Model year record
2002 GMC C/K Pickup recalls & problems
The 2002 GMC C/K Pickup has no safety recalls on file with NHTSA, and 5 owner complaints. The most-reported problem area is service brakes, hydraulic (2 complaints).
Safety recalls
No safety recalls have been filed for the 2002 GMC C/K Pickup.
Recall repairs are free at any authorised dealer. A recall listed here may already have been fixed on a particular car: enter its 17-character VIN at nhtsa.gov/recalls to see open recalls.
What owners report
| Problem area | Complaints | Typical mileage* |
|---|---|---|
| Service brakes, hydraulicFoundation components › Disc › Rotor | 2 | — |
| Air bags | 1 | — |
| Electrical systemWiring › Interior/under dash | 1 | — |
| Trailer hitches | 1 | — |
*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.
Recent owner complaints
- Service brakes, hydraulic
WHILE ATTEMPTING TO STOP IN MY DRIVEWAY, I LOST BRAKING POWER... PEDAL WENT TO THE FLOOR AFTER A FEW PUMPS. BRAKE FLUID OUT ON THE GROUND. INSPECTION REVEALED REAR BRAKE LINE FAILURE BECAUSE OF CORROSION. THE TRUCK HAD 56,337 MILES AT THE TIME. IN SEPTEMBER 2011, THE FRONT LINES FAILED BECAUSE OF CORROSION WHILE OUT DRIVING ON THE ROADS. THE CORROSION WAS SEVERE OVERALL AND I HAD THE ENTIRE FRONT BRAKE LINE SYSTEM REPLACED FROM THE MASTER CYLINDER DOWN RATHER THAN THE PARTIAL BRANCH THAT HAD BURST. AT THE TIME OF THE FRONT LINE FAILURE, THE VEHICLE ONLY HAD 58,555 MILES ON IT. IT IS WORTH NOTING THAT THE CORROSION WAS ESPECIALLY SEVERE AT THE CONTACT POINTS: WHERE FASTENERS HELD THE LINES…
- Service brakes, hydraulic › Foundation components › Disc › Rotor
FAULTY DISC BRAKE ROTORS ON GENERAL MOTOR CARS AND TRUCKS. EVEN THOUGH G.M. DEALERS ACKNOWLEDGE PROBLEM REFUSE TO CORRECT WITHOUT OWNER PAYING. COULD POSSIBLY CAUSE ACCIDENT ON BRAKE FAILURE.*AK
- Trailer hitches
GENERAL MOTORS HEAVY DUTY HITCH ON 1999-PRESENT TRUCKS & SUVS. RATED FOR 1500 LBS TOUNGE WEIGHT & 15,000 LBS TOTAL W/WEIGHT DIST. FLEXES UNDER LIGHT LOAD COMNDITIONS WHEN USING WEIGHT DISTRUBITION. POTENTIAL METAL FATIGUE AND FAILURE(TRAILER BREAKING LOOSE) NOTHING WAS DONE BY MY DEALER, I REPLACED THE HITCH MYSELF WITH AN AFTERMARKET PRODUCT.*AK
- Electrical system › Wiring › Interior/under dash
INSTRUMENT PANEL FAILED COMPLETELY WITHOUT WARNING. *AK
- Air bagsCrash1 injury
ONE OF OUR 2002 GMC PICKUPS WAS INVOLVED IN A FRONTAL COLLISION THAT WAS SEVERE ENOUGH TO BEND THE FRAME AND TOTAL THE TRUCK BUT THE AIR BAGS DID NOT DEPLOY. DUE TO THE AMOUNT AND TYPE OF DAMAGE I BELIEVE THERE IS A PROBLEM. I CONTACTED GM CUSTOMER SERVICE BUT THERE DID NOT SEEM TO BE ANY INTEREST. *JB
Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.
NHTSA defect investigations
- PARKING BRAKE FAILUREClosedLed to recall 05V161000
IN A LETTER DATED APRIL 20, 2005, GM NOTIFIED NHTSA THAT IT HAD DECIDED THAT DEFECTS THAT RELATE TO MOTOR VEHICLE SAFETY EXIST IN CERTAIN MODEL YEAR (MY) 1999-2002 C/K 1500 SERIES (PBR PARKING BRAKE SYSTEM) AND MY 2001-2005 C/K 2500 AND 3500 SERIES (TRW PARKING BRAKE SYSTEM) PICKUPS WITH MANUAL TRANSMISSIONS.ACCORDING TO GM, SOME OF THESE VEHICLES MAY HAVE CONDITIONS THAT CAUSE THE FRICTION LININGS TO WEAR TO AN EXTENT WHERE THE PARKING BRAKE CAN BECOME INEFFECTIVE IN IMMOBILIZING A PARKED VEHICLE.GM'S ACTION COVERS AN ESTIMATED TOTAL OF 142,585 VEHICLES.DEALERS WILL INSTALL A LOW-FORCE SPRING CLIP RETAINER FOR VEHICLES EQUIPPED WITH THE PBR PARKING BRAKE SYSTEM AND INSTALL A REDESIGNED PARKING BRAKE CABLE ASSEMBLY ON VEHICLES EQUIPPED WITH THE TRW PARKING BRAKE SYSTEM. A TOTAL OF 58 NON-DUPLICATIVE COMPLAINTS WERE RECEIVED BY ODI AND GM CONCERNING THE APPROXIMATELY 59,000 MY 1999-2002…
- PARKING BRAKE FAILUREClosed
ODI OPENED PE03-057 TO ASSESS PARKING BRAKE INEFFECTIVENESS IN THE SUBJECT VEHICLES.THESE VEHICLES ARE EQUIPPED WITH FOUR WHEEL DISC BRAKES THAT INCORPORATE A SINGLE-SHOE DRUM-IN-HAT PARKING BRAKE INDEPENDENT OF THE SERVICE BRAKES.COMPLAINT AND WARRANTY DATA INDICATE THAT THE PARKING BRAKE LININGS TEND TO WEAR OUT EARLY IN THE LIFE OF THE VEHICLE (AT AN AVERAGE OF 24 MONTHS IN SERVICE), REDUCING THE PARKING BRAKE SYSTEM'S TORQUE BELOW THAT NEEDED TO IMMOBILIZE THE VEHICLE.GM HAS ATTRIBUTED THIS ACCELERATED WEAR TO FOREIGN MATERIAL INTRUSION AND A FAILURE OF THE BRAKE SHOE TO PROPERLY SELF-CENTER WITHIN ITS BRAKE DRUM.EFFECTIVE WITH THE START OF MY 2003 PRODUCTION, A NEWER REDUCED FORCE HOLD-DOWN CLIP WAS INTRODUCED TO FACILITATE BRAKE SHOE DISENGAGEMENT FROM THE DRUM SURFACE.THIS PART IS ALSO AVAILABLE AT THE SERVICE LEVEL FOR THE MY 1999-2002 VEHICLES.GM HAS INDICATED THAT THE PAKING…