The 1995 Chrysler Sebring has 5 safety recalls and 132 owner complaints on file with NHTSA. The most-reported problem area is suspension (48 complaints).
Problem: CERTAIN AIRTEX FUEL PUMP MODULE ASSEMBLIES, P/N E7081H, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE VEHICLES LISTED ABOVE. THE WALL OF THE FLARED FITTING OF THE FUEL PUMP IS NOT THICK ENOUGH TO PREVENT THE MATING THREADED FITTINGS FROM BOTTOMING OUT BEFORE AN ADEQUATE SEAL IS ACHIEVED. THIS CONDITION MAY RESULT IN LEAKAGE OF FUEL AT THE CONNECTION OF THE VEHICLE FUEL LINE AND THE FUEL PUMP MODULE ASSEMBLY.
Risk: IN THE PRESENCE OF AN IGNITION SOURCE, A FUEL LEAK COULD RESULT IN A FIRE.
Fix: AIRTEX WILL NOTIFY OWNERS AND REPLACE THE FUEL PUMPS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING JULY 2007. OWNERS CAN CONTACT AIRTEX AUTOMOTIVE AT 800-880-3056.
Fuel system, gasoline › Delivery › Fuel pump
NHTSA recall 06E088000 · Oct 23, 2006 · 39,243 vehicles
Problem: CERTAIN TIGAS FUEL PUMP MODULES MANUFACTURED BETWEEN JUNE 1 AND SEPTEMBER 24, 2006, SOLD UNDER VARIOUS BRAND NAMES AND P/NOS. THESE FUEL PUMP MODULES ARE SOLD AS AFTERMARKET FOR USE IN CERTAIN DAIMLERCHRYSLER VEHICLES LISTED ABOVE. SILICONE MATERIAL USED IN MANUFACTURE OF THE FLAPPER VALVE WAS OUT-OF-SPECIFICATION, LEADING TO EXCESS SWELL OF THE FLAPPER VALVE RESTRICTING THE FLOW OF FUEL TO THE FUEL PUMP MODULE.
Risk: FUEL RESTRICTION COULD RESULT IN LOSS OF POWER AND/OR ENGINE STALL, POSSIBLY RESULTING IN A VEHICLE CRASH.
Fix: TI AUTOMOTIVE WILL NOTIFY OWNERS AND REPLACE THE DEFECTIVE FUEL PUMP MODULES FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 6, 2006. OWNERS MAY CONTACT TI AUTOMOTIVE TOLL-FREE AT 1-877-461-1834.
Suspension › Front › Control arm › Lower ball joint
NHTSA recall 00V421002 · Dec 18, 2000 · 393,796 vehicles · opened after NHTSA action (ODI)
Problem: VEHICLE DESCRIPTION: PASSENGER VEHICLES. IF THE RUBBER BOOTS ON THE LOWER LATERAL ARM BALL JOINTS OF THE FRONT SUSPENSION WERE DAMAGED DURING ASSEMBLY, DIRT AND WATER CAN INTRUDE. ALSO, MMC HAS ADDED THE POTENTIAL OF LEAKING MOISTURE, WHICH CAN CAUSE THE BALL STUD TO CORRODE.
Risk: THIS CONDITION COULD CAUSE THE LOWER LATERAL ARM BALL JOINT TO SEPARATE, INCREASING THE RISK OF A VEHICLE CRASH. THIS CAMPAIGN SUPERCEDES MMC'S PREVIOUS SAFETY RECALL CAMPAIGN, SEE 99V-066.
Fix: DEALERS WILL INSPECT THE LOWER LATERAL ARM BALL JOINT FOR WEAR. BALL JOINTS THAT EXHIBIT WEAR BEYOND THE ESTABLISHED TOLERANCE WILL BE REPLACED WITH NEWLY DESIGNED LATERAL ARM BALL JOINTS. BALL JOINTS THAT ARE WITHIN THE ESTABLISHED TOLERANCE WILL BE CLEANED AND A SPECIAL SEALANT WILL BE APPLIED TO PREVENT INTRUSION OF MOISTURE.
Suspension › Front › Control arm › Lower ball joint
NHTSA recall 99V066003 · Apr 5, 1999 · 165,857 vehicles · opened after NHTSA action (ODI)
Problem: VEHICLE DESCRIPTION: PASSENGER VEHICLES. IF THE RUBBER BOOTS ON THE LOWER LATERAL ARM BALL JOINTS OF THE FRONT SUSPENSION WERE DAMAGED DURING ASSEMBLY, DIRT AND WATER CAN INTRUDE.
Risk: THIS CONDITION COULD CAUSE THE LOWER LATERAL ARM BALL JOINT TO SEPARATE, INCREASING THE RISK OF A VEHICLE CRASH.
Fix: DEALERS WILL INSPECT THE RUBBER BOOTS, AND IF THE BOOT IS DAMAGED, THEY WILL REPLACE THE LOWER LATERAL ARM AND BALL JOINT ON THE AFFECTED VEHICLES.
Suspension › Front › Control arm › Lower ball joint
NHTSA recall 97V201000 · Nov 13, 1997 · 599,000 vehicles · opened after NHTSA action (ODI)
Problem: VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE LOWER CONTROL ARM BALL JOINT CAN SEPARATE DUE TO LOSS OF LUBRICATION.
Risk: SEPARATION OF THE BALL JOINT COULD CAUSE A LOSS OF STEERING CONTROL INCREASING THE RISK OF A VEHICLE CRASH.
Fix: DEALERS WILL INSPECT THE BALL JOINT END HOUSING COVER SEAL FOR LEAKAGE WITH A HIGH PRESSURE AIR TESTER AND THE RUBBER BOOT WILL BE VISUALLY INSPECTED FOR DAMAGE. IF THE COVER SEAL LEAKS OR THE BOOT IS DAMAGED, THE LOWER CONTROL ARM WILL BE REPLACED.
Recall repairs are free at any authorised dealer. A recall listed here may already have been fixed on a particular car: enter its 17-character VIN at nhtsa.gov/recalls to see open recalls.
Fuel economy
Sebring
23mpg combined
City / highway
19 / 30 mpg
Fuel
Regular Gasoline
2 L · 4 cyl · Manual 5-spd · Front-Wheel Drive · about $2,900/year to fuel
Sebring
23mpg combined
City / highway
19 / 29 mpg
Fuel
Regular Gasoline
2 L · 4 cyl · Manual 5-spd · Front-Wheel Drive · about $2,900/year to fuel
Sebring
22mpg combined
City / highway
19 / 29 mpg
Fuel
Regular Gasoline
2 L · 4 cyl · Automatic 4-spd · Front-Wheel Drive · about $3,050/year to fuel
Sebring
21mpg combined
City / highway
18 / 27 mpg
Fuel
Regular Gasoline
2 L · 4 cyl · Automatic 4-spd · Front-Wheel Drive · about $3,200/year to fuel
Sebring
21mpg combined
City / highway
18 / 26 mpg
Fuel
Regular Gasoline
2.5 L · 6 cyl · Automatic 4-spd · Front-Wheel Drive · about $3,200/year to fuel
EPA estimates from fueleconomy.gov for each engine and transmission sold. Annual cost is the EPA's estimate for 15,000 miles a year at its current fuel and electricity price assumptions. Your results will vary.
What owners report
Problem area
Complaints
Crashes
Fires
Injuries
Typical mileage*
Suspension Front › Control arm › Lower ball joint; Front › Control arm
48
4
1
4
97,000 mi
Service brakes, hydraulic Antilock/traction control/electronic limited slip; Foundation components
39
2
0
0
—
Engine and engine cooling Engine › Gasoline; Engine
Equipment Appliance › Air conditioner; Electrical › Radio/tape deck/cd etc.
7
0
0
0
—
*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.
Recent owner complaints
Aug 24, 2010 · 189 milesSuspension MY 95 CHRYSLER SEBRING HAS A SQUEAKING NOISE ON THE PASSENGER SIDE TOWARDS THE BACK TIRES I HAD IT CHECKED OUT THEY SAID THE RUBBER PIECE ON BY BALL JOINT IS GONE SO THE NOISE IS FROM THE METAL RUBBING AND TO BE CAREFUL CAUSE IT CAN CAUSE AN ACCIDENT IF NOT FIXED THE BALLJOINT WILL COME OFF AND TIRES. I ALSO HAVE A PROBLEM WITH MY APR'S SHIFTING OUT OF CONTROL WHILE DRIVING THAT I'VE ALMOST HAD AN ACCIDENT COUPLE TIMES I HAVE NO CHOICE BUT TO DRIVE THE CAR THAT'S ALL I HAVE. *TR
Jan 19, 2010 · 152,000 milesSuspension › Front › Control arm › Lower ball joint TL*THE CONTACT OWNS A 1995 CHRYSLER SEBRING. SHE STATED THAT WHILE DRIVING 10 MPH WHEN THE WHOLE WHEEL AND THE BALL JOINTS CAME OFF OF THE AXLE, THE VEHICLE FELL ON THE GROUND. THE VEHICLE WAS TOWED TO A LOCAL AUTO SHOP TO DIAGNOSE THE FAILURE. THE MECHANIC STATED THAT IT WAS THE BALL JOINT CV AXLE THAT FAILED. NO REPAIRS HAVE BEEN MADE. THE DEALER WAS CONTACTED AND THEY GAVE HER A CASE NUMBER STATING THAT SOMEONE WOULD CALL HER BACK . NHTSA CAMPAIGN ID NUMBER, 00V421002, SUSPENSION FRONT CONTROL ARM, LOWER BALL JOINT IS RELATED TO THE FAILURE; HOWEVER, CHRYSLER STATED THAT THEY WOULD INFORM HER IF THE VEHICLE QUALIFIES. THE FAILURE AND CURRENT MILEAGES WERE 152,000.
Sep 26, 2005 · 128,500 milesFuel system, gasoline › Fuel injection system › Injectors DT: THE INJECTORS LEAKED. ALSO, THERE WAS A FUEL SMELL IN THE VEHICLE. WAS NOT SURE WHAT CAUSED THE LEAKAGE. THE CONSUMER FOUND THIS OUT WHEN HE WENT TO GET THE BRAKES REPAIRED. THE PROBLEM WAS FOUND ON SEPTEMBER 26, 2005. THE SMELL HAD BEEN THEIR FOR AT LEAST SIX MONTHS OFF AND ON. THERE HAVE BEEN NO ACCIDENTS AS OF YET. THE VEHICLE HAS NOT BEEN REPAIRED AS OF YET. *AK
Sep 23, 2005 · 129,000 milesFuel system, gasoline › Fuel injection system › Fuel rail I WISH YOU WOULD RECALL THE FUEL RAIL WHICH CONNECTS TO MY CHRYSLER SEBRING LXI 2.5 COUPE,WHY, BECAUSE IT COULD CAUSE A FIRE WITH JUST A SPARK IT ALSO LEAKS AND I HAVE MY KIDS TO THINK ABOUT. FROM WHAT I'VE BEEN TOLD THIS HAPPENS TO A LOT OF SEBRINGS. I'D RATHER FILE A COMPLAINT BEFORE SOMETHING TERRIBLE HAPPENS RATHER THEN WAIT TILL ITS TOO LATE. *NM
May 15, 2002 · crash · 8 injuriesElectrical system › Alternator/generator/regulator AS I WAS LEAVING I PUT MY CAR ON REVERSE TO DRIVE OFF.I PUSHED THE GAS PEDAL IT TOOK OFF AND HIT A POLE.WHAT I MEAN BY TOOK OFF IS THAT I ONLY HAD A SMALL AREA TO REVERSE IN SO I GENTLY PUSHED THE PEDAL AND IT LIKE JERKED AND AT A FASTER PACE REVERSED INTO THE POLE.I THEN HAD TO PUT IT IN DRIVE TO MOVE IT AWAY FROM WRECKED POLE I PUT THE CAR ON DRIVE THEN I PUSHED THE PEDAL TO DRIVE AWAY THE CAR ALONE WENT AT A HIGH RATE OF SPEED I COULD NOT CONTROL IT TO STOP IT.I HIT THE BRAKES AND IT DID STOP.I EVEN LIFT THE EMERGENCY BRAKES.NOT EVEN DID THE AIR BAGS COME OUT.FROM THERE MY CAR WAS TAKEN BY THE CHP TO INVESTIGATE.FROM THERE MY CAR WAS TAKEN TO THE BODY SHOP.I DID NOT RECIEVE MY CAR FROM…
Apr 27, 2004 · crashPower train › Driveline › Universal joint WHILE DRIVING VEHICAL SUDDENLY LOST CONTROL DUE TO LOWER LATERAL ARM OF SUSPENSION BREAKING ON PASSENGER'S SIDE WHICH IN TURN CAUSED EXTENSIVE OTHER DAMAGE TO SUSPENSION...ETC. REPLACED CV BOOTS, ALSO NOTICED DAMAGE TO OTHER PARTS. RECENTLY LEARNED ABOUT RECALL AND WOULD LIKE MORE INFO ON HOW TO HAVE REPAIRS PERFORMED.*AK
May 29, 2001 · 109,549 miles · crashSuspension › Front › Control arm › Lower ball joint 2 YEARS AGO, WHILE DRIVING BETWEEN 5-10 MPH THE RIGHT LOWER LATERAL BALL JOINT BROKE IN TWO, CAUSING $10,000.00 IN BODY REPAIRS, RECALL REPAIRS, ALL TO THE FRONT END OF MY CHRYSLER SEBRING.THE LOCAL DEALERSHIP HAD MY CAR FOR 3 MONTHS WORKING ON MY CAR. I NEVER RECEIVED A RECALL NOTICE!!! JUST MINUTES BEFORE I WAS ON THE INTERSTATE, WE WOULD HAVE BEEN KILLED. NOW 2 YEARS LATER AND ONLY 18,000 MILES LATER MY CAR IS MAKING A NOISE IN THE WHEEL. I TAKE IT BACK TO THE DEALERSHIP AND THEY SAY IT IS THE BALL JOINT ,( THE OTHER SIDE) THEY SAID IT IS A NON SERVICEABLE , IT HAS RUST AND IS DRY. THE DEALERSHIP TOLD ME MY CAR IS NOT SAFE TO DRIVE!!!!!THAT THE WHEEL COULD FALL OFF AGAIN!!! BUT THE PART…
Feb 29, 2004 · 98,000 milesSuspension › Front › Control arm › Lower ball joint WHILE DRIVING FRONT DRIVER'S SIDE TIRE DETACHED FROM THE VEHICLE DUE TO A BROKEN LOWER BALL JOINT. VEHICLE WAS TOWED THE DEALER, BUT HAS NOT BEEN REPAIRED. *AK
Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.
NHTSA defect investigations
DP03002 · opened May 7, 2003 · closed Jul 22, 2003STEERING COLUMN SEPARATION MR. LARRY A. SACKEY SUBMITTED A PETITION TO THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) BY LETTER DATED APRIL 18, 2003, REQUESTING THAT NHTSAFURTHER INVESTIGATE THE DEFECTIVE COLLAPSIBLE STEERING SHAFT SYSTEM ON 1987-1995 VEHICLES MANUFACTURED BY THE DAIMLERCHRYSLER CORPORATION.IN PART BECAUSE OF 49 CFR ? 30120(G), NHTSA HAS DECIDED TO LIMIT THE SCOPE OF THE PETITION VEHICLES TO 1993-1995 MODELS, EXCLUDING THE 1993 JEEP GRAND CHEROKEE AND 1994-1995 DODGE RAM SERIES TRUCKS THAT WERE RECALLED (93V210 & 96V230) FOR STEERING COLUMN FAILURE.IF THE ANALYSIS OF THESE VEHICLES HAD IDENTIFIED A POTENTIAL PROBLEM, THE SCOPE COULD HAVE BEEN EXPANDED IN AN INVESTIGATION.A REVIEW OF ODI'S DATA BASE SHOWS NO RECENT COMPLAINTS AND A LACK OF A COMPLAINT TREND CONCERNING THE SUBJECT ISSUE ON THE SUBJECT VEHICLES AS A WHOLE OR BY INDIVIDUAL MODELS.THEREFORE, THE PETITION IS DENIED.FOR…
PE02082 · opened Nov 6, 2002 · closed Apr 23, 2003SAFETY BELT CINCHING LATCH PLATE THERE ARE NO INJURIES OR FATALITIES ASSOCIATED WITH THIS ALLEGED DEFECT.WHILE CONDUCTING THIS INVESTIGATION, ODI FOUND THAT THE SUBJECT CINCHES MEET THE LOAD BEARING REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD 208, AND THAT MANY OF THE REPORTED FAILURES WERE DUE TO INCORRECT CHILD SAFETY SEAT INSTALLATIONS. ADDITIONALLY, THE REPORT RATE IS LOW (1.60/100K).THE INFORMATION AVAILABLE FAILS TO ESTABLISH THE EXISTENCE OF A DEFECT TREND AT THIS TIME.FURTHER ALLOCATION OF AGENCY RESOURCES TO THIS ISSUE IS UNWARRANTED AND THE PRELIMINARY EVALUATION IS BEING CLOSED.
RQ00015 · opened Aug 2, 2000 · closed Apr 20, 2001 · led to recall 00V421001LOWER CONTRTOL ARM BALL JOINT There is no summary currently available
PE99008 · opened Feb 1, 1999 · closed Apr 13, 1999 · led to recall 99V066001BALL JOINT allege failure of front ball joints may cause the driver to loose control of the vehicle as the front suspension collapses on one side.this loss of control increases the risk of a vehicle crash.
PE98001 · opened Jan 7, 1998 · closed May 29, 1998AUTOMATIC TRANSAXLE IGNITION INTERLOCK ALLEGED FAILURE OF THE AUTOMATIC TRANSAXLE IGNITION INTERLOCK SYSTEM EITHER ALLOWS THE IGNITION KEY TO BE REMOVED WHEN THE TRANSMISSION GEAR SELECTOR IS NOT IN THE PARK POSITION OR PREVENTS THE IGNITION KEY FROM BEING REMOVED WHEN THE TRANSMISSION GEAR SELECTOR IS IN THE PARK, OR ANY OTHER, POSITION.