*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.
Unknown or other
We are writing to formally escalate catastrophic and highly dangerous safety failure issues involving a Braun Millenium Lift, hydraulic oil explosion, failure of the emergency back up pump, severe structural defects, a sagging floor near wheelchair tie downs and the rear passenger seat and a four year pattern of negligence from the dealer that installed Braun Lift. We had the van into dealer about this issue many times. They adjusted something and would say every things ok. In August 2026 my husband took van in for maintenance and service manager told him she had 3 of her men stand on lift and it went up fine. It was a continuous issue. On 9/24/26 after leaving a restaurant our paralyzed…
Oct 8, 2026Seat belts
The passenger side seat belt locks up at unusual times. Passenger canât reach anything because they are locked in their seat. The seatbelt has locked up numerous times however the mechanic canât repeat the problem in the shop. Yes is has been reported and investigated by TASCA Ford, 1300 Pontiac Ave., Cranston, RI. No indications before the seatbelt locks up.
Jun 12, 2024Visibility › Windshield
The contact owns a 2021 Ford Transit. The contact stated that while parked and having an oil change sticker applied to the top of the driver's side windshield, the glass detached half an inch and water had since entered the vehicle through the crack. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was 92,000.
Mar 1, 2026 · 92,000 milesElectrical system › Instrument panel › Speedometer/odometer
Odometer Fraud. The contact purchased a 2021 Ford Transit. It was discovered that there was a mileage discrepancy. The vehicle was a dealer sale. At the time of purchase, the vehicle mileage was 33,000; and at the time of registration, it was discovered that the mileage was 320,000.
Jan 13, 2026 · 320,000 milesAir bagsCrash2 injuries
The contact owned a 2021 Ford Transit. The contact stated that while driving the 2021 Thor Gemini at 65 MPH in the wind, the wind veered the vehicle off the road. The vehicle rolled over and down an embankment when it came to a stop. Â No warning lights were illuminated. The side curtain air bag and front passenger-side air bags deployed. However, the driver-side air bags did not deploy. A police report was filed. The contact and his wife were taken to the hospital via ambulance. The contact sustained a concussion, while the contact's wife was severely injured in the right eye due to the air bag and sustained a concussion. The vehicle was towed to Ricky's Towing, a local towing yard. The…
Mar 27, 2025 · 25,000 milesTires
The contact owns a 2021 Ford Transit 250 equipped with Sentury Lionheart Tires, Tire Line: Lionclaw, Tire Size: 235/65/R16, DOT Number: [XXX] . The tires were replacement tires. The contact stated while driving approximately 40 MPH, there was an abnormally loud sound coming from the front end of the vehicle, and the vehicle started shuddering and vibrating. After stopping to inspect the vehicle, the contact noticed a blowout of the front driver's side tire. Upon inspection, it was discovered that the front passengerâs side tire was cracked by the side wall. The cause of the failure was not yet determined. The manufacturer and local tire dealer were notified of the failures. No further…
Nov 21, 2025 · 20,000 milesPower train
The contact owns a 2021 Ford Transit. The contact stated that while driving 65 MPH in the middle lane, the vehicle lost motive power with the âWRENCHâ warning light illuminated. The contact pulled over, turned off, and was able to restart the vehicle and continued driving. Two days later, the âWRENCHâ light illuminated again. The vehicle was taken to a local dealer, where it was diagnosed and determined that the transmission needed to be replaced. The vehicle was not yet repaired. Subsequently, the vehicle was taken to a transmission center, and it was determined that the transmission needed to be replaced. The manufacturer was contacted, opened a case, and requested the vehicle…
Aug 7, 2025 · 79,469 milesWheels
Issue is with Hankook tires. Mileage on original OEM tires on my campervan from Ford. 44,600 miles. Good tread, air pressure checked daily on trips. Date code of manufacture of tires: 41st week, 2020. Took ownership of campervan on Dec 6th, 2021. Travel west on I-696 at 70 mph. Driverâs left front tire exploded. I did not hit anything in the road way. In the second lane from right side of freeway. Was able to safely move to the shoulder of the freeway. Tread completely came off the tire. Broke bumper, damages sensors, bent floor pan, and cracked driver side step. Insurance claim filed with Progressive Insurance, and will be inspected on Aug 22nd. Tires will be replaced on Aug 12th at…
Aug 5, 2025
Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.
