Problem: Ford Motor Company (Ford) is recalling certain 2018 Ford F53 stripped chassis vehicles equipped with 22.5 inch front wheels. The front wheel hub assembly may have wheel studs that were not properly heat treated.
Risk: If a sufficient quantity of wheel studs break on one hub, vehicle handling could be affected, increasing the risk of a crash.
Fix: Ford will notify owners, and dealers will replace any suspect front wheel hub studs, free of charge. The recall began August 20, 2018. Owners may contact Ford customers service at 1-866-436-7332. Ford's number for this recall is 18S21.
Recall repairs are free at any authorised dealer. A recall listed here may already have been fixed on a particular car: enter its 17-character VIN at nhtsa.gov/recalls to see open recalls.
What owners report
Problem area
Complaints
Crashes
Fires
Injuries
Typical mileage*
Structure Body
5
0
1
1
9,000 mi
Electrical system
2
0
1
1
—
Parking brake
1
0
0
0
—
Steering
1
0
0
0
—
Wheels
1
0
0
0
—
Seat belts
1
0
0
0
—
Back over prevention
1
0
0
0
—
Power train
1
0
0
0
—
Suspension
1
0
0
0
—
*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.
Recent owner complaints
Oct 31, 2022 · 9,000 milesStructure The contact owns a 2019 Thor Motor coach Windsport built on a 2018 Ford F-53 Chassis. The contact stated that while she was cleaning the RV, she noticed that the metal screws that maintained the overhead unit of the driving compartment attached to the ceiling were pulling out. However, the brackets installed on each side of the overhead unit prevented it from falling. An independent RV mechanic diagnosed that the failure was due to metal screws being installed on the wooden surface. The independent mechanic informed the contact that brackets needed to be installed to maintain the overhead unit into position. The RV was not repaired. The dealer was not notified of the failure. The…
Jul 8, 2021 · 7,376 milesStructure › Body The contact owns a 2019 Jayco Alante manufactured on a 2015 Ford F53 chassis. The contact stated while driving 28 mph, the front grill detached from the RV inadvertently. The contact took the RV to the local dealer, where it was diagnosed with needing the grill to be replaced however, the dealer did not provide the service at their location. The dealer referred the contact to a body shop for the repair. The RV was not yet repaired. The manufacturer had not been informed of the failure. The failure mileage was approximately 7,376.
Oct 12, 2020 · 75,000 miles · fire · 1 injuryStructure › Body TL* THE CONTACT OWNS A 2018 FORD F53. THE CONTACT STATED WHILE THE VEHICLE WAS STATIONARY, THE ROOF STARTED TO LEAK CAUSING WATER TO GET INSIDE OF THE VEHICLE. THE CONTACT ALSO STATED THAT THE INVERTER UNIT SHORTED OUT AND CAUGHT ON FIRE. THE CONTACT WAS ABLE TO EXTINGUISH THE FIRE WITH A FIRE EXTINGUISHER. THE FIRE OR POLICE DEPARTMENT WAS NOT NOTIFIED. THE CONTACT STATED THAT THE FLOOR HEATING UNITS AND WOULD OCCASIONALLY OVERHEAT BURNING THE CONTACTS FEET. THE CONTACT SUSTAINED A SORE FOOT BUT NO MEDICAL ATTENTION WAS REQUIRED. THE CONTACT STATED NO WARNING LIGHT WAS ILLUMINATED. THE VEHICLE WAS NOT TAKEN TO A LOCAL DEALER OR AN INDEPENDENT MECHANIC TO HAVE IT DIAGNOSED. THE VEHICLE HAD…
Oct 28, 2020Power train TRANSMISSION FAILED AT 54000 MILES DUE TO INTERNAL DEFECTIVE PART. THE VEHICLE STARTED TO JUMP ON SHIFTING FROM 1 ST GEAR TO 2 ND .
Jan 1, 2020 · 3,000 milesBack over prevention TL* THE CONTACT OWNS A 2018 FORD F-53 RV. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE BACK-UP CAMERA DETACHED AND BECAME INOPERABLE. THERE WERE NO WARNING LIGHTS ILLUMINATED. THE VEHICLE WAS TAKEN TO APPLETON CAMPING CENTER (2100 N MCCARTHY RD, APPLETON, WI 54913, (920) 757-6112) TO BE DIAGNOSED. THE CONTACT WAS INFORMED OF A LOOSENED ELECTRICAL WIRE. THE VEHICLE WAS REPAIRED HOWEVER, THE FAILURE RECURRED. THE MANUFACTURER WAS NOT CONTACTED OR NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 3,000.*DT*JB
Jun 2, 2020 · 12,424 milesStructure › Body MAIN DOOR HATCH PLUNGER BROKE ON TRIMARK 72130 DOOR HATCH /DEAD BOLT , LOCKING US OUT. IF WE HAD BEEN INSIDE WE WOULD HAVE BEEN TRAPPED INSIDE. THE VEHICLE WAS PARKED AT THE TIME. HAD TO FIND A LADDER A CLIMB THRU WINDOW AND AFTER A COUPLE HOURS WERE ABLE TO TAKE APART TO GET UNLATCH AND FOUND BROKEN PLUNGER/HATCH. *TR
Jun 4, 2019 · 17 milesSeat belts THE FRONT PASSENGER SHOULDER HARNESS IN MY RV IS MOUNTED SO HIGH THAT THE BELT GOES ACROSS MY WIFE'S THROAT INSTEAD OF HER CHEST. WHY IS THERE NO SAFETY STANDARD WHICH REQUIRES A SHOULDER HARNESS MOUNT TO BE ADJUSTABLE VERTICALLY TO KEEP SHORT PEOPLE SAFE?*DT
Feb 24, 2019 · 3,100 milesWheels VEHICLE SOLD AS NEW TO ME BY GIANT RV WITH A 15 YEAR OLD TIRE INSTALLED ON THE FRONT DRIVER SIDE. THIS WAS A MISMATCH, OFF BRAND "EXPIRED" TIRE THAT CAUSED A BLOW OUT REQUIRING REPAIRS AND CREATING AN OPPORTUNITY OF RISK. THIS WAS NOT DISCLOSED AND THE DEALER REFUSES TO TAKE OWNERSHIP OF THE ISSUE OR PROVIDER NECESSARY BACKGROUND AS TO THE CAUSE OF WHY THIS TIRE WAS IMPROPERLY REPLACED. CONCERN BEING THAT THERE MAY HAVE BEEN A NON DISCLOSED VEHICLE EVENT (ACCIDENT ETC.) THAT CAUSED DAMAGES WHICH WERE IMPROPERLY AND UNSAFELY REPAIRED WITHOUT PROPER DISCLOSURE. CONCERN BEING THAT THERE MAY BE OTHER HIDDEN ISSUES WHICH MAY CONTINUE TO PUT MY FAMILY AT RISK. WHEN ASKED THE DEALER AND…
Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.
NHTSA defect investigations
PE20021 · opened Nov 23, 2020 · closed Dec 13, 2024Trimark 060-1650 Door Latch Failures On November 23, 2020, the Office of Defects Investigation (ODI) opened PE20021 to investigate allegations of inoperative Trimark THP 060-1650 door lock/latches originally equipped on model years (MY) 2015-2017 Class A and Class C motorhomes.ODI received forty-six Vehicle Ownerâs Questionnaires (VOQs) describing consumers being locked in or out of their vehicles.The door latch, containing a die-cast zinc plunger, was produced by Equality during calendar years 2014-2016. The die-cast may become porous and brittle over time and can break without warning, causing the vehicle owner to be unable to open the recreational vehicle door equipped with the latch.If the motorhome does not have any other doors such as some Class A models, occupants could be trapped inside, needing to climb out using the emergency exits. If locked out, owners would be unable to easily get in and retrieve children…