Model year record
2002 Chevrolet Yukon recalls & problems
The 2002 Chevrolet Yukon has no safety recalls on file with NHTSA, and 6 owner complaints. The most-reported problem area is engine and engine cooling (3 complaints).
Safety recalls
No safety recalls have been filed for the 2002 Chevrolet Yukon.
Recall repairs are free at any authorised dealer. A recall listed here may already have been fixed on a particular car: enter its 17-character VIN at nhtsa.gov/recalls to see open recalls.
What owners report
| Problem area | Complaints | Typical mileage* |
|---|---|---|
| Engine and engine coolingEngine; Engine › Gasoline | 3 | — |
| Service brakes, hydraulicFoundation components › Hoses, lines/piping, and fittings | 3 | 129,000 mi |
| Electrical system12v/24v/48v battery | 1 | — |
| Parking brake | 1 | — |
| Fuel system, gasolineFuel injection system | 1 | — |
| StructureBody › Door | 1 | — |
| Steering | 1 | — |
| Unknown or other | 1 | — |
*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.
Recent owner complaints
- Unknown or other
MY WIFE WAS DRIVING DOWN THE INTERSTATE AND THE LINE RUBBED THROUGH AND LEAKED OUT. SHE WAS GOING 70 M.P.H. THE BRAKE LINES ON DRIVERS SIDE AT REAR WHEEL WERE RUBBING AND RUBBED THROUGH. THIS COULD HAVE KILLED HER. IT IS A FAULTY DESIGN, AND HAS NOTHING TO DO WITH RUST.
- Service brakes, hydraulic › Foundation components › Hoses, lines/piping, and fittings
TL* THE CONTACT OWNS A 2002 CHEVROLET YUKON XL. THE CONTACT STATED THAT WHEN DEPRESSING THE BRAKES THEY EXTENDED TO THE FLOOR AND ALL OF THE FLUID LEAKED OUT. THE VEHICLE WAS TAKEN TO A DEALER WHO ADVISED HIM THAT ALL OF THE BRAKE LINES WERE COMPLETELY RUSTED THROUGH AND NEEDED TO BE REPLACED. THE BRAKE LINES WERE REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS APPROXIMATELY 129,000. UPDATED 08/31/11 *BF THE BRAKE LINES WERE REPLACED TWICE. UPDATED 09/09/11.*JB
- Engine and engine cooling › Engine
WHILE DRIVING 45 MPH, THE VEHICLE STALLED. THE CONSUMER MANAGED TO PULL OVER AND HAD THE VEHICLE TOWED. THE CAUSE WAS NOT DETERMINED. PLEASE PROVIDE MORE INFORMATION. *JB
- Fuel system, gasoline › Fuel injection system
THE FUEL INJECTION SYSTEM DID NOT WORK CORRECTLY. THE VEHICLE HAD BEEN TO THE DEALER ON FIVE OCCASIONS AND THE PROBLEM STILL EXISTED. *NLM THERE WAS A NOISE COMING FROM UNDER THE HOOD, THE PIN IN THE ROOF CONTINUED TO FALL OUT, THE DOOR DID SHUT PROPERLY, THE BRAKES MADE A NOISE, THE VEHICLE HAD A BAD STEERING SHAFT. PH *JB
- Parking brake
INEFFECTIVE PARKING BRAKES. THERE IS NO EXTERNAL ADJUSTMENT. *AK
- Engine and engine cooling › Engine › Gasoline
WHILE DRIVING 5-50 MPH AND WITHOUT WARNING VEHICLE WILL SHUTDOWN. AFTER VEHICLE TURNS OFF THE BATTERY LIGHT WILL ILLUMINATE. DEALER HAS SERVICED VEHICLE 5 TIMES, AND HAS NOT FOUND THE CAUSE. *AK
Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.
NHTSA defect investigations
- Brake line corrosion failureClosed
On January 11, 2011, ODI opened EA11-001 to investigate allegations of premature brake line corrosion failure in model year (MY) 1999 through 2003 General Motors (GM) full-size pickup trucks and sport utility vehicles sold or registered in the following region of the United States that NHTSA has viewed as salt states for investigations of corrosion related issues:Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin.The subject vehicles represent the first five MY's of GM's GMT800 platform production, of which approximately 2,038,504 vehicles were sold in salt states (the subject vehicles).The GMT800 platform includes the following vehicles:1999-2007 Chevrolet Silverado and GMC Sierra 1500, 2500 and…
- PARKING BRAKE FAILUREClosed
ODI'S REVIEW OF COMPLAINT DATA RECEIVED SINCE THE CLOSE OF EA04-011 REVEALED NO INDICATION THAT THE INVESTIGATION SHOULD BE RE-OPENED.MORE DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE ENCLOSED IN THE DP05-009 PUBLIC FILE.ODI RESERVES THE RIGHT TO REOPEN THE INVESTIGATION IN THE FUTURE SHOULD CONDITIONS WARRANT.
- HYDRAULIC PUMP FAILRESClosedLed to recall 05V005000
GM IS CONDUCTING A RECALL ON ALL SUBJECT VEHICLES BUILD BETWEEN MAY 1999 AND OCTOBER 14, 1999.SIGNIFICANT CHANGES WERE INCORPORATED INTO PRODUCTION IN EARLY OCTOBER 1999, AND VEHICLES BUILT AFTER THAT DATE HAVE LOWER WARRANTY FAILURE RATES.THE COMPLAINT AND WARRANTY DATA APPEAR TO SUPPORT THE EFFECTIVENESS OF THESE CHANGES. GM MADE ADDITIONAL CHANGES IN NOVEMBER 1999, FEBRUARY 2000, MAY 2001, AND FEBRUARY 2004.ODI WILL CONTINUE TO MONITOR THIS PROBLEM AND WILL TAKE FURTHER ACTION, IF WARRANTED, IN THE FUTURE.FOR FURTHER TECHNICAL DETAILS SEE THE ATTACHED ENGINEERING ANALYSIS REPORT.
- STEEL WHEEL RIM FRACTUREClosed
THERE HAVE BEEN LESS THAN 2 COMPLAINTS PER 100,000 SUBJECT VEHICLES RELATED TO THE ALLEGED DEFECT.THE OLDEST VEHICLES (MY 1999) HAVE ONLY 2 COMPLAINTS IN OVER 140 THOUSAND VEHICLES AFTER OVER 4 YEARS IN SERVICE.THE RATE OF WARRANTY CLAIMS POTENTIALLY RELATED TO THE ALLEGED DEFECT IS LESS THAN 0.1%.THERE ARE NO KNOWN INCIDENTS INVOLVING RAPID LOSS OF TIRE PRESSURE OR LOSS OF VEHICLE CONTROL. A DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.