1996 GMC Savana recalls & problems

Safety recalls

Recall repairs are free at any authorised dealer. A recall listed here may already have been fixed on a particular car: enter its 17-character VIN at nhtsa.gov/recalls to see open recalls.

Fuel economy

EPA estimates from fueleconomy.gov for each engine and transmission sold. Annual cost is the EPA's estimate for 15,000 miles a year at its current fuel and electricity price assumptions. Your results will vary.

What owners report

*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.

Recent owner complaints

• Visibility/wiper

  WINDSHIELD WIPERS STOPPED WORKING AT RANDOM.

  Feb 1, 2008 · 94,000 miles
• Fuel system, gasoline › Delivery › Hoses, lines/piping, and fittings

  DT*: THE CONTACT STATED THERE IS A STRONG ODOR OF GASOLINE. THERE IS A NHTSA RECALL, # 00V110000, REGARDING THE FUEL SYSTEM GASOLINE DELIVERY HOSES, LINES/PIPING AND FITTINGS. THE VIN WAS NOT INCLUDED IN THE RECALL. UPDATE 05/30/2006. *AK *TS

  Apr 27, 2006 · 147,500 miles
• Structure › Body › Door › Hinge and attachments

  THIS IS A COMMERCIAL VEHICLE USED IN TRANSPORTING INTERIOR DECORATING ITEMS. ON OR ABOUT 8/2/04, I DELIVERED A TABLE TOP TO A CLIENT AND UPON OPENING THE REAR SIDE DOORS (BOTH DOORS) THE UPPER HINGE ON THE FURTHERMOST REAR DOOR BROKE. I HAD NOTICED A RATTLING SOUND PRIOR TO THIS DATE, HOWEVER I THOUGHT IT WAS ITEMS INSIDE THE VEHICLE. THE DOOR IS ONLY BEING HELD ON BY THE LOWER HINGE AND THE OTHER DOOR CLOSED UPON IT. I AM FEARFUL THAT THE OTHER HINGE WILL SUFFER A STRESS FRACTURE AND POSSIBLY THE DOOR WILL FALL OFF. I RESEARCHED THROUGH THIS SITE AND FOUND TWO INCIDENTS OF SERVICE BULLETINS (SEPTEMBER 24, 2001 AND JUNE 1,2003) NOTIFYING THAT CUSTOMERS HAVE COMPLAINED THAT THE DOOR HINGE…

  Aug 2, 2004 · 65,350 miles
• Visibility › Windshield wiper/washer

  THE WINDSHIELD WIPERS WORKED INTERMITTENTLY. RECALL 03V159000 WAS ISSUED WHICH DESCRIBED THE EXACT PROBLEM. BUT THE CONSUMER'S VEHICLE IDENTIFICATION NUMBER WAS NOT INCLUDED IN THE RECALL. *AK THE WIPERS WOULD ALWAYS WORK WHEN ON HIGH SPEED. THE CONSUMER FELT THAT HIS VEHICLE EXPERIENCED THE SAME PROBLEM AS IN RECALL# 03V159000. *SC *JB

  Apr 17, 2000
• Visibility › Windshield wiper/washer

  WINDSHIELD WIPERS FAILED TO OPERATE. INTERMITTENTLY WILL NOT WORK ON INTERMITTENT OR LOW SPEED. DEALER ADVISED MY VEHICLE NOT RECALLED WITH NUMEROUS OTHERS RECALLED FOR SAME PROBLEM.*AK

  Mar 1, 1998 · 20,000 miles
• Fuel system, gasoline › Delivery › Fuel pump

  1996 GMC SAVANA VAN- FUEL PUMP FAILURES AT 40,000 MILES AND 75,000 MILES. $600 REPAIR EACH TIME. HIGH FAILURE ITEM LASTING LESS THAN A SET OF TIRES, MAJOR REPAIRS NEEDED. THIS *HAS* TO BE A MANUFACTURING DEFECT. THIS IS A COMMON FAILURE PER THE GM DEALER.*JB

  Dec 4, 2003 · 40,000 miles
• Visibility › Windshield wiper/washer › Motor

  WINDSHIELD WIPER MOTOR QUIT WORKING WHILE DRIVING IN A SEVERE THUNDER STORM. AFTER PULLING TO THE SIDE OF THE ROAD THE WIPERS STARTED WORKING INTERMITTENTLY. *JB

  Mar 29, 2003 · 67,000 miles
• Engine and engine cooling › Engine › Gasoline

  START THE ENGINE PUT THE VEHICLE INTO GEAR REVERSE OR DRIVE AND THE THROTTLE IS STUCK IN THE CLOSED POSITION MY WIFE AND I HAVE SEARNED TO EITHER SET THE THE VEHICLE PROCEED AT IDLE TIL ANY DANGER OF UNINTENDED ACCELLERATION IS NOT PRESENT THEN PUSH TAP. THE ACCELLERATOR PEDAL UNTIL IT BREAKS LOOSE AND HAS FREE TRAVEL SO FAR THE ACCELLERATOR ONLY STICKS ON INITIAL STARTUP OF THE ENGINE EITHER HOT OR COLD. I AM WRITING THIS BECAUSE OF READING A TRADE PUBLICATION REPORTING AN INVESTIGATION IN 98-99. DT

  Dec 4, 2002

Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.