Model year record

2003 GMC C4500 recalls & problems

The 2003 GMC C4500 has 1 safety recall and 6 owner complaints on file with NHTSA. The most-reported problem area is service brakes, hydraulic (2 complaints).

Recalls1safety recalls

Complaints6filed by owners

Crashes · fires0 · 0reported in complaints

Injuries · deaths0 · 0reported in complaints

Safety recalls

SuspensionJul 26, 2002

Rear

Recall 02V202000952 vehicles

Problem: CERTAIN MEDIUM DUTY TRUCKS EQUIPPED WITH 11,000 LB. REAR AXLE HAVE A CONDITION WHERE THE REAR AXLE ANCHOR PLATE MAY FRACTURE. AS THE ANCHOR PLATE FRACTURES, THERE IS AN AUDIBLE "BANG." IF THIS INDICATION OF A CONDITION REQUIRING THE DRIVER'S ATTENTION WENT UNNOTICED OR WAS IGNORED, AND UNDER CERTAIN REBOUND, BRAKING, OR CORNERING MANEUVERS, THE REAR AXLE WOULD BE FREE TO MOVE FORE AND AFT AND PROVIDE UNEXPECTED STEERING INPUTS TO THE VEHICLE.
Risk: IF THIS HAPPENS WHILE THE VEHICLE IS MOVING, A CRASH COULD RESULT.
Fix: DEALERS WILL INSTALL A NEW REAR AXLE ANCHOR PLATE AND SPACER. OWNER NOTIFICATION BEGAN AUGUST 16, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782.

Recall repairs are free at any authorised dealer. A recall listed here may already have been fixed on a particular car: enter its 17-character VIN at nhtsa.gov/recalls to see open recalls.

What owners report

Problem area	Complaints	Typical mileage*
Service brakes, hydraulicPower assist › Hydraulic; Foundation components › Disc › Caliper	2	—
Power trainDriveline › Differential unit	2	—
Exterior lightingHeadlights	1	—
Engine and engine cooling	1	—
Tires	1	—

*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.

Recent owner complaints

Tires
PURCHASES TIRES IN JUNE 2009 -- UPON INSPECTION THIS WEEKEND 4/11/2010 WE NOTICED LARGE CRACKS IN THE TIRES ALMOST LIKE IT WAS SEPARATING. WE BROUGHT THEM TO THE DEALER AND THEY CHARGED US $100 TO REPLACE THEM AFTER ADMITTING THAT THE TIRES HAD FAILED AND WERE DEFECTIVE. *TR
Apr 11, 2010 · 240,000 miles
Power train
THROW BEARING WEARS OUT EVERY 40,000 KM. BELL HOUSING GONE AT 180,000 KM'S, REAR END WORE OUT AT 182,000 KMS AND FORTH GEAR GONE IN TRANSMISSION AT 183,000, DASH CLUSTER GONE AT 188,000. MANUFACTURE OR DEALER WOULD NOT COVER ANYTHING. *NM
May 10, 2006 · 180,000 miles
Engine and engine cooling
VEHICLE EXPERIENCED SUDDEN STALLING AT VARIOUS SPEEDS WHEN ON THE ROAD. TAKEN TO THE DEALER 10 TIMES FOR CHECKUP, BUT THE CAUSE WAS STILL UNDETERMINED.*AK
May 3, 2004
Power train › Driveline › Differential unit
VEHICLE WAS EXPERIENCING A PROBLEM WITH GREASE FROM THE REAR END LEAKING ONTO THE LEFT REAR WHEEL BRAKING SYSTEM. THIS CAUSED LOSS OF BRAKING IN THAT WHEEL. DEALER REPLACED THE GREASE SEAL WITH AN UPGRADED SEAL SIX TIMES, PROBLEM RECURRED. *AK REAL GREASE SEAL WAS REPLACED. THE DRIVER SIDE BRAKE CALIPER BOLT FELL OUT CAUSING THE CALIPER TO RUB THE INSIDE OF THE INNER DUAL WHEEL CAUSING DAMAGE TO THE CALIPER AND WHEEL. *TC
Jan 5, 2005 · 3,300 miles
Service brakes, hydraulic › Power assist › Hydraulic
MY ENGINE STALLED DUE TO CONTAMINATED FUEL. WITH THE KEY STILL IN THE ON POSITION, I ATTEMPTED TO STOP. I PRESSED THE SERVICE BRAKE PEDAL. THE BACKUP BRAKE SYSTEM DID NOT OPERATE. I REPEATED PRESSING THE BRAKE PEDAL TWO MORE TIMES. I UNDERSTOOD. I WAS CLOSING THE DISTANCE BETWEEN MY VEHICLE AND THE ONE IN FRONT OF ME APPROACHING THE TRAFFIC SIGNAL, RED. THE BRAKE PEDAL SWITCH FAILED TO INITIATE THE RELAYS AND PUMP. CONSEQUENTLY, THE VEHICLE HAD PRACTICALLY NO BRAKES OTHER THAN THE DRUM BRAKE BY HAND BRAKE HANDLE. I APPLIED THE HAND BRAKE. GOOD THING I WAS ONLY TRAVELING AT LESS THAN 30 MILES PER HOUR, WITHOUT CARGO, AND HAD MORE THAN 400 FEET TO STOP. I ALMOST HIT THE VEHICLE IN FRONT AT…
Oct 1, 2004 · 79,000 miles
Exterior lighting › Headlights
WHEN THE VEHICLE REACHED A SPEED OF 50 MPH, THE HEAD LIGHTS DIMMED. *JB WHEN THE LIGHTS ARE ADJUSTED PROPERLY, THEY DO NOT ALLOW THE PROPER LIGHT ON THE ROAD AT SPEEDS GREATER THAN 50 MPH. DEALER DID NOT SEE THE PROBLEM. SCC
Mar 19, 2003

Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.