Model year record
2001 Ford F Series (light) recalls & problems
The 2001 Ford F Series (light) has no safety recalls on file with NHTSA, and 10 owner complaints. The most-reported problem area is engine and engine cooling (5 complaints).
Safety recalls
No safety recalls have been filed for the 2001 Ford F Series (light).
Recall repairs are free at any authorised dealer. A recall listed here may already have been fixed on a particular car: enter its 17-character VIN at nhtsa.gov/recalls to see open recalls.
What owners report
| Problem area | Complaints | Typical mileage* |
|---|---|---|
| Engine and engine coolingEngine | 5 | 116,000 mi |
| Seat beltsFront | 2 | — |
| Air bagsFrontal | 1 | — |
| Service brakes, hydraulicAntilock/traction control/electronic limited slip › Control unit/module | 1 | — |
| Engine | 1 | — |
| Electrical system | 1 | — |
*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.
Recent owner complaints
- Seat belts
WHILE SHIFTING ABOUT IN THE DRIVER'S SEAT TO BACK UP AND LOOK REARWARD TO GUIDE THE VEHICLE IN REVERSE, THE DRIVER'S SEAT BELT UNEXPECTEDLY CAME UNBUCKLED AND BEGAN TO RETRACT. I THOUGHT THAT I MUST HAVE BEEN AT FAULT AND NOT PROPERLY BUCKLED IT EVEN THOUGH THE NORMAL WARNING LITE AND SOUNDS INDICATING AN UNBUCKLED SEAT BELT WERE NOT EVIDENT. OWNERS BEGAN TO "TUG" THE BELT AFTER LATCHING IT EACH TIME TO ENSURE PROPER CLOSURE AND VERIFY BUCKLE ENGAGED. THE SAME EVENTS, USUALLY ENCOUNTERED WHILE SHIFTING POSITION IN THE DRIVER'S SEAT, HAPPENED REPEATEDLY EVEN THOUGH BUCKLES INITIAL ENGAGEMENT HAD BEEN TEST VERIFIED BY THE DRIVER EACH TIME. WE WERE OBVIOUSLY CONCERNED THAT IN ANY ACCIDENT,…
- EngineFire
2001 FORD F150 WAS SITTING OUT IN DRIVEWAY OF OWNER'S HOME. HE HAD BEEN HOME APPROX 1/2 HOURS WHEN OWNERS VEHICLE WAS ON FIRE COMING FROM THE ENGINE COMPARTMENT. NO FIRE DAMAGE TO THE INSIDE CAB OF OWNERS VEHICLE. *TR
- Engine and engine cooling
ATTEMPTED TO START A 2001 FORD F-150 SUPER CREW THAT HAS A 5.4LITER ENGINE AND ONLY 80,500 AND HEARD A BANG. ENGINE STARTED BUT MADE A LOT OF NOISE. I SHUT DOWN THE ENGINE AND CHECKED UNDER HOOD. ON THE RIGHT SIDE OF ENGINE FOUND A PLUG WIRE AND COIL DESTROYED WHICH INDICATED A SPARK PLUG EXPLODED OUT OF THE CYLINDER HEAD. REPAIR SHOP SAID DO NOT DRIVE IT AS FUEL WILL SPRAY ON HOT MANIFOLD AND WILL CAUSE A FIRE. THEY SAID I WAS LUCKY ENGINE WAS NOT HOT. THESE WERE THE FACTORY INSTALLED PLUGS AS ORIGINAL WINDOW STICKER SAYS 100K MILE TUNE-UPS. ESTIMATE OF REPAIR IS $4,000. FORD ACCRONIM APPLIES HERE "FOUND ON ROAD DEAD OR, FIX OR REPAIR DAILY." UPON INTERNET SEARCH THIS APPEARS TO BE A…
- Engine and engine cooling
I HAVE A 2001 FORD PICKUP WITH 116,000 MILES THAT I HAVE BABIED SINCE I PURCHASED IT JUST THIS WEEK I HAD A SPARK PLUG BLOW OUT OF THE HEAD, JUST SO HAPPENED I WAS 45 MILES AWAY FROM HOME, SO A WRECKER CHARGE WAS DUE, TOOK MY TRUCK TO MY USUAL REPAIR SHOP BUT THEY SAID THEY COULDN'T FIX THE PROBLEM. SO I THEN HAD TO FIND SOMEONE ELSE, ANOTHE WRECKER CHARGE. FORD MUST KNOW FROM ALL THE COMPLAINTS THAT THIS IS A BIG PROBLEM AND VERY COSTLY. FORD SHOULD RECALL ALL VEHICLES WITH ALUMINUM HEADS AND INSTALL A STEEL SLEEVE IN ALL SPARK PLUGS TO TAKE CARE OF THIS PROBLEM, THEY ARE SAVING TONS OF MONEY WITH THIS TYPE OF FAULTY ENGINE. I HAD CONSIDERED BUYING A NEW FORD PICKUP, BUT THIS JUST MIGHT…
- Engine and engine cooling › Engine
SPARK PLUG BLOWOUT FORD 4.6 ENGINE AND COIL DAMAGE. *TR
- Engine and engine cooling › Engine
# 6 SPARK PLUG BLEW OUT OF THE HOLE IN CYLINDER HEAD. *TR
- Seat belts › Front
PASSENGER SEAT BELT LOCKS FOR NO REASON WHATSOEVER. PASSENGER MUST UNLATCH BELT, LET IT GO ALL THE WAY BACK IN, THEN PUT IT BACK ON IN ORDER TO "RESET" THE LOCK. *TR
- Service brakes, hydraulic › Antilock/traction control/electronic limited slip › Control unit/module
POWER BRAKES FAILED (ABS UNIT), PEDAL IS VERY SOFT AND LOSS OF BRAKE EFFECTIVENESS TO SLOW/STOP VEHICLE SAFELY. OWNER REPLACED MASTER CYLINDER(REBUILT UNIT), BLEED BRAKES, SAME CONDITION, TOOK TO CERTIFIED MECHANIC REPLACED MASTER CYL. WITH (NEW UNIT) SAME CONDITION, VEHICLE THEN TAKEN TO DEALER FOR ABS HYDRAULIC UNIT REPLACEMENT AT COST OF OVER $800 TO THE OWNER. TOLD THERE WAS A STUCK VALVE IN ABS UNIT. VEHICLE IS 2001 WITH 68,000 MILES AT TIME OF FAILURE, VEHICLE IS UNSAFE TO BE DRIVEN AND OWNER HAS 2 SMALL CHILDREN
Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.
NHTSA defect investigations
- SPARK PLUG EJECTION FROM CYLINDER HEADClosed
ON SEPTEMBER 6, 2005, ODI RECEIVED A PETITION REQUESTING THAT THE AGENCY INVESTIGATE ALLEGATIONS OF ENGINE SPARK PLUG EJECTION IN CERTAIN MODEL YEAR 1997 THROUGH 2004 FORD VEHICLES WITH TRITON V-8 AND V-10 ENGINES.ODI RECEIVED A TOTAL OF 474 NON-DUPLICATIVE COMPLAINTS ON THE SUBJECT VEHICLES WHERE THE COMPLAINANT, OR THE DEALER REPAIRING THE VEHICLE, REPORTED THAT A SPARK PLUG DETACHED FROM THE CYLINDER AND/OR EJECTED FROM THE ENGINE.AS OF DECEMBER 8, 2005, ODI IS NOT AWARE OF ANY ALLEGATIONS WHERE THE ALLEGED DEFECT RESULTED IN A LOSS OF VEHICLE CONTROL, A CRASH, AN INJURY, OR A FATALITY IN ANY OF THE 10,319,810 SUBJECT VEHICLES.IN ADDITION, ODI IS AWARE OF ONLY TWO INCIDENTS WHERE THE VEHICLE STALLED WITHOUT RESTART.INFORMATION CONTAINED IN THE ODI CONSUMER COMPLAINTS AND OBTAINED FROM 72 TELEPHONE INTERVIEWS WITH COMPLAINANTS SHOWED THE FOLLOWING:(1) 99% OF THE COMPLAINTS WERE ON MY…
- FRONT SEAT BELT BUCKLE ASSEMBLYClosed
DURING THE INITIAL RECALL CAMPAIGN IN 2001, THE SUBJECT VEHICLES WERE INSPECTED BY FORD DEALERSHIPS USING A TEST TOOL THAT WOULD DETECT A DEFECTIVE FRONT SEAT OUTBOARD SEAT BELT BUCKLE ASSEMBLY.APPROXIMATELY ONE MILLION VEHICLES PASSED THE INSPECTION TEST FOR ONE OR BOTH FRONT BUCKLES.SUBSEQUENT TO THE RECALL SERVICE ACTION, ODI RECEIVED 15 CONSUMER REPORTS ALLEGING THAT A PASSED INSPECTION BUCKLE SUBSEQUENTLY FAILED TO LATCH OR INADVERTENTLY UNLATCHED DURING USE.IN ADDITION, FORD HAS IDENTIFIED 543 OWNER AND FIELD REPORTS ALLEGING BUCKLE FAILURE SUBSEQUENT TO PASSING THE INSPECTION TEST.FORD TESTED AND EXAMINED OVER 100 WARRANTY-RETURNED BUCKLES AND FOUND THAT 44% OF THE BUCKLES HAD NO PROBLEM OR A CONDITION NOT RELATED TO THE RECALL INSPECTION (NON-LATCH RELATED BUCKLE DAMAGE OR FOREIGN CONTAMINATION).WARRANTY CLAIMS WERE HIGHEST DURING THE 18-MONTH PERIOD AFTER THE START OF THE…
- FRONT SEAT BELT BUCKLE ASSEMBLYClosed
UNDER RECALL CAMPAIGN (01V227), FORD RECALLED APPROXIMATELY 1.3 MILLION VEHICLES TO INSPECT AND IF NECESSARY REPLACE THE FRONT DRIVER AND/OR PASSENGER SEAT BELT BUCKLE.APPROXIMATELY 1.1 MILLION OWNERS RESPONDED BY TAKING THEIR VEHICLES TO A DEALER FOR INSPECTION OF THE BUCKLE USING A SPECIALIZED BUCKLE TEST TOOL.FORD REPORTED THAT 829,927 VEHICLES HAD BOTH BUCKLES PASS THE TOOL TEST AND ANOTHER 167,336 VEHICLES HAD ONE BUCKLE PASS.ODI AND FORD RECEIVED COMPLAINTS ALLEGING SEAT BELT BUCKLE FAILURE SHORTLY AFTER PASSING THE ORIGINAL RECALL INSPECTION SERVICE.COMPLAINANTS ALLEGED THAT THE BUCKLE FAILED BY EITHER NOT LATCHING OR FALSE-LATCHING (PARTIAL ENGAGEMENT OF THE LATCH TO THE LATCH PLATE).A FALSE-LATCHED BUCKLE MAY RELEASE WITH MINOR MOVEMENT OR IMPACT AGAINST THE BUCKLE HOUSING INCLUDING INADVERTENT RELEASE WHILE THE VEHICLE IS IN MOTION.ODI IS UPGRADING THIS RECALL QUERY TO AN…