2004 Ford Freestar recalls & problems

Recent owner complaints

• Jun 26, 2025 · 104,000 milesPower train
  The contact owns a 2004 Ford Freestar. The contact stated while driving at approximately 40 MPH, the vehicle stalled. There was no warning light illuminated. The vehicle was towed to the residence. An independent mechanic diagnosed that the torque converter and the transmission needed to be replaced. The contact related the failure to an unknown NHTSA Campaign Number; however, the VIN was not included. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 104,000.Â
• Jul 2, 2025Power train
  Flashing! With gear around it and car will not operate correctly i.e. no power very slow acceleration and lacking ability to change gears.
• Aug 25, 2024Power train
  I have a 2004 Ford freestar van and I was driving down the road and I went to pass another vehicle and I push the gas and I heard some crunchy noise is and then nothing no power at all no gears nothing I was dead in the water so I had to get out of the van and push it to the side of the road didn't have reverse didn't have drive didn't have third second or first no gears at all the transmission failed me I could have been in a very bad accident and hurt it just came out of nowhere there was no signs of anything wrong with the van and then this happens.
• Mar 18, 2024Power train
  My son was driving down Rt 81 when the transmission stopped working Your vehicle was running fine but would not go had to drift off the highway she avoid getting hit I had to tow the van home we’re it’s still parked
• May 1, 2023 · 250,000 milesPower train
  The contact owns a 2004 Ford Freestar. The contact stated that while driving at various speeds the vehicle would not properly accelerate and would hesitate to accelerate and the check engine warning light would remain illuminated. The vehicle was taken to the local mechanic who diagnosed that the transmission torque converter was faulty and needed to be replaced. The vehicle was not yet repaired. The manufacturer and local dealer were contacted and informed that the VIN was not included in the NHTSA Campaign Number: 12V006000(Power Train). The contact indicated that the vehicle had experienced that same failure listed in the recall. The VIN was not available. The failure mileage was 250,000.
• Dec 16, 2022Engine
  Conducía mi vehículo y la trasmisión quedó en neutro en una entrada y no pude estacionarme Y no volvió arrancar Solo coje la reversa I was driving my vehicle and the transmission was neutral in a driveway and I couldn't park And did not start again Just take the reverse
• Sep 9, 2022Power train
  The transmission is grinding and popping when shifting gears.Also it has started not moving when I shift it into drive and 3rd and 1st.When I drive it I have to put it in 1st gear and change up to drive and it grinds and pops when giving it gas to go.It comes to a crawl going up hills.Has a big loss of power.The trackshion control light comes on saying it's not working.The electrical is messing up the doors are opening up when they are not supposed to going down road.It tells me that different doors are open when there not keeping the lights on in the van running down the battery.
• Aug 5, 2022Unknown or other
  I just purchased the vehicle used and recently discovered there was a recall on these vehicles. The vehicle I purchased keeps stalling and is not getting any power. I’ve had the vehicle checked by the car lot and they say there is nothing wrong.. the vehicle died out on me already twice while I was driving.

Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.

NHTSA defect investigations

• EQ12010 · opened Sep 28, 2012 · closed Dec 31, 2012Stabilus Rear Liftgate Struts Failing
  Please see the attached closing resume summary.It has been attached to this document as a PDF.
• EA12003 · opened Apr 23, 2012 · closed May 2, 2013 · led to recall 13V081000Corrosion of Third-Row Seat Attachment
  Ford is conducting a safety recall to repair the third-row seat's latch mechanisms in approximately 196,667 model year (MY) 2004 through 2007 Ford Freestar and Mercury Monterey vehicles (see NHTSA recall 13V-081 for more details).The recall covers vehicles originally sold, or currently registered, in the salt belt states or high corrosion areas of the United States: Connecticut, Delaware, the District of Columbia, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, and Wisconsin.Approximately 100,000 remaining MY 2004-2007 Freestar and Monterey vehicles--those vehicles that were not originally sold, or are not currently registered, in salt belt states--are not included in the recall action. Although these vehicles are the same as the ones described above,…
• PE11039 · opened Dec 21, 2011 · closed Apr 27, 2012Corrosion of Third-Row Seat Attachment
  ODI has received 18 complaints on the subject vehicles from the salt belt states that allege severe corrosion at the rear wheel wells.Additionally, ODI identified 4 similar reports from Ford's response to the investigation.Ford submitted a total of 10 reports to ODI (6 of 10 Ford reports are duplicates of ODI reports).The complaints indicated difficulty or inability to latch the rear seat as some of the complaints reported the entire anchor plate completely detached from the vehicle (rear wheel well).The first report of this condition was received in March 2011 and subsequent reporting frequency indicates a potentially increasing trend over time.ODI seeks to evaluate the potential occupant safety risks resulting from structurally degraded seat anchorages.In addition to the subject vehicles, ODI also will collect and review information on MY 2005-2007 Freestar/Monterey vehicles that…
• PE11033 · opened Sep 13, 2011 · closed Dec 7, 2012Service Jack Failure
  The subject vehicles (SV) are all automatic transmission, front wheel drive vehicles with hand actuated mechanical park brakes. The investigation focused on allegations that the service jack failed and caused the vehicles to fall. The subject scissors-type jack appears to fail at the slotted hinge joints where the jack screw is located (bends at mid-point). The failures occur while the jack is in use, and vehicle movement (forward or backward) is typically reported coincident with the failure. Ford reported that most MY 2003 Windstar and all MY 2006-2007 Freestar/Monterey also use the subject jack, an additional 223,246 vehicles.NHTSA has received six consumer complaints (VOQs) involving three injury incidents and a fatality.Ford reported 26 complaints for the SVs involving an additional 4 injuries. In the fatal incident, the van fell on a person working on the engine under the…
• PE10033 · opened Aug 23, 2010 · closed Jul 15, 2011Engine Stalling
  The subject vehicles suffered from a design issue whereby water could run down onto the cowling under the hood and located in the area of the windshield wipers and then drip onto a computer module, the Powertrain Control Module (PCM), which could be manifested in a variety of symptoms depending on which part of the circuit board became wet or which of the connector pins shorted out.In addition to causing an engine to stall, which may or may not then restart, the water intrusion could also cause the transmission to shift poorly, the vehicle to have erratic power, a malfunction indicator light to come on, or result in an inability to start the vehicle, an inability to shift the vehicle into either forward or reverse. Also the problem could cause a higher than normal idle RPM in Park, or for the radio to malfunction, or the interior lights to stay on.During this investigation ODI was…
• EA09016 · opened Nov 10, 2009 · closed Feb 2, 2012 · led to recall 12V006000Transmission Torque Converter Failure
  On January 4, 2012 Ford Motor Company submitted a Defect Information Report (NHTSA Recall No. 12V-006) to NHTSA regarding a defect in the performance of the transmission torque converter for approximately 205,896 Ford Freestar and Mercury Monterey vehicles.The supplier of the torque converter manufactured converters containing a pump shaft spline that did not consistently meet the specified heat treatment requirements.In normal use, the spline may wear excessively and eventually fails without warning.If a torque converter malfunctions due to a sheared pump drive spline, the vehicle will abruptly lose motive power.This problem affected model year 2004 and 2005 Freestar and Monterey minivans.During the investigation NHTSA identified 532 complaints alleging incidents of vehicle stall while driving due to torque converter failure.These failures were sudden and without any prior warning.Of…
• PE09033 · opened Jul 15, 2009 · closed Nov 17, 2009TORQUE CONVERTER OUTPUT SHAFT FAILURE
  ODI HAS RECEIVED 227 OWNER COMPLAINTS ALLEGING A SUDDEN AND UNEXPECTED LOSS OF MOTIVE POWER DUE TO AN INTERNAL TRANSMISSION FAILURE IN THE SUBJECT VEHICLES.OF THOSE COMPLAINTS, 124 CAN BE ATTRIBUTED TO THE TORQUE CONVERTER OUTPUT SHAFT SPLINES STRIPPING CAUSING A SUDDEN LOSS OF POWER TO THE DRIVETRAIN.THE REMAINING 103 COMPLAINTS EXPERIENCED A LOSS OF MOTIVE POWER BUT THE SPECIFIC INTERNAL FAILURE CAUSE WITHIN THE TRANSMISSION IS NOT KNOWN.ODI HAS UPGRADED THE INVESTIGATION TO AN ENGINEERING ANALYSIS (EA09-016) TO CONTINUE ITS ASSESSMENT OF THE SCOPE, FREQUENCY AND SAFETY-RELATED CONSEQUENCES OF THE ALLEGED DEFECT.
• DP09004 · opened Jun 4, 2009 · closed Sep 7, 2010Engine stalling
  On May 6, 2009, NHTSA received a request for a hearing through Title 49 of the United States Code, Chapter 301, Motor Vehicle Safety, Part 557. the request was in reference to vehicle owner complaint, 10266067, filed with NHTSA on April 20, 2009, which described a problem with engine stall in a model year (MY) 2004 Ford Freestar minivan due to water entering the PCM.Part 557 of Title 49 of the Code of Federal Regulations establishes procedures for holding a hearing to determine whether a manufacturer has reasonably met its obligation to notify owners of a safety related defect.Because a safety related defect has not been determined regarding the alleged defect in MY 2004 Ford Freestar vehicles, the Office of Defects Investigation interpreted the request as a defect petition under Part 552 of Title 49 of the Code of Federal Regulations.In response to the Information Request letter sent…