Model year record
2003 Chevrolet Suburban 2500 recalls & problems
The 2003 Chevrolet Suburban 2500 has no safety recalls on file with NHTSA, and 21 owner complaints. The most-reported problem area is service brakes (10 complaints).
Safety recalls
No safety recalls have been filed for the 2003 Chevrolet Suburban 2500.
Recall repairs are free at any authorised dealer. A recall listed here may already have been fixed on a particular car: enter its 17-character VIN at nhtsa.gov/recalls to see open recalls.
What owners report
| Problem area | Complaints | Typical mileage* |
|---|---|---|
| Service brakes | 10 | 115,500 mi |
| Service brakes, hydraulic | 4 | 90,906 mi |
| Electrical systemInstrument cluster/panel | 3 | — |
| Power trainTransfer case (4-wheel drive) | 2 | — |
| Fuel/propulsion system | 2 | — |
| Engine and engine coolingEngine | 1 | — |
| Structure | 1 | — |
| Trailer hitches | 1 | — |
| Engine | 1 | — |
| Vehicle speed control | 1 | — |
*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.
Recent owner complaints
- Service brakes
BRAKE LINE FAILED WHILE DRIVING, TURNS OUT ALL LINES ARE RUSTED, NEED ALL BRAKE LINES REPLACED.
- Engine
I WILL BE DRIVING DOWN THE ROAD BOTH HWY AND CITY. THE SUBURBAN WILL GO INTO REDUCED ENGIN AND LOSE ALL ITS POWER AND SPEED. I HAVE TO PULL OVER AND CUT THE CAR OFF AND RESTART IT AND IT'S FINE TO GO FOR MAYBE A MILE AND IT DOES IT AGAIN. THEY CAN NOT PIN POINT WHAT THE PROBLEM IS . IT'S VERY DANGEROUS.
- Service brakes
BRAKE LINE FAILURE
- Service brakes
TL* THE CONTACT OWNS A 2003 CHEVROLET SUBURBAN 2500. WHILE DRIVING 35 MPH, THE CONTACT DEPRESSED THE BRAKE PEDAL AND IT TRAVELED ALL THE WAY TO THE FLOORBOARD. THE CONTACT WAS ABLE TO STOP THE VEHICLE. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE THEY PERFORMED AN INTERIM REPAIR. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT ALL THE BRAKE LINES WERE RUSTED AND NEEDED TO BE REPLACED. THE CONTACT WAS ALSO INFORMED BY THE INDEPENDENT MECHANIC THAT THE VEHICLE MAY NEED THE FUEL PUMP LINE REPLACED AS WELL. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 72,000.
- Service brakes
THE METAL BRAKE LINE BETWEEN THE ABS MODULATOR VALVE AND FRONT RIGHT WHEEL RUPTURED WHEN THE BRAKE PEDAL WAS PRESSED. THE LINE FAILED DUE TO CORROSION. ALL BRAKE LINES IN THE VEHICLE HAD SIMILAR LEVELS OF CORROSION NEAR THE AREA THE AFOREMENTIONED LINE RUPTURED, AND AT VARIOUS OTHER LOCATIONS ON THE VEHICLE. A BRAKE LINE BETWEEN THE MASTER CYLINDER AND ABS MODULATOR HAD FAILED IN A SIMILAR MANNNER APPROXIMATELY 8 MONTHS PREVIOUSLY. THE TRANSMISSION COOLER LINES HAD ALSO FAILED DUE TO CORROSION APPROXIMATELY 2 YEARS AGO. THE CORROSION AND RUST ON MANY OTHER COMPONENTS BENEATH THE VEHICLE AND IN THE ENGINE COMPARTMENT IS RATHER CONCERNING. POWER STEERING LINES (INCLUDING POWER BRAKES, SINCE…
- Service brakes
AS I WAS COMING TO AN INTERSECTION WITH A RED LIGHT, I WENT TO SLOW STOP FROM 30 MPH AND MY BRAKES FAILED ALMOST CAUSING ME TO CRASH INTO THE INTERSECTION. WHEN I APPLIED THE BRAKES THEY DID NOT ENGAGE AND MY BRAKE PEDAL WENT TO THE FLOOR. *TR
- Service brakes
I WAS SLOWLY BACKING UP AT A FLAT LAUNCH RAMP TO PUT OUR BOAT INTO THE WATER. AS THE TRAILER REACHED THE WATER, I PRESSED HARDER ON THE BRAKE PEDAL. WHEN I DID THAT, THE BRAKE PEDAL WENT TO THE FLOOR AND THE VEHICLE CONTINUED TO ROLL BACKWARDS UNTIL THE BOAT REACHED THE WATER. FORTUNATELY THAT STOPPED THE VEHICLE FROM MOVING AND ALLOWED ME TO APPLY THE PARKING BRAKE. ONE OF MY BRAKE LINES HAD BURST. THE REPAIR SHOP SAID THE BRAKE LINES WERE ALL RUSTED AND NOT IN VERY GOOD SHAPE. CONTRARY TO WHAT GM IS CLAIMING, MY VEHICLE COULD NOT STOP IN A SAFE DISTANCE AND THAT WAS WITHOUT THE BOAT/TRAILER ATTACHED. IF WE HAD BEEN EXITING THE HIGHWAY WHEN THIS HAPPENED (WHICH WE DID SHORTLY BEFORE THE…
- Service brakes
ONE OF THE METAL BRAKE LINES BETWEEN THE MASTER CYLINDER AND THE ABS MODULATOR VALVE RUPTURED DURING A STOP DUE TO CORROSION. ALL BRAKE LINES IN THE VEHICLE HAVE SIMILAR LEVELS OF CORROSION NEAR THE AREA THE AFOREMENTIONED LINE RUPTURED, AND AT VARIOUS OTHER LOCATIONS ON THE VEHICLE. THE TRANSMISSION COOLER LINES HAD FAILED APPROXIMATELY 18 MONTHS PREVIOUSLY DUE TO CORROSION. THE CORROSION AND RUST ON MANY COMPONENTS BENEATH THE VEHICLE AND IN THE ENGINE COMPARTMENT IS BECOMING RATHER CONCERNING. *TR
Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.