Model year record

1993 Ford F-250 recalls & problems

The 1993 Ford F-250 has 7 safety recalls and 130 owner complaints on file with NHTSA. The most-reported problem area is fuel system, gasoline (42 complaints).

Recalls7safety recalls

Complaints130filed by owners

Crashes · fires5 · 4reported in complaints

Injuries · deaths4 · 0reported in complaints

Safety recalls

Vehicle speed controlFeb 4, 2008

Cruise control

Recall 08V051000225,000 vehicles

Problem: FORD IS RECALLING 225,000 MY 1992-2003 ECONOLINE, MY 1993-1995 TAURUS SHO, MY 1992-1998 CROWN VICTORIA, MY 1993 BRONCO, F-SERIES, MY 1995-1997 F-SERIES SUPER DUTY STRIPPED CHASSIS, MY 1992-1998 MERCURY GRAND MARQUIS, AND MY 1992-1995 LINCOLN TOWN CAR VEHICLES. THE AFFECTED VEHICLES WERE PREVIOUSLY REPAIRED USING A WIRING HARNESS THAT IS NOT COMPATIBLE WITH THE VEHICLE CIRCUIT POLARITY.
Risk: AS A RESULT, THE FUSE IS LOCATED IN THE OUTPUT CIRCUIT RATHER THAN IN THE INTENDED INPUT POWER FEED CIRCUIT, AND MAY NOT OFFER THE INTENDED PROTECTION IN THE EVENT OF AN ELECTRICAL SHORT TO GROUND.
Fix: DEALERS WILL INSTALL A NEW WIRING HARNESS, OR REPLACE THE MATING ELECTRICAL COMPONENT. THE RECALL BEGAN ON FEBRUARY 18, 2008. OWNERS MAY CONTACT FORD AT 1-800-392-3673.

Vehicle speed controlAug 3, 2007

Vehicle speed control

Recall 07V3360003,600,000 vehiclesopened after NHTSA action (ODI)

Problem: ON CERTAIN PICKUP TRUCKS, PASSENGER VEHICLES, SPORT UTILITY VEHICLES, AND MOTOR HOMES CHASSIS, THE SPEED CONTROL DEACTIVATION SWITCH MAY, UNDER CERTAIN CONDITIONS, LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
Risk: THIS COULD RESULT IN AN UNDERHOOD FIRE.
Fix: DEALERS WILL INSTALL A FUSED WIRING HARNESS. OWNERS OF THE PASSENGER CARS INCLUDED IN THIS CAMPAIGN WILL BE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED AS AN INTERIM REPAIR. AS SOON AS REPAIR PARTS ARE AVAILABLE (EXPECTED OCTOBER 2007), OWNERS WILL BE INSTRUCTED TO RETURN TO THE DEALERS FOR INSTALLATION OF A FUSED WIRING HARNESS. THE RECALL BEGAN ON AUGUST 13, 2007, AND MAILING COMPLETED BY SEPTEMBER 19, 2007. OWNERS MAY CONTACT FORD AT 1-888-222-2751.

Exterior lightingMay 24, 2006

Exterior lighting

Recall 06E04900027,176 vehiclesopened after NHTSA action (OVSC)

Problem: CERTAIN CK MOTORSPORTS COMBINATION HEADLIGHTS, CLEAR CORNER, BUMPER, AND SIDE MARKER LIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON THE PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Risk: WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Fix: CK MOTORSPORT WILL NOTIFY OWNERS AND REPLACE THE NONCOMPLIANT LAMPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 1, 2006. OWNERS MAY CONTACT CK MOTORSPORT AT 1-909-610-7211.

Fuel system, gasolineDec 29, 2000

Storage › Tank assembly

Recall 00V424000275,000 vehiclesopened after NHTSA action (ODI)

Problem: VEHICLE DESCRIPTION: LIGHT DUTY TRUCKS AND CAB CHASSIS EQUIPPED WITH GASOLINE ENGINES AND DUAL FUEL TANKS. THE CARBON STEEL FUEL PRESSURE REGULATOR IN THE FUEL SYSTEM CAN WEAR OUT DURING THE LIFE OF THE VEHICLE. IF THE FUEL PRESSURE REGULATOR MALFUNCTIONS, IT CAN CAUSE HIGH FUEL SYSTEM PRESSURE, WHICH DAMAGES THE FUEL PUMP CHECK VALVE. THIS ALLOWS FUEL TO BE TRANSFERRED FROM ONE TANK TO THE OTHER, POSSIBLY OVERFILLING THE NON-OPERATING TANK, RESULTING IN FUEL OVERFLOW PAST THE FILLER CAP.
Risk: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A VEHICLE FIRE.
Fix: DEALERS WILL HAVE A STAINLESS STEEL FUEL PRESSURE REGULATOR INSTALLED. OWNER NOTIFICATION BEGAN JULY 9, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332. (SEE PREVIOUS NHTSA RECALL 93V-125/FORD RECALL 93S68).

Parking brakeSep 7, 1994

Conventional

Recall 94V169001835,791 vehiclesopened after NHTSA action (ODI)

Problem: THE PARKING BRAKE CONTROL SELF-ADJUST PAWL DOES NOT LINE UP PROPERLY WITH THE SELF-ADJUST RACHET CAUSING THE PAWL TO SLIP OVER ONE OR MORE TEETH IN THE RACHET.
Risk: WHEN THE ABOVE OCCURS, IT CAN RESULT IN PARKING BRAKE SYSTEM INEFFECTIVENESS. THE PARKING BRAKE WILL NOT HOLD THE VEHICLE, CAUSING THE VEHICLE TO ROLL FREELY, IF THE TRANSMISSION IS NOT LEFT IN GEAR.
Fix: A WEDGE WILL BE INSTALLED WHICH WILL SERVE TO LOCK THE PARKING BRAKE SELF-ADJUST MECHANISM PAWL INTO ENGAGEMENT WITH THE RACHET. ALSO, OWNERS WILL BE ADVISED TO RELEASE AND REAPPLY THE PARKING BRAKE WHENEVER TOOTH SKIP OCCURS AND WILL BE REMINDED TO ALWAYS TURN OFF THE ENGINE AND LEAVE THE VEHICLE IN GEAR WHEN THE VEHICLE IS PARKED.

StructureJan 2, 1994

Body › Bumpers

Recall 94V018000370,000 vehicles

Problem: THE U-CLIP STYLE NUTS THAT RETAIN THE FRONT BUMPERS TO THE FRONT BUMPER INNER ARMS CAN FRACTURE.
Risk: IF ONE OF THE U-CLIP NUTS FRACTURES, THE BUMPER WILL LOOSEN AND RATTLE CAUSING FRACTURE OF THE REMAINING U-CLIP NUTS, RESULTING IN SEPARATION OF THE BUMPER FROM THE VEHICLE. IF THE BUMPER WERE TO DETACH FROM THE VEHICLE WHILE IT IS BEING DRIVEN, A VEHICLE COLLISION COULD RESULT.
Fix: INSPECTION AND REPLACEMENT OF THE FOUR U-CLIP NUTS AND THE ASSOCIATED BOLTS.

Fuel system, gasolineAug 2, 1993

Storage › Tank assembly

Recall 93V1250001,131,000 vehiclesopened after NHTSA action (ODI)

Problem: A MALFUNCTIONING CHECK VALVE WITHIN THE FUEL PUMP ASSEMBLY CAUSES A PORTION OF THE UNUSED FUEL FROM ONE TANK TO BE RETURNED TO THE SECOND TANK. WHEN THIS OCCURS, THE CAPACITY OF THE SECOND TANK CAN BE EXCEEDED, CAUSING FUEL SPILLAGE.
Risk: SPILLED FUEL CAN RESULT IN A FIRE WHEN EXPOSED TO ASOURCE OF IGNITION.
Fix: REPLACEMENT OF THE FUEL PRESSURE REGULATOR AND INSTALLATION OF REDUNDANT CHECK VALVES.

Recall repairs are free at any authorised dealer. A recall listed here may already have been fixed on a particular car: enter its 17-character VIN at nhtsa.gov/recalls to see open recalls.

Fuel economy

F250 Pickup 2WD

15mpg combined

City / highway	14 / 18 mpg
Fuel	Regular Gasoline

4.9 L · 6 cyl · Automatic 4-spd · Rear-Wheel Drive · about $4,450/year to fuel

F250 Pickup 2WD

15mpg combined

City / highway	15 / 17 mpg
Fuel	Regular Gasoline

4.9 L · 6 cyl · Manual 4-spd · Rear-Wheel Drive · about $4,450/year to fuel

F250 Pickup 2WD

15mpg combined

City / highway	14 / 18 mpg
Fuel	Regular Gasoline

4.9 L · 6 cyl · Manual 5-spd · Rear-Wheel Drive · about $4,450/year to fuel

F250 Pickup 2WD

15mpg combined

City / highway	14 / 18 mpg
Fuel	Regular Gasoline

5 L · 8 cyl · Manual 5-spd · Rear-Wheel Drive · about $4,450/year to fuel

F250 Pickup 2WD

14mpg combined

City / highway	13 / 17 mpg
Fuel	Regular Gasoline

5 L · 8 cyl · Automatic 4-spd · Rear-Wheel Drive · about $4,800/year to fuel

F250 Pickup 2WD

14mpg combined

City / highway	13 / 15 mpg
Fuel	Regular Gasoline

5 L · 8 cyl · Manual 4-spd · Rear-Wheel Drive · about $4,800/year to fuel

F250 Pickup 2WD

12mpg combined

City / highway	11 / 15 mpg
Fuel	Regular Gasoline

5.8 L · 8 cyl · Automatic 4-spd · Rear-Wheel Drive · about $5,600/year to fuel

EPA estimates from fueleconomy.gov for each engine and transmission sold. Annual cost is the EPA's estimate for 15,000 miles a year at its current fuel and electricity price assumptions. Your results will vary.

What owners report

Problem area	Complaints	Crashes	Fires	Injuries	Typical mileage*
Fuel system, gasolineStorage › Tank assembly; Storage › Auxillary tank › Selector devices	42	0	0	2	—
Service brakes, hydraulicAntilock/traction control/electronic limited slip; Foundation components › Disc › Rotor	34	2	1	0	—
Engine and engine coolingEngine › Gasoline › Belts and associated pulleys; Engine	32	0	0	0	—
Power trainAutomatic transmission; Clutch assembly	20	1	1	2	—
SteeringHydraulic power assist › Pump; Steering wheel/handle bar	11	0	0	0	—
Vehicle speed controlAccelerator pedal; Cruise control	8	0	0	0	—
Electrical systemIgnition › Switch; Ignition	8	0	2	0	—
SuspensionFront; Front › Wheel bearing	7	0	0	0	—
Tires	4	0	0	0	—
EquipmentAppliance › Air conditioner	3	0	0	0	—
Exterior lightingTurn signal	2	0	0	0	—
Seat beltsFront › Anchorage; Front › Buckle assembly	2	1	0	1	—

*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.

Recent owner complaints

Fuel/propulsion system
TL* THE CONTACT OWNS A 1993 FORD F-250. WHILE THE CONTACT WAS FUELING THE VEHICLE, THE FUEL CAP SHRANK AND FUEL SPEWED FROM THE FUEL TANK. THE FAILURE OCCURRED WHENEVER HE ATTEMPTED TO FUEL THE FRONT TANK FIRST. AS THE FUEL TRAVELED TO THE REAR TANK, IT SPEWED OUT. THE CONTACT STATED THAT THE FAILURE WAS A FIRE HAZARD. THE CONTACT DROVE THE VEHICLE TO FUTURE FORD OF ROSEVILLE (650 AUTOMALL DR, ROSEVILLE, CA 95661, (888) 656-7577), BUT THE MECHANICS REFUSED TO SERVICE THE VEHICLE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 250,000.
Aug 10, 2010 · 250,000 miles
Vehicle speed control › Cruise control
TL* THE CONTACT OWNS A 1993 FORD F-250. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 55 MPH, HE NOTICED THAT THE SPEEDOMETER AND CRUISE CONTROL FAILED TO OPERATE. IN ADDITION, THE ABS WARNING INDICATOR ILLUMINATED ON THE INSTRUMENT PANEL. THE WARNING LIGHT REMAINED ILLUMINATED UNTIL THE ENGINE WAS TURNED OFF. THERE WAS A RECALL UNDER NHTSA CAMPAIGN ID NUMBER 8V051000 (VEHICLE SPEED CONTROL:CRUISE CONTROL) HOWEVER THE VIN WAS NOT INCLUDED. THE CONTACT EXPERIENCED THE SIMILAR DEFECT AS MENTIONED IN THE RECALL. THE VEHICLE WAS REPAIRED AT THE CONTACT'S EXPENSE. THE MANUFACTURER WAS MADE AWARE OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 145,000. UPDATED 10/17/12*LJ THE CONSUMER…
Sep 6, 2011 · 145,000 miles
Tires
TL* THE CONTACT OWNS A 1993 FORD F-250 EQUIPPED WITH COOPER DEAN MUD TERRAIN RADIAL SXT TIRES, SIZE 285/75/16. THE CONTACT STATED THAT THERE WERE BLISTERS BETWEEN THE LUGS. THE FRONT PASSENGER TIRE HAD WIRES PROTRUDING, WHICH WAS CAUSING TREAD SEPARATION. THE MANUFACTURER ADVISED THE CONTACT THAT THE TIRES WERE NOT INCLUDED IN NHTSA RECALL NUMBER: 06T003000(TIRES:TREAD/BELT). THE CURRENT AND FAILURE MILEAGES WERE 234,242.
Sep 20, 2011 · 234,242 miles
Fuel system, gasoline › Storage › Tank assembly
THIS IS ABOUT A FUEL TANK DELIVERY AND AIR INDUCTION BULLETIN, CROSS TANK FUEL FLOW PROBLEM MY FORD F250 TRUCK IS HAVING. I HAVE NOTIFIED MY LOCAL DEALERSHIP AND FORD CUSTOMER SERVICE, THEY BOTH SAY THERE IS NO RECALL FOR THIS VEHICLE. BUT I FOUND A NHTSA CAMPAIGN # 93V12500 DESCRIBING EXACTLY WHAT HAS BEEN HAPPENING FOR THE LAST 6 MONTHS. IT NEEDS TO BE FIXED AND IS EXPENSIVE, BUT I CAN'T GET ANY SATISFACTION FROM FORD, I'M HOPING YOU CAN HELP. *TR UPDATED 04/15/10.*JB
Aug 12, 2009 · 295,251 miles
Steering
TL*THE CONTACT OWNS 1993 FORD F-250. WHILE DRIVING 60 MPH THE VEHICLE STARTED TO 'SHIMMY" VIOLENTLY. THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION. AFTER 4 DAYS THE TECHNICIAN CONCLUDED THAT THE TIRE PRESSURE WAS HIGH; HOWEVER, HE SPECULATED THAT THE TIRES WERE NOT THE CAUSE OF THE FAILURE. THERE ARE NUMEROUS COMPLAINTS REGARDING THE "SHIMMY" ON SEVERAK YEAR, MAKE, AND MODELS, OF THE F-SERIES. THE CURRENT AND FAILURE MILEAGE WAS 61,000.
Sep 2, 1993 · 61,000 miles
Tires
TIRE WENT FLAT FOR NO REASON ONLY HAD 2000 MILES ON THEM NOW THEY SAY THEY DON'T MAKE THEM ANYMORE SO I CANT GET ONE TO MATCH CAN NOT DRIVE FORD F 250 TILL I FIND ONE. TIRE WAS A DAYTON A BAJA A/T WIDETRACK 33/1250/16.5 *TR
Apr 15, 2008
Vehicle speed control › Cruise control
TL*THE CONTACT OWNS A 1993 FORD F250. THE VEHICLE WAS TAKEN TO THE DEALER FOR THE RECALL REPAIR REGARDING THE VEHICLE SPEED CONTROL: CRUISE CONTROL. THE DEALER DISCONNECTED THE CRUISE CONTROL ON OCTOBER 17, 2007 AND INFORMED THE CONTACT THAT THE REPLACEMENT PART WAS NOT YET AVAILABLE. THERE HAD BEEN NO FAILURE TO DATE. THE RECALL NUMBER AND PURCHASE DATE WERE UNKNOWN. THE CURRENT MILEAGE WAS 180,000.
Oct 17, 1993
Electrical system
FORD MOTOR COMPANY IS BEING NON-RESPONSIVE TO A RECALL NOTICE (08S01) THAT THEY HAVE SENT OUT. THEIR REPRESENTATIVE DEALERS ARE NOT BEING SUPPLIED PARTS TO MAKE THE REPAIR AND FORD MOTOR COMPANY REFUSES TO SAY WHEN THE PART WILL BE MADE AVAILABLE. *TR
Feb 15, 2008 · 93,000 miles

Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.

NHTSA defect investigations

DUAL FUEL TANK CROSSFLOW/LEAKAGEClosedLed to recall 00V424000
ON JULY 14, 1993 FORD FILED A DEFECT INFORMATION REPORT CONCERNING FUEL TANK CROSS FLOW LEAKAGE ON F-SERIES LIGHT TRUCKS AND CAB CHASSIS BUILT FROM JULY 22, 1989 THROUGH DECEMBER 17, 1992.THE REMEDY WAS TO REPLACE THE FUEL PRESSURE REGULATOR AND INSTALL A CHECK VALVE BETWEEN EACH FUEL SUPPLY LINE AND FUEL TANK (2) TO REPAIR THE SUPPLY SIDE FUEL CROSS FLOW PROBLEM (RECALL 93V-125).ODI OPENED RQ98-008 ON MAY 29, 1998 BECAUSE OF THE LARGE NUMBER OF ALLEGED REMEDY FAILURES AND REPORTS OF FUEL CROSS FLOW ON VEHICLES OUTSIDE OF THE RECALL POPULATION.BASED ONTHE INFORMATION RECEIVED FROM FORD ON AUGUST 11, SEPTEMBER 30, AND DECEMBER 15, 1998, AND THE INCREASING TREND OF REMEDY FAILURES AND OUT OF SCOPE CROSSFLOW REPORTS, ODI OPENED EA99-032 ON NOVEMBER 4, 1999.THE ATTACHED ENGINEERING ANALYSIS CLOSING REPORT FULLY DESCRIBES THE RESULTS OF THIS INVESTIGATION AND REASON FOR CLOSING.THE SUBJECT…
EA99032 · opened Nov 4, 1999 · closed Dec 6, 2001
FAILURE OF SERPENTINE BELTClosedLed to recall 96I003001
AN ENGINEERING ANALYSIS CLOSING REPORT IS INCLUDED.
EA95012 · opened Mar 31, 1995 · closed May 28, 1996
PARKING BRAKE FAILUREClosedLed to recall 94V169001
There is no summary currently available
EA93020 · opened Jul 28, 1993 · closed Sep 23, 1994