Model year record

2005 Chevrolet Venture recalls & problems

The 2005 Chevrolet Venture has 3 safety recalls and 42 owner complaints on file with NHTSA. The most-reported problem area is structure (9 complaints).

Recalls3safety recalls

Complaints42filed by owners

Crashes · fires7 · 1reported in complaints

Injuries · deaths9 · 2reported in complaints

2005 Chevrolet Venture in an NHTSA crash test — NHTSA crash test

Safety recalls

SteeringFeb 17, 2009

Steering

Recall 09E005000979 vehicles

Problem: DORMAN IS RECALLING 979 STEERING KNUCKLES, DORMAN P/NOS. 697-902 AND 697-903, SOLD UNDER DORMAN'S "OE SOLUTIONS<SUP>TM</SUP>" BRAND NAME, AND NAPA P/NOS. 7-8502 AND 7-8503 WHICH WERE SOLD FOR REPLACEMENT USE ON THE VARIOUS VEHICLES LISTED ABOVE. A POTENTIAL MATERIAL OR DESIGN DEFECT COULD RESULT IN THE STEERING KNUCKLE BREAKING IN THE HUB AREA.
Risk: A BROKEN STEERING KNUCKLE COULD RESULT IN LOSS OF STEERING CONTROL AND A POSSIBLE CRASH WITHOUT WARNING.
Fix: DORMAN WILL NOTIFY OWNERS AND REPLACE THE DEFECTIVE STEERING KNUCKLES FREE OF CHARGE AND REIMBURSE THE REPAIR FACILITY OR OWNER FOR LABOR. THE RECALL BEGAN ON FEBRUARY 23, 2009. OWNERS MAY CONTACT DORMAN'S TOLL-FREE HOTLINE AT 1-800-523-2492 AND PRESS 5.

Fuel system, otherMar 12, 2007

Storage › Tank assembly › Pressure relief devices

Recall 07E021000742 vehicles

Problem: CERTAIN DELPHI FUEL PRESSURE REGULATORS, P/NOS. FP10020-11B1, FP10026-11B1, AND FP10027-11B1, SOLD AFTER JANUARY 9, 2007, AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES LISTED ABOVE. THE UNIVERSAL PRESSURE REGULATORS (UPR) WERE PRODUCED WITHOUT AN O'RING AND RETAINER.
Risk: FUEL MAY LEAK, POSSIBLY RESULTING IN A FIRE.
Fix: DELPHI WILL NOTIFY OWNERS AND REPLACE THE UPR FREE OF CHARGE. THE RECALL BEGAN ON APRIL 23, 2007. OWNERS CAN CONTACT DELPHI AT 877-411-8770.

Latches/locks/linkagesDec 22, 2004

Doors › Latch

Recall 04V597000717,302 vehiclesopened after NHTSA action (ODI)

Problem: ON CERTAIN MINIVANS EQUIPPED WITH SECOND-ROW BUCKET SEATS OR CAPTAIN'S CHAIRS AND A POWER SLIDING DOOR ON THE PASSENGER SIDE OF THE VEHICLE, A PASSENGER USING THE INTERIOR HANDLE TO OPEN THE POWER SLIDING DOOR COULD BE INJURED.
Risk: IF A PASSENGER USES THE INTERIOR HANDLE TO OPEN THE POWER SLIDING DOOR AND HOLDS ONTO THE HANDLE WHILE IT IS BEING OPENED BY THE MOTOR, THE PASSENGER'S ARM MAY BE PUSHED INTO THE SEAT BACK OR ARMREST AND A WRIST OR LOWER ARM INJURY MAY RESULT.
Fix: DEALERS WILL REPLACE THE POWER SLIDING DOOR INTERIOR HANDLE ON THE PASSENGER-SIDE. IF THE VEHICLE IS EQUIPPED WITH A POWER OR MANUAL SLIDING DOOR ON THE DRIVER-SIDE, THE INTERIOR HANDLE WILL ALSO BE REPLACED FOR APPEARANCE REASONS. NOTE: BEFORE THE VEHICLE IS SERVICED, GM ADVISES OWNERS TO NOT USE THE INTERIOR DOOR HANDLE TO OPEN THE DOOR. THE DRIVER CAN OPEN AND CLOSE THE DOOR FROM SWITCHES AT THE DRIVER'S POSITION OR BY USING THE REMOTE KEY FOB. THE DRIVER SHOULD TELL PASSENGERS TO USE THE SWITCH LOCATED IN FRONT OF THE DOOR TO OPEN OR CLOSE IT. THE DRIVER SHOULD USE THE OVERRIDE SWITCH TO PREVENT OPERATION OF THE POWER DOOR BY CHILDREN OR BY OTHERS WHO ARE NOT FAMILIAR WITH ITS USE. THE OWNER NOTIFICATION LETTER MAILING WILL BE CONDUCTED IN PHASES WITH THE FIRST PHASE BEGINNING ON MAY 31, 2005. THE SECOND PHASE MAILING BEGAN ON JULY 18, 2005. THE RECALL BEGAN ON MAY 31, 2005. PHASE 2 BEGAN ON JULY 18, 2005. PHASE 3 (FINAL PHASE) BEGAN ON AUGUST 24, 2005, TO ALL REMAINING CUSTOMERS. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438; PONTIAC AT 1-800-620-7668; OR OLDSMOBILE AT 1-800-630-6537.

Recall repairs are free at any authorised dealer. A recall listed here may already have been fixed on a particular car: enter its 17-character VIN at nhtsa.gov/recalls to see open recalls.

Crash test ratings

2005 Chevrolet Venture w/SAB

OverallNot Rated

Frontal crash	Not Rated
Side crash	Not Rated
Rollover	Not Rated

2005 Chevrolet Venture NHTSA side crash test — NHTSA side barrier crash test

NHTSA 5-Star Safety Ratings (New Car Assessment Program). Ratings are comparable only between vehicles of similar size and weight, and ratings from 2011 on use tougher tests than earlier years. Photos: NHTSA.

Fuel economy

Venture FWD

19mpg combined

City / highway	17 / 24 mpg
Fuel	Regular Gasoline

3.4 L · 6 cyl · Automatic 4-spd · Front-Wheel Drive · about $3,550/year to fuel

EPA estimates from fueleconomy.gov for each engine and transmission sold. Annual cost is the EPA's estimate for 15,000 miles a year at its current fuel and electricity price assumptions. Your results will vary.

What owners report

Problem area	Complaints	Crashes	Fires	Injuries	Typical mileage*
StructureBody › Door; Body › Door › Hinge and attachments	9	1	0	3	44,177 mi
Latches/locks/linkagesDoors › Latch; Hood › Latch	8	0	0	3	69,250 mi
Fuel system, gasolineDelivery; Delivery › Hoses, lines/piping, and fittings	8	0	1	0	85,000 mi
Electrical systemWiring › Interior/under dash; Ignition › Switch	5	0	0	0	35,000 mi
Air bagsFrontal	5	5	0	4	31,235 mi
Service brakes, hydraulicFoundation components › Disc › Pads	3	1	0	0	—
Engine and engine coolingCooling system	3	0	0	0	—
Fuel system, otherStorage › Fuel gauge system	3	0	0	0	—
Steering	3	2	0	0	—
Seat beltsRear/other; Front › Buckle assembly	2	0	0	0	—
EquipmentAppliance › Air conditioner	2	0	0	1	—
Power trainAxle assembly	2	1	0	2	—

*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.

Recent owner complaints

Fuel system, gasolineFire
The contact owns a 2005 Chevrolet Venture. The contact stated that while his father was driving at an undisclosed speed on the highway, the vehicle suddenly lost automotive power. No warning lights illuminated. In addition, the contact stated that his father managed to pull over to the shoulder of the road, and upon further inspection, white/blue smoke was seen coming from under the vehicle, and the vehicle later caught on fire from the fuel pump/tank. The fire had leaked onto the floor; however, it had extinguished on its own. A police report was not filed; however, Law Enforcement arrived on scene to direct traffic. The local fire department did not arrive on scene. No injuries were…
Dec 15, 2025 · 116,000 miles
Steering
The contact owns a 2005 Chevrolet Venture. The contact stated that while driving at various speeds, the vehicle was making a rattling sound coming from the front passengerâs side of the vehicle. There were no warning lights illuminated. The contact took the vehicle to a certified mechanic who replaced the wheel bearing hub assembly, brakes, rotors, struts, and tires. The failure persisted. The contact took the vehicle to another certified mechanic who performed a front-end alignment however, the failure persisted. The vehicle was taken to a third mechanic who identified that the noise seemed to be coming from the steering wheel; however, the mechanic could not verify the cause of the…
Oct 26, 2021 · 236,000 miles
Air bagsCrash1 injury
TL* THE CONTACT OWNED A 2005 CHEVROLET VENTURE. WHILE DRIVING APPROXIMATELY 35 MPH IN THE RAIN, THE VEHICLE HYDROPLANED TO THE LEFT AND THEN BACK TO ITS LANE. THE REAR TIRES ROLLED OFF THE ROAD AND CAUSED THE VEHICLE TO CRASH INTO A DITCH. THE AIR BAGS DID NOT DEPLOY. A POLICE REPORT WAS FILED. THE CONTACT SUSTAINED INJURIES THAT REQUIRED MEDICAL ATTENTION. THE VEHICLE WAS TOWED TO A BODY SHOP AND DEEMED DESTROYED BY THE INSURANCE COMPANY. THE FAILURE MILEAGE WAS 130,000.
May 10, 2017 · 130,000 miles
Structure › BodyCrash1 injury
MY WIFE HIT A OLD STYLE VAN THAT HAD STOPPED FOR A DOG CROSSING A THE ROAD. THE WHOLE FRONT END HAD TO BE REPLACED. HOOD, GRILL, LIGHTS, BOTH FENDER HAD TO BE REPAIRED, ALSO THE STEAL TUBE UNDER THE RADIATOR FRAME HAD TO BE CUT OUT AND REPLACED. ON 11/5/2010 I HIT A DEER GOING 30 MPH, AGAIN FRONT END DAMAGE. BOTH TIMES THE AIR BAGS DIDN'T DEPLOY, AND ON STAR DIDN'T RESPOND. I ASKED TWO DIFFERENT CHEVROLET DEALERS IF THE AIR BAG SENSOR COULD BE TESTED, ANSWER WAS NO.
Jan 25, 2010 · 49,357 miles
Fuel/propulsion system
WE HAVE BEEN SMELLING GASOLINE FUMES IN AND OUTSIDE OUR VAN. SOMETIMES IT IS VERY POTENT AND OTHER TIMES FAINT. WHEN WE WALK INTO OUR GARAGE, WE CAN SMELL IT ALSO. IT OCCURS OFTEN WHEN MAKING A LEFT-HAND TURN. WHEN WE INSPECT IT, WE CAN'T FIND ANY LEAK. WE SMELL THIS FROM A HALF TANK TO EMPTY. *TR
Jan 1, 2015 · 225,000 miles
Air bagsCrash1 injury
2005 CHEVROLET VENTURA. CONSUMER WRITES IN REGARDS TO NON-DEPLOYMENT OF AIR BAGS. *SMD THE CONSUMER STATED HIS FATHER AND STEP-MOTHER WERE INVOLVED IN AN ACCIDENT. HIS FATHER DIED FROM HIS INJURIES AND HIS STEP-MOTHER WAS INJURED. THE CONSUMER STATED HIS FATHER HIT A DIRT BANK HEAD-ON AND THE AIR BAGS FAILED TO DEPLOY. AS A RESULT, HIS FATHER HIT THE STEERING WHEEL WITH HIS CHEST CAUSING DAMAGE TO HIS LUNGS, SPLEEN, KIDNEYS AND RIBS. HIS STEP-MOTHER HIT THE DASH AND CENTER CONSOLE WITH HER HEAD, CUTTING HER ACROSS THE FOREHEAD. *JB
Oct 15, 2012
Seat belts › Front › Buckle assembly
TL * THE CONTACT OWNS A 2005 CHEVROLET VENTURE. THE CONTACT STATED THAT THE FRONT PASSENGER SIDE SEAT BELT BUCKLE RELEASE MECHANISM FRACTURED. THE DEALER ORDERED A SEAT BELT MOUNTING KIT TO PERFORM THE REPAIR. THE MANUFACTURER WAS NOT NOTIFIED. THE VIN WAS UNAVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 90,000. UPDATED 10/24/2014*LJ UPDATED 7/14/2015*JS
Jul 9, 2014 · 90,000 miles
Fuel system, gasoline
TL* THE CONTACT OWNS A 2005 CHEVROLET VENTURE. WHILE DRIVING AT AN UNKNOWN SPEED, THE CONTACT SMELLED FUEL WITHIN THE CABIN OF THE VEHICLE. THE DEALER WAS UNABLE TO DIAGNOSE THE CAUSE OF THE FUEL ODOR. THE VEHICLE WAS NOT REPAIRED AND THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS 85,000.
Dec 16, 2013 · 85,000 miles

Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.

NHTSA defect investigations

POWER SLIDING DOORClosed
ODI EVALUATED GENERAL MOTORS' (GM) DATA, CONDUCTED CONSUMER INTERVIEWS, INSPECTED AND TESTED MY 2005-2007 GM MINIVANS WITH REGARD TO THE ALLEGED DEFECT OF A POWER SLIDING DOOR (PSD) OPENING WHILE THE VEHICLE IS OUT OF PARK.ODI IDENTIFIED A HIGH WARRANTY CLAIM RATE.HOWEVER, THESE CLAIMS ARE RELATED TO VARIOUS PROBLEMS ASSOCIATED WITH DOORS NOT PROPERLY OPENING OR CLOSING AND NOT SPECIFICALLY TO DOORS OPENING WHILE DRIVING.THE CONDITION OF THE PSD REVERSING DIRECTION DURING THE CLOSING SEQUENCE IS CONSISTENT WITH AN OBSTRUCTION OF THE DOOR, OR WITH IMPROPER ALIGNMENT OF THE DOOR, AND THIS IS ADDRESSED IN GM TECHNICAL SERVICE BULLETIN # 07-08-64-007 AND BULLETINS # 07-08-64-007A THROUGH D.ODI'S EVALUATION OF THE PSD SYSTEM NOTES NUMEROUS SAFEGUARDS TO PRECLUDE BOTH UNINTENTIONAL AND INTENTIONAL POWER OPENING OF THE PSD WHILE THE VEHICLE IS IN MOTION.A SAFETY-DEFECT TREND HAS NOT BEEN…
EA07019 · opened Dec 11, 2007 · closed Feb 23, 2009
POWER SLIDING DOOR OPENINGClosed
ODI HAS RECEIVED REPORTS THAT THE POWER SLIDING DOORS OPENED WITHOUT COMMAND WHILE THE VEHICLE WAS IN MOTION ON MODEL YEAR 2005 AND 2006 GENERAL MOTORS MINIVANS (CHEVROLET UPLANDER/VENTURE, PONTIAC MONTANA SV6/MONTANA, BUICK TERRAZA, AND SATURN RELAY).SOME REPORTS INDICATE THAT THE DOOR MAY NOT HAVE BEEN CLOSED AND LATCHED BEFORE DRIVING AWAY CAUSING THE DOOR TO REVERSE (OPEN) AT LOW VEHICLE SPEEDS.HOWEVER, OTHER REPORTS INDICATE THAT THE DOOR WAS INITIALLY SHUT THEN OPENED AFTER DRIVING FOR SEVERAL MINUTES AND/OR MILES AT VEHICLE SPEEDS BETWEEN 20 AND 70 MPH.ODI HAS UPGRADED THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA07-019) TO FURTHER ASSESS THIS ISSUE.
PE07044 · opened Aug 16, 2007 · closed Dec 11, 2007