Model year record

1995 Ford Aerostar recalls & problems

The 1995 Ford Aerostar has 7 safety recalls and 157 owner complaints on file with NHTSA. The most-reported problem area is electrical system (41 complaints).

Recalls7safety recalls

Complaints157filed by owners

Crashes · fires16 · 18reported in complaints

Injuries · deaths19 · 0reported in complaints

Safety recalls

Service brakes, hydraulicMar 13, 2006

Service brakes, hydraulic

Recall 06E0220007,440 vehicles

Problem: CERTAIN AFTERMARKET BRAKE HYDRAULIC MASTER CYLINDERS SOLD AS REPLACEMENT BRAKE CYLINDERS FOR CERTAIN FORD, DAIMLERCHRYSLER, AND JEEP PASSENGER VEHICLES. THESE BRAKE CYLINDERS WERE SOLD UNDER THE BRAND NAMES OF NAPA, RAYBESTOS, AIMCO, AC DELCO, CARQUEST, BENDIX, AND WAGNER. ONLY PRODUCTS THAT WERE MANUFACTURED FROM JULY 27, 2005 THROUGH JANUARY 17, 2006 (DATE CODES 0529 THROUGH 0602) ARE SUBJECT TO THIS RECALL. WHEN SUBJECT TO VERY COLD TEMPERATURES, AN INTERNAL SEAL IN THE MASTER CYLINDER COULD LOSE FLEXIBILITY AND MAY CAUSE BRAKE FLUID TO LEAK.
Risk: LOSS OF BRAKE FLUID CAN LEAD TO A DECREASE IN BRAKE LINE PRESSURE AND AN INCREASE IN STOPPING DISTANCE, WHICH CAN RESULT IN A VEHICLE CRASH.
Fix: AFFINIA (BRAKE PARTS, INC.) WILL REPLACE THE SUBJECT BRAKE HYDRAULIC MASTER CYLINDERS FREE OF CHARGE. THE RECALL BEGAN ON MARCH 20, 2006. OWNERS CAN CONTACT AFFINA GROUP CUSTOMER SERVICE AT 1-800-323-0354.

Electrical systemFeb 9, 1999

Wiring › Front underhood

Recall 99V02800023,097 vehiclesopened after NHTSA action (ODI)

Problem: VEHICLE DESCRIPTION: MINI VANS. HEAT GENERATION IN THE WIRING HARNESS TO THE FUEL PUMP/SENDER ASSEMBLY CAN CAUSE AN ELECTRICAL SHORT. THE VEHICLE COULD EXPERIENCE A LOSS OF POWER AND BECOME IMMOBILIZED AND THE FUEL GAUGE MAY BE ERRATIC.
Risk: HEAT DAMAGE, INCLUDING MELTING OR CHARRING OF THE FUEL PUMP AND SENDER ASSEMBLY WIRE HARNESS AND ASSOCIATED WIRING HARNESSES CAN ALSO RESULT. THE SHORT CIRCUIT COULD ALSO HAVE THE POTENTIAL FOR A VEHICLE FIRE.
Fix: DEALERS WILL INSTALL A FUSED JUMPER HARNESS IN THE FUEL PUMP GROUND CIRCUIT THAT WILL BE INSTALLED AT THE FUEL PUMP INERTIA SHUT-OFF SWITCH.

Electrical systemFeb 9, 1999

Ignition › Switch

Recall 99V029000762,201 vehiclesopened after NHTSA action (ODI)

Problem: VEHICLE DESCRIPTION: MINI VANS. THESE VEHICLES WERE PRODUCED WITH A HIGHER THAN SPECIFIED ELECTRICAL LOAD THROUGH THE ACCESSORY POWER FEED CIRCUIT. THE POTENTIAL FOR CONTACT BETWEEN THE B2 (BATTERY), A2 (ACCESSORY), AND P1 (PROOF) CIRCUITS CAN OCCUR, CREATING A SHORT CIRCUIT, ALLOWING CURRENT TO FLOW THROUGH THE GROUND WIRE.
Risk: THIS CAN CAUSE OVER HEATING AND THE POTENTIAL FOR A VEHICLE FIRE.
Fix: DEALERS WILL INSTALL A JUMPER HARNESS WITH A RELAY WHICH WILL RE-ROUTE AND ACTIVATE ALL A2 ACCESSORIES THROUGH THE RELAY.

Service brakes, airApr 8, 1998

Disc › Rotor

Recall 98E01000023,500 vehicles

Problem: EQUIPMENT DESCRIPTION: AFTERMARKET BRAKE ROTORS FOR USE ON CERTAIN FORD AND MAZDA TRUCKS. CRACKED CASTINGS CAUSED CRACKS TO APPEAR ON THE OUTER DIAMETER OF THE ROTOR HAT OR AROUND THE STUD HOLE.
Risk: LOSS OF BRAKING CAN RESULT.
Fix: AIMCO WILL REIMBURSE CONSUMERS/INSTALLERS FOR THE COST OF REPLACEMENT ROTORS AND INSTALLATION. CONSUMERS ARE REQUESTED TO RETURN TO THE LOCATION WHERE THE ROTORS WERE ORIGINALLY PURCHASED/INSTALLED FOR REPLACEMENT.

Power trainNov 13, 1997

Transfer case (4-wheel drive)

Recall 97V20400075,000 vehicles

Problem: VEHICLE DESCRIPTION: ALL WHEEL DRIVE PASSENGER MINIVANS. THESE VEHICLES CAN DEVELOP POWERTRAIN BENDING RESONANCE OR TRANSFER CASE OUTPUT SHAFT BUSHING DISPLACEMENT. THE POWERTRAIN BENDING RESONANCE OR THE OUTPUT SHAFT BUSHING DISPLACEMENT CAN RESULT IN STRUCTURAL FAILURE OF THE TRANSMISSION AND/OR TRANSFER CASE. FLUID EXPLUSION, DRIVESHAFT SEPARATION OR LOSS OF VEHICLE DRIVE CAN RESULT.
Risk: THIS CONDITION CAN CAUSE A LOSS OF VEHICLE CONTROL, AND, IF THE EXPELLED FLUID CONTACTS THE EXHAUST SYSTEM, A VEHICLE FIRE COULD OCCUR.
Fix: DEALERS WILL INSTALL A NEW TRANSFER CASE REAR OUTPUT SHAFT BUSHING AND AN ALUMINUM DRIVESHAFT WILL BE INSTALLED.

EquipmentFeb 28, 1995

Other › Labels

Recall 95V03700012,000 vehicles

Problem: THE CERTIFICATION LABEL ON THESE VEHICLES HAVE INCORRECT REAR TIRE SIZES LISTED. P215/70R14SL SHOULD BE P215/75R14SL. THIS DOES NOT COMPLY WITH FMVSS NO. 120, "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS."
Risk: CONSEQUENCE OF NON-COMPLIANCE: THE INCORRECTLY SIZED REAR TIRE WOULD NOT HAVE SUFFICIENT LOAD CAPACITY FOR THE VEHICLE'S SPECIFIED GROSS AXLE WEIGHT RATING, INCREASING THE POTENTIAL FOR PREMATURE TIRE FAILURE.
Fix: OWNERS WILL BE MAILED A SUPPLEMENTARY LABEL CONTAINING THE CORRECT REAR TIRE INFORMATION AND INSTRUCTIONS FOR INSTALLING THE LABEL ON THEIR VEHICLES. IF OWNERS PREFER, THEIR DEALER CAN INSTALL THE LABEL FOR THEM.

EquipmentDec 1, 1994

Mechanical › Carrier/rack

Recall 94V2390009,400 vehicles

Problem: THE SPARE TIRE SUPPLIED WITH THE VEHICLE CAN CONTACT THE BRAKE LINES ON THE REAR AXLE IF IT IS MOUNTED IN THE UNDERBODY SPARE TIRE CARRIER. SUCH CONTACT COULD RESULT IN FRACTURE OF A REAR BRAKE LINE.
Risk: THIS CAN RESULT IN REDUCED VEHICLE BRAKE CAPABILITY.
Fix: DEALERS WILL INSTALL A LOWER PROFILE MINI-SPARE TIRE ON THE EXISTING MINI-SPARE WHEEL. THE NEW TIRE WILL ALLOW THE MINI-SPARE TO BE INSTALLED WITH APPROPRIATE CLEARANCES IN THE UNDERBODY SPARE TIRE CARRIER.

Recall repairs are free at any authorised dealer. A recall listed here may already have been fixed on a particular car: enter its 17-character VIN at nhtsa.gov/recalls to see open recalls.

Crash test ratings

1995 Ford Aerostar

OverallNot Rated

Frontal crash	Not Rated
Side crash	Not Rated
Rollover	Not Rated

NHTSA 5-Star Safety Ratings (New Car Assessment Program). Ratings are comparable only between vehicles of similar size and weight, and ratings from 2011 on use tougher tests than earlier years. Photos: NHTSA.

Fuel economy

Aerostar Van

18mpg combined

City / highway	16 / 22 mpg
Fuel	Regular Gasoline

3 L · 6 cyl · Automatic 4-spd · Rear-Wheel Drive · about $3,700/year to fuel

Aerostar Wagon

18mpg combined

City / highway	15 / 22 mpg
Fuel	Regular Gasoline

3 L · 6 cyl · Automatic 4-spd · Rear-Wheel Drive · about $3,700/year to fuel

Aerostar Wagon

17mpg combined

City / highway	15 / 20 mpg
Fuel	Regular Gasoline

4 L · 6 cyl · Automatic 4-spd · Rear-Wheel Drive · about $3,950/year to fuel

Aerostar Wagon AWD

15mpg combined

City / highway	14 / 18 mpg
Fuel	Regular Gasoline

4 L · 6 cyl · Automatic 4-spd · 4-Wheel or All-Wheel Drive · about $4,450/year to fuel

EPA estimates from fueleconomy.gov for each engine and transmission sold. Annual cost is the EPA's estimate for 15,000 miles a year at its current fuel and electricity price assumptions. Your results will vary.

What owners report

Problem area	Complaints	Crashes	Fires	Injuries	Typical mileage*
Electrical systemIgnition › Switch; Ignition	41	0	14	2	150,000 mi
Power trainAutomatic transmission; Automatic transmission › Lever and linkage › Column shift	26	0	2	0	—
Service brakes, hydraulicAntilock/traction control/electronic limited slip; Foundation components › Disc › Rotor	20	3	0	1	—
Air bagsFrontal	11	10	0	10	—
Engine and engine coolingEngine; Exhaust system	11	0	1	0	—
StructureBody › Door; Body	10	0	0	1	—
VisibilityDefroster/defogger/hvac system › Windshield › Electrical heating element; Power window devices and controls	10	0	2	1	—
TiresTread/belt; Temporary/emergency spare tire	8	0	0	0	103,000 mi
Latches/locks/linkagesDoors › Latch; Hatchback/liftgate › Lock	8	0	0	0	—
Exterior lightingHeadlights › Switch; Brake lights	8	0	0	0	—
Fuel system, gasolineStorage › Tank assembly; Delivery	7	0	0	0	—
SteeringSteering wheel/handle bar; Hydraulic power assist › Pump	7	1	0	1	—

*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.

Recent owner complaints

Fuel/propulsion system
TL* THE CONTACT OWNS A 1995 FORD AEROSTAR. AFTER REFUELING THE VEHICLE, THE CONTACT DETECTED A STRONG FUEL ODOR AROUND THE VEHICLE. THE CONTACT DISCOVERED THAT THE FUEL TANK WAS LEAKING FUEL. IN ADDITION, THE FUEL STRAP AND THE FUEL INLET WERE CRACKED. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC WHERE IT WAS DIAGNOSED THAT THE FUEL TANK NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 165,000.
Sep 22, 2014 · 165,000 miles
Electrical system › Wiring › Front underhoodFire1 injury
TL*THE CONTACT OWNS A 1995 FORD AEROSTAR. WHILE DRIVING 20 MPH, THE VEHICLE SHUT OFF WITHOUT WARNING. THE CONTACT OPENED THE HOOD AND NOTICED THAT THE FUEL LINES WERE EXTREMELY HOT BEFORE THEY BURST INTO FLAMES. THE CONTACT SUSTAINED A BURNED RIGHT HAND. THE FIRE DEPARTMENT STATED THAT THE FUEL PUMP CAUSED THE FIRE. A POLICE REPORT WAS FILED. THE MANUFACTURER STATED THAT HIS VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER 99V028000 (ELECTRICAL SYSTEM: WIRING: FRONT UNDER HOOD). THE CURRENT AND FAILURE MILEAGES WERE 150,000.
Oct 18, 2007 · 150,000 miles
Seat belts › Rear/other › Buckle assembly
WENT TO INSTALL CAR SEAT IN THREE ROW, PASSENGER SIDE AND THE SEAT BELT CAME UNLATCHED. IT WILL NOT STAY BUCKLED AT ALL. WENT TO A DEALERSHIP AND THEY WANT TO CHARGE US OVER $100 FOR BUCKLE AND AN HOURS WORTH OF LABOR. WE ARE DUE IN 2 WEEKS WITH THIRD CHILD AND THAT IS THE ONLY SPOT LEFT IN THE VAN THAT THE CAR SEAT FITS IN. *NM
Jul 7, 2006 · 140,000 miles
Tires
AT APPROXIMATELY 12:00 AM 6/23/06, I WAS DRIVING FROM ALBANY, TX TO DALLAS, TX ON HIGHWAY 180... AND THE TREAD ON MY RIGHT REAR TIRE SEPARATED FROM THE REST OF THE TIRE. THE TIRE IS A BRIDGESTONE TURANZA. I WAS DOING BETWEEN 70 AND 75 AT THE TIME AND THE VEHICLE WAS TOTALLY OUT OF CONTROL UNTIL I WAS ABLE TO REDUCE SPEED TO ABOUT 25. INTERESTINGLY, THE REMAINING TIRE DID NOT GO FLAT. IT WAS STILL INFLATED WHEN I CAME TO A HALT. THE TREAD TORE OFF PART OF MY REAR BUMPER AND MARKED UP THE REAR SIDE PANEL OF MY VEHICLE. I HAVE TAKEN MANY PICTURES OF THE TIRE AND OF THE DAMAGE TO MY VEHICLE. THIS IS THE THIRD TIRE OF A 4 TIRE SET THAT HAS GIVEN ME PROBLEMS. THE FIRST TWO DEVELOPED RIDGES IN THE…
Jun 23, 2006 · 138,000 miles
Electrical system › Ignition
DT: THE CALLER SAID IGNITION FAILED. SHE SAID A YEAR AGO THAT THE VEHICLE STARTED BY ITSELF WITHOUT A KEY. SHE STATED THAT CURRENTLY SHE HAD INTERMITTENT TROUBLE STARTING THE VEHICLE. THE LIGHTS ON THE DASHBOARD WILL COME ON BUT THE VEHICLE WILL NOT START. DEALER SAID VEHICLE WAS NOT RECALLED. THEY WILL NOT HELP HER FOR FREE. MANUFACTURER HAS NOT BEEN CONTACTED YET. *AK *NM
Sep 5, 2005 · 111,000 miles
Engine and engine coolingFire
THE VEHICLE WAS PARKED IN THE OFFICE PARKING LOT. SUDDENLY A CUSTOMER NOTIFIED THE CONSUMER THAT THERE WAS A VEHICLE FIRE. THE FIRE DEPARTMENT EXTINGUISHED THE FIRE. THE MANUFACTURE WILL MAKE CONTACT WITH THE CONSUMER FOR INSPECTION. *NM *NM
Feb 23, 2005 · 125,000 miles
Electrical system › Wiring › Interior/under dashFire
THE INTERIOR OF THE DASH BOARD CAUGHT FIRE ON ITS OWN, WHILE THE VEHICLE WAS PARKED. MANUFACTURER WILL BE CONTACTED BY CONSUMER. *NM
Feb 23, 2005
Electrical system › Ignition › Switch
CONSUMER ATTEMPTED TO GET THE VEHICLE RECALL 99V029000 REPAIRED. HOWEVER, THE DEALER KEPT GIVING THE CONSUMER EXCUSES WHY THEY COULD NOT FIX THE IGNITION SWITCH. *AK *SC *JB
Apr 10, 2004 · 151,000 miles

Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.

NHTSA defect investigations

TRANSFER CASES AND REAR DRIVE SHAFTClosedLed to recall 99V094000
There is no summary currently available
EA99002 · opened Jan 7, 1999 · closed Nov 14, 2000
TRANSFER CASES AND REAR DRIVESHAFTClosedLed to recall 97V204000
There is no summary currently available
RQ98012 · opened Jul 31, 1998 · closed Jan 7, 1999
FUEL SENDER ASSEMBLY FIRESClosedLed to recall 99V028000
There is no summary currently available
EA98016 · opened Jul 14, 1998 · closed Feb 12, 1999