2023 Chevrolet Trailblazer recalls & problems

Safety recalls

Recall repairs are free at any authorised dealer. A recall listed here may already have been fixed on a particular car: enter its 17-character VIN at nhtsa.gov/recalls to see open recalls.

Crash test ratings

NHTSA 5-Star Safety Ratings (New Car Assessment Program). Ratings are comparable only between vehicles of similar size and weight, and ratings from 2011 on use tougher tests than earlier years. Photos: NHTSA.

Fuel economy

EPA estimates from fueleconomy.gov for each engine and transmission sold. Annual cost is the EPA's estimate for 15,000 miles a year at its current fuel and electricity price assumptions. Your results will vary.

What owners report

*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.

Recent owner complaints

• Unknown or other

  When going over a small bump in the road the bolts connecting the catalytic converter to the exhaust pipe snapped without any visible corrosion or rust.

  Oct 23, 2026
• Engine and engine cooling › Exhaust system › Manifold/header/muffler/tail pipe

  The contact owns a 2023 Chevrolet Trailblazer. The contact stated that while driving at approximately 25 - 30 MPH, the exhaust system, where the muffler was attached only had three bolts attached. The contact stated that the exhaust system had detached and the muffler was very loud. The tow truck driver loaded the muffler separately. The vehicle was towed to the local dealer. The dealer stated that the issue was normal wear and parts were ordered to repair the vehicle. The contact stated that the bolts on one side of the exhaust were stuck. The failure mileage was approximately 18,787.

  Oct 21, 2026 · 18,787 miles
• Exterior lighting › Headlights

  The contact owns a 2023 Chevrolet Trailblazer. The contact stated that while driving at 25 MPH, the headlights failed to illuminate as intended. The contact stated that the headlights did not provide illumination up to thirty feet. The vehicle was taken to the dealer, where the failure was not duplicated. The dealer informed the contact that the headlight bulbs were replaced. The manufacturer was notified of the failure, and a case was filed. The failure mileage was approximately 59,050.

  Oct 14, 2026 · 59,050 miles
• Electrical system

  While in Park, Ignition Key will not release. Couldn't Drive anywhere without leaving Key in the Ignition. Dealership aware of Issue with TrailBlazers 2021 to 2024. No Warning Lights Appeared. Had to get Repaired. "Shift to Park" TSB 23-NA-119

  Oct 3, 2026
• Service brakes

  purchased brand new December 2022. 7000 miles had issues with brake noise. dealership resurfaced rotors. 28000 miles turbo had to be replaced due to "reduced engine power". Was told a seal was the problem in the original design. 45000 miles a/c would stop blowing and produce extensive condensation on middle vents and "shift to park" became a problem. dealership cannot "reproduce" issues and therefore states nothing is wrong, although research shows problems exists and there is a back order on switch/shift assembly. Hopefully these problems "show" themselves to the technicians before extended warranty runs out, better yet a recall be issued.

  Aug 1, 2026
• Unknown or other

  Key getting stuck in ignition

  Sep 22, 2026
• Air bagsCrash1 injury

  I was riding in this suv with the owner heading down [XXX] towards Highway [XXX] in Madera, CA . We were approaching a turn onto highway [XXX] and there was slowed or stopped traffic in front of us, we slowed to a stop and then was hit very hard from behind by a newer Mustang.ihad my seat belt on, as usual, but we were hit so hard i hit my face on the dash, causing pain and a bloody nose, swollen lips and head pain. The air bag did not deploy, nor did the seat belt hold me in place. We called 911 and had the CHP come out. The car had to be towed away. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

  Sep 29, 2026
• EngineFire

  This incident is in regards to a fire that occurred in the engine bay area, post having turbo replacement and spark plug replacement done by a local dealership where this car was purchased new. Car had roughly approximately 60,000 miles and had a check engine light and engine reduce power notification on dash. Was taken to the aforementioned dealership for general scope of work while in the possession and actively being test driven for the repair the vehicle was driven 5 miles and the driver was flagged down by motorists for smoke. The incident was recorded by Riverside Police Department and Riverside fire department. The origin and caused are still undetermined at this time. Some…

  Sep 2, 2026

Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.