AS OF THE FOURTH TIME IT WENT IN (JAN 13), WHERE IT STILL IS NOW…
Jan 12, 2017 · 3,006 miles
Service brakes
4 TIMES WHILE DRIVING, 1 TIME WHILE STATIONARY, THE CAR'S BRAKE ASSIST (POWER BRAKING SYSTEM) HAS GONE OUT. EACH TIME, IT WAS DIFFICULT TO SLOW THE VEHICLE AND BRING IT TO A STOP. THERE WAS A "SERVICE STABILITRAK" WARNING FOLLOWED IMMEDIATELY BY A "SERVICE BRAKE ASSIST" WARNING. CONCURRENTLY, THE ABILITY TO BRAKE IS EXTREMELY DIMINISHED. THE BRAKE PEDAL GOES MOST OF THE WAY TO THE FLOOR WITH VERY LITTLE BRAKING CAPACITY. IT FEELS LIKE THERE ARE NO POWER BRAKES, ONLY MANUAL BRAKES THAT REQUIRE A GREAT DEAL OF EFFORT. EACH OF THE FIRST THREE TIMES IT WENT INTO THE DEALERSHIP, THEY TOLD ME THEY FULLY REPLACED THE PEDAL ASSEMBLY. AS OF THE FOURTH TIME IT WENT IN (JAN 13), WHERE IT STILL IS NOW…
Dec 21, 2016 · 2,741 miles
Service brakes
4 TIMES WHILE DRIVING, 1 TIME WHILE STATIONARY, THE CAR'S BRAKE ASSIST (POWER BRAKING SYSTEM) HAS GONE OUT. EACH TIME, IT WAS DIFFICULT TO SLOW THE VEHICLE AND BRING IT TO A STOP. THERE WAS A "SERVICE STABILITRAC" WARNING FOLLOWED IMMEDIATELY BY A "SERVICE BRAKE ASSIST" WARNING. CONCURRENTLY, THE ABILITY TO BRAKE IS EXTREMELY DIMINISHED. THE BRAKE PEDAL GOES MOST OF THE WAY TO THE FLOOR WITH VERY LITTLE BRAKING CAPACITY. IT FEELS LIKE THERE ARE NO POWER BRAKES, ONLY MANUAL BRAKES THAT REQUIRE A GREAT DEAL OF EFFORT. EACH OF THE FIRST THREE TIMES IT WENT INTO THE DEALERSHIP, THEY TOLD ME THEY FULLY REPLACED THE PEDAL ASSEMBLY. AS OF THE FOURTH TIME IT WENT IN (JAN 13), WHERE IT STILL IS NOW…
Dec 9, 2016 · 2,613 miles
Service brakes
4 TIMES WHILE DRIVING, 1 TIME WHILE STATIONARY, THE CAR'S BRAKE ASSIST (POWER BRAKING SYSTEM) HAS GONE OUT. EACH TIME, IT WAS DIFFICULT TO SLOW THE VEHICLE AND BRING IT TO A STOP. THERE WAS A "SERVICE STABILITRAK" WARNING FOLLOWED IMMEDIATELY BY A "SERVICE BRAKE ASSIST" WARNING. CONCURRENTLY, THE ABILITY TO BRAKE IS EXTREMELY DIMINISHED. THE BRAKE PEDAL GOES MOST OF THE WAY TO THE FLOOR WITH VERY LITTLE BRAKING CAPACITY. IT FEELS LIKE THERE ARE NO POWER BRAKES, ONLY MANUAL BRAKES THAT REQUIRE A GREAT DEAL OF EFFORT. EACH OF THE FIRST THREE TIMES IT WENT INTO THE DEALERSHIP, THEY TOLD ME THEY FULLY REPLACED THE PEDAL ASSEMBLY. AS OF THE FOURTH TIME IT WENT IN (JAN 13), WHERE IT STILL IS NOW…
Oct 23, 2016 · 1,773 miles

Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.

NHTSA defect investigations

Pedestrian alert soundsClosedLed to recall 22V063000
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review…
DP22005 · opened Jan 27, 2023 · closed Aug 7, 2023
Desiccated Air Bag Inflator RuptureOpen
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled…
EA21002 · opened Sep 17, 2021