Model year record

1999 Dodge Ram 2500 recalls & problems

The 1999 Dodge Ram 2500 has 2 safety recalls and 313 owner complaints on file with NHTSA. The most-reported problem area is service brakes, hydraulic (78 complaints).

Recalls2safety recalls

Complaints313filed by owners

Crashes · fires19 · 2reported in complaints

Injuries · deaths18 · 0reported in complaints

Safety recalls

SteeringMar 28, 2008

Linkages › Tie rod assembly

Recall 08E0270005,700 vehicles

Problem: AFFINIA IS RECALLING 5,700 AFTERMARKET CHASSIS TIE ROD ASSEMBLIES MANUFACTURED FROM MARCH 28, 2006 THROUGH MARCH 17, 2008, SOLD FOR USE ON MY 1998 AND 1999 DODGE RAM 2500 AND 3500 HEAVY DUTY TRUCKS. THE DUST SEAL SUPPLIED WITH THE CHASSIS TIE RODS WERE MANUFACTURED TO THE WRONG SPECIFICATION. AS A CONSEQUENCE, THE DUST SEAL MAY PREVENT THE BALL STUD OF THE CHASSIS TIE ROD FROM PROPERLY SEATING INTO THE TAPER OF THE VEHICLE STEERING KNUCKLE DURING AFTERMARKET INSTALLATION.
Risk: IF THIS CONDITION REMAINS UNDETECTED, THE BOLT CAN EVENTUALLY UNSEAT COMPLETELY, CAUSING THE AFFECTED WHEEL TO DISENGAGE FROM THE STEERING MECHANISM, POSSIBLY RESULTING IN A CRASH.
Fix: AFFINIA WILL NOTIFY OWNERS AND REPLACE THE AFFECTED CHASSIS TIE ROD ASSEMBLIES FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING APRIL 2008. OWNERS MAY CONTACT AFFINIA AT 734-827-5400.

Engine and engine coolingMar 15, 2006

Engine and engine cooling

Recall 06E02400044,386 vehicles

Problem: CERTAIN REPLACEMENT K&N FUEL PERFORMANCE KITS, P/NOS. 57-1509, 57-1511, 57-1511-1, 57-1517, 57-1517-1, 57-1527, AND 57-1530. ALSO, A SMALL PERCENTAGE OF THESE KITS WERE SOLD UNDER THE MOPAR PERFORMANCE PARTS BRAND NAME (P/NOS. P5007069 AND P5007070). ALL KITS WERE MANUFACTURED FROM APRIL 20, 1999, THROUGH SEPTEMBER 23, 2004. THESE ASSEMBLIES WERE MANUFACTURED AS REPLACEMENT EQUIPMENT FOR CERTAIN DODGE PICKUP TRUCKS AND SUVS. A SMALL PIECE OF MATERIAL FROM THE TUBE WALL COULD BE SUCKED INTO THE ENGINE THROTTLE BODY, WHICH COULD CAUSE THE THROTTLE TO BECOME JAMMED IN THE OPEN POSITION.
Risk: A JAMMED OPEN THROTTLE COULD CAUSE UNINTENDED ACCELERATION OF THE VEHICLE, POSSIBLY RESULTING IN A CRASH OR INCREASED STOPING DISTANCES WHEN BRAKING.
Fix: K&N WILL PROVIDE OWNERS WITH A FREE REPAIR KIT ALONG WITH REPAIR INSTRUCTIONS. THE RECALL BEGAN ON APRIL 20, 2006.

Recall repairs are free at any authorised dealer. A recall listed here may already have been fixed on a particular car: enter its 17-character VIN at nhtsa.gov/recalls to see open recalls.

What owners report

Problem area	Complaints	Crashes	Fires	Injuries	Typical mileage*
Service brakes, hydraulicAntilock/traction control/electronic limited slip; Foundation components › Disc	78	3	0	2	60,000 mi
StructureFrame and members; Body	54	1	0	1	96,500 mi
Power trainAutomatic transmission; Manual transmission	38	2	0	0	54,032 mi
SteeringGear box (other than rack and pinion); Steering wheel/handle bar	37	3	0	4	49,000 mi
SuspensionFront; Front › Stabilizer bar	27	2	0	0	45,000 mi
Engine and engine coolingEngine › Diesel; Engine	24	1	0	0	96,945 mi
Unknown or other	20	0	0	1	99,800 mi
Air bagsFrontal	19	11	0	14	128,000 mi
Electrical systemWiring › Front underhood; 12v/24v/48v battery	17	0	2	4	86,000 mi
Seat beltsFront › Anchorage; Front › Buckle assembly	16	1	0	1	131,000 mi
Fuel system, gasolineDelivery › Fuel pump; Delivery	14	0	1	0	100,200 mi
TiresTemporary/emergency spare tire; Tread/belt	13	0	0	0	75,500 mi

*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.

Recent owner complaints

Air bags
I know I am not the only one that thinks this is a bad problem, in fact I have not met a person that has owned this era of Dodge Ram that has their Dashboard and the whole parts inside can have been falling apart. Mine has fallen and hit my legs and or lap. Now I donât mean the whole dash at one time but I have glued, taped and put a dash pad over top to try to keep things from falling into the vents and blower motor or anything that is behind and under the top. This is a definite safety problem cause I never know when this will happen and happening more often. I bought this truck with 11 miles on it from Logansport Indiana, September of 1999. I had been looking for a 2 wheel drive with a…
May 16, 2007
Unknown or other1 injury
While wiping down the dashboard, I sliced my finger open on a piece of the dashboard which was sticking up. This dashboard is a brittle as a potato chip and had cracked but I didn't notice it since the crack was very near the windshield and the section that broke apart was at the defroster vent situated away from my viewpoint.
Apr 27, 2022
Electrical system
THE DASHBOARD HAS DISINTEGRATED CAUSING EXPOSURE TOO WIRING, INTERMITTENT DIAGNOSED AND UNDIAGNOSED PROBLEMATIC WIRING ISSUES WITH INTERMITTENT 'NO BUS' CAUSING LOSS OF POWER ON FREEWAY. DEALER UNABLE OR UNWILLING TO FURTHER DIAGNOSE ISSUE UNLESS ENTIRE DASHBOARD PLASTIC IS REPLACED UNFORTUNATELY IT IS THE SAME PLASTIC THAT NUMEROUS PEOPLE ACCORDING TO DEALER AND ACCORDING TO SEVERAL INTERNET SEARCHES THAT THE DASHBOARD PLASTIC WAS NOT MANUFACTURED PROPERLY CAUSING PHYSICAL, EMOTIONAL AND FINANCIAL HARM TO TENS OF THOUSANDS OF DODGE /CHRYSLER OWNERS. WHEN MY TRUCK LOST ALL POWER I WAS DRIVING IN FAST LANE OF FWY. ALL POWER WAS GONE INCLUDING BRAKES AND STEERING. HAD TO USE MUSCLE POWER TO…
Jul 20, 2016 · 114,705 miles
Unknown or other
WENT TO HAVE A FRONT END ALIGNMENT DONE BECAUSE THE TRUCK FELT OFF IN THE FRONT WHEN DRIVING.AND THE MECHANIC STATED HE COULDN'T DO IT AS THE FRAME IS ROTTED WHERE THE DRIVERS SIDE SWAY BAR BOLTS TO THE FRAME. IT IS RIGHT BEFORE THE STEERING GEAR BOX AND WAS TOLD IT'S A HUGE PROBLEM THAT THESE DODGE'S HAVE. TRUCK ONLY HAS 98000 MILES ON IT AND IT IS ALWAYS GARAGED. MAINTENANCE ALWAYS DONE AS STATED PER THE OWNERS MANUAL. IT'S NOT SAFE TO DRIVE.
Feb 21, 2020 · 98,000 miles
Unknown or other
DRIVING OVER A SPEED BUMP UNDER 5 MPH THE DASH BOARD CRUMBLED INTO SEVERAL PIECES. IF THIS WERE TO HAPPEN IN A COLLISION THAT SHRAPNEL WOULD BE DEADLY. MY TRUCK ONLY HAS 99800 MILES ON IT. IN EXCELLENT CONDITION THERE IS NO REASON FOR THIS TO HAPPEN. THERE ARE THOUSANDS OF COMPLAINTS ONLINE ABOUT THESE DASHBOARDS JUST FALLING APART. IT'S A SERIOUS SAFETY ISSUE AND DODGE NEEDS TO BE MADE TO RECALL THEM.
Feb 20, 2020 · 99,800 miles
Seat belts
AFTER RELATIVELY SHORT LIFE, THE SEAT BELT CONTROL TIMER MODULE FAILS, LEAVING SEAT BELTS INOPERABLE - A SIGNIFICANT SAFETY HAZARD!! SEAT BELTS REMAIN IN A LOCKED POSITION, PREVENTING USE WHILE DRIVING. DODGE P/N 56043003AD. DODGE HAS RECEIVED REPORTS ABOUT THE PROBLEM ALONG WITH REQUESTS TO PURCHASE PART, FOR MANY YEARS BUT HAS CHOSEN TO STOP PRODUCTION OF THE PART. THAT WOULD NOT BE AS BIG AN ISSUE IF THEY HAD ENSURED AN ONGOING SUPPLY FROM THIRD PARTY VENDORS. AS IT STANDS, THEY HAVE CREATED A MAJOR SAFETY CRISIS FOR TENS OF THOUSANDS OF USERS OF THE LATE 90'S TO EARLY 2000'S TRUCKS.
Dec 18, 2018
Air bags
FOR NO APPARENT REASON THE AIR BAG LIGHT CAME ON. IT SEEMS TO BE THE CLOCK SPRING MECHANISM. THE CURRENT RECALL FOR THIS PROBLEM DOES NOT INCLUDE MY VEHICLE, WHERE I BELIEVE IT SHOULD.
Mar 21, 2018 · 165,000 miles
Air bags
THIS IS MY SECOND COMPLAINT REGARDING DASH BOARD. THE DASH STARTED CRACKING WITH JUST 30,000 MILES ON TRUCK, WHEN I PUT IN COMPLIANT TO NHTSA. NOW 109,000 THE ELECTRICAL, AIR BAGS, COMPUTER HARNESS WIRING ARE EXPOSED WITH A INTERMITTENT STALLING AND A GUESSING GAME FROM AUTHORIZED DODGE DEALERS AS TO WHAT MIGHT BE THE ISSUES. "UNDETERMINED ELECTRICAL SHORTS FROM CRACKED DASH A POSSIBILITY" "ABS SERVICE LIGHT STAYS ON, ALSO "UNDETERMINED BY DEALER", "CAN'T TRACK CODE" "DON'T DRIVE AS AIRBAG MIGHT DEPLOY BECAUSE DASH HAS DASH DEBRIS FROM CRACKS" PLUS HEARING "REFUSE TO SERVICE UNLESS REPLACE THE DASHBOARD" ALL THESE QUOTES WHEN TRYING TO TAKE TO GET THE TRUCK FIXED. MAIN COMPUTER HARNESS…
Jul 23, 2010 · 100,000 miles

Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.

NHTSA defect investigations

OVERSENSITIVE STEERINGClosed
ODI has received 14 consumer complaints concerning steering control concerns.Complainants typically alleged that the steering is loose, oversensitive, or has excessive play.They further alleged that this phenomena contributes to the vehicle wondering back and forth and being difficult to maintain in its lane.The majority of the complaints are on vehicles which are equipped with the V-10 or diesel engine.A preliminary evaluation will be conducted to assess the safety aspects of this matter.
PE99069 · opened Nov 8, 1999 · closed Mar 27, 2000